2007 MERCEDES-BENZ E350 Complaints

FUEL TANK AND FUEL PARTS LEAKING. 2 REPAIRS AND CAR OFTEN SMELLS OF GASOLINE ESPECIALLY IN THE GARAGE.

Fuel tank fuel leak, NHTSA Action Number EA13003 I purchased a 2007 Mercedes E Class used a few months ago, and recently I noticed a fuel leak, strong fuel smell outside of vehicle when fuel tank is filled higher. More fuel means more fuel odor. Upon research, it seems like there was a warranty extension for 15 years, and with my luck, warranty extension ran out just after I bought the car but before I noticed the problem. As fuel is a safety issue and can easily ignite, and also affects emissions, I feel like the remedy should not just be a 15 year warranty extension, but longer as cars are staying on the road longer and longer. I'm sure I'm not the only one with this issue out of warranty extension period.

2007 MERCEDES BENZ E 350. CONSUMER WRITES IN REGARD TO ILLUMINATED CHECK ENGINE LIGHT.

Due to the odor of gasoline both inside and outside my car I brought my car to the local Mercedes’ dealership. Upon inspection they found a small crack in my fuel tank which allowed gasoline to leak into another compartment. The dealer stated they would not be able to replace fuel pump without replacing the gasoline because of the “danger and risk of fire”. I believe that the leakage of gasoline and the fumes associated inhaled presents a very real danger, and risk to health. Upon research I found that this is a major issue that has been addressed by your department. After a 3 year investigation this investigation was closed due to the extension of the manufactures warranty to 15 years. My car is 8 months out of the extended warranty. When speaking to Mercedes’ Benz hotline, the representative stated receiving several phone calls recently with reports of the same issue. I appreciate your attention to this matter. I am hoping this case with be reopened, and the manufacturer held responsible for replacing faulty fuel tanks.

Vehicle fuel system known component issue, fuel pump failure, intermittent. Driving vehicle can lose power at speed, causing potential loss of control as hydraulic assist to steering and braking fails with engine. This known issue has intermittently cause our car to fail to start, or fail in operation. This was a known issue, the manufacturer was allowed to avoid a recall by extending the warranty for this component (fuel pump in fuel tank assembly) to 15 years. Our car started showing this around that time (3 months ago, when extended warranty expired), however we were not then aware of said warranty. Now that we've been two months of diagnosis and discussions with MBUSA Customer Care, they are not willing to replace the known failure point as warranty expired 3 months ago. This should have been a recall from the beginning, and now we, and many others to come, will have the value and usefulness of our vehicles reduced or eliminated. Those not aware of the potential failure of this very expensive part, will be at risk every time they operate their cars at speed on the public highways. NHTSA should never have allowed this warranty extension scheme to substitute for a recall. There is no way to predict failure, and entire fuel tank assembly replacement is <$4,000. Fuel pump is not individually accessible or available for replacement, only entire tank assembly in these PZEV vehicles is available. Mercedes-Benz is shirking responsibility here, and flipping it over to the dealerships and consumers.

The contact owns a 2007 Mercedes-Benz E350. The contact stated while driving approximately 65 MPH, the check engine warning light illuminated and with an abnormal sound coming from the gear shifter. The contact stated there was a failure with the transmission and the vehicle would not exceed 65 MPH. The transmission was replaced. The contact was unable to reach the manufacturer; however, several voicemails left for the manufacturer. The approximate failure mileage was 100,000.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that while the vehicle was parked in the garage and turned off, the entire rear end of the vehicle inadvertently lowered to the ground. The contact stated that the failure was related to NHTSA Campaign Number: 12V264000 (Suspension) however, the vehicle was not included in the recall. The vehicle had not been diagnosed or repaired. The manufacturer and the dealer were not made aware of the failure. The approximate failure mileage was 140,000. The consumer stated the rear air suspension is functioning as designed. Upon restarting the vehicle the air compressor was recharged.

The component/s that have failed are (reputedly) the fuel system resulting in significant fuel fumes permeating into the cabin of the vehicle as well as being very evident around the rear outside of the vehicle. This seems to be more obvious after the car has been filled with fuel. Having fuel fumes leaking into the cabin of the car should be self evident as a risk to anyone travelling in the vehicle, especially in the rear seats. The fumes eminating from the car, externally, are a potential fire hazard should anyone walk by with a cigarette or naked flame. This is an on going problem well known to Mercedes Benz and one that should have been the subject of immediate recalls by MB and not subject to a Mileage, Time Frame or VIN number. Why should I, or anyone, have to foot a fairly significant bill, for fixing a manufacturing fault just because the previous owners didn't get the problem fixed and I purchased the vehicle after some 15 year warranty time frame? This issue could result in someone's death if Mercedes is not forced to remedy it and by remedy it I mean for ALL 2007 E350's to be recalled unconditionally. Consumer would like to amend the complaint to include the recall of ALL Mercedes E350 for the years 2006 and 2009 for inspection of the cause of the problem and the repair of those vehicles where repairs are needed at Mercedes Benz cost.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that while the vehicle was parked with the engine running, the contact heard a loud rattling sound coming from the engine compartment. The contact called an independent mechanic and was informed that the camshaft balancer was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 257,000.

The contact owns a 2007 Mercedes-Benz E350. The contact stated that the vehicle leaked gasoline into the rear driver’s side seat causing a pool of gasoline under the seat. The contact stated that the check engine warning light was illuminated. The vehicle was diagnosed but not yet repaired. The manufacturer was informed of the failure. The contact was provided information of a possible manufacturer’s recall. The failure mileage was approximately 104,000.