2011 MERCEDES-BENZ E350 Complaints

The known Subframe rust recall issue has caused the brake lines to rust and mercedes in St Louis wont cover the expense to fix this known extra problem. They want $2200.00 to fix the brakes that other dealers would charge half for. They want to escape this problem and I just want this fixed at their cost.

Driving on interstate, hit the brakes and noticed the car was swaying hard to the left. After that it progressively got worse. When hitting even the smallest bump or braking I heard a metal on metal ‘thunk’ sound. My daughters were in the car and it was frightening. Upon further inspection by a Mercedes mechanic, the secondary frame had rusted and snapped into. After reading forums online I found it’s very common. They rust from the inside out. There was absolutely NO previous warning.

The contact owns a 2011 Mercedes-Benz E-350. The contact stated while driving at various speeds, the steering wheel would occasionally become difficult to maneuver. The contact stated the power steering fluid was previously refilled. The air bag warning light was illuminated intermittently. Additionally, the contact stated that there was an unusual amount of smoke coming from under the hood occasionally. The vehicle was taken to an independent mechanic, where it was diagnosed that the power steering fluid might have leaked. The mechanic could not determine the cause of the failure. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 108,000.

The contact owns a 2011 Mercedes-Benz E350. The contact received notification of NHTSA Campaign Number: 16V081000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer and another dealer, Mercedes-Benz of Sacramento (1810 Howe Ave, Sacramento, CA 95825) were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and a case was opened. The contact had not experienced a failure. Parts distribution disconnect.

I bought my vehicle to the Mercedes dealership to get the rear subframe replaced under extended warranty due to it being rusted and broken from the rear suspension attachment points. While the Mercedes technician had the subframe removed he noted that the rear brake lines which are routed under the body and between the subframe had significant rust/corrosion on them.

With less than 40,000 miles on the odometer, I noticed a gas smell both inside the car and outside. I was able to access the fuel filter assembly on the top of the gas tank and found it had a substantial leak resulting in a puddle of fuel on the assembly. The car has never been in a wreck on had any damage that would cause this problem. I researched and found earlier years of the same model had this problem resulting in Mercedes Benz extending the warranty to 150,000 miles for this part. They have refused to warranty my car. This is a major safety issue and by releasing gas fumes into the atmosphere is an environmental problem as well.

The passenger front air bag malfunction,the passenger seat head rest deployed and And malfunction with any incident,the driver air bag is light on malfunction.after I took it to the dealership radio stop working no audio

While driving at approximately 55mph on the highway, I was required to brake for a merging vehicle who decided to make a lane change at the last second. I used my breaks, and my car did not break correctly. Instead, the car pulled the the right and locked up, it felt as though I had lost control of the car. When I went to my mechanic, I thought it was a break issue. Instead, it turns out the whole rear sub frame had rusted. When researching this issue, I found many other similar experiences. The harm that this part failure lead to was extreme. This could have been deadly. This is a safety issue that the manufacturer does not address.

The sunroof detached and the water from the rain leaked through the faulty sunroof into the interior doors, floorboard and dashboard. This happened to both the passenger side and the driver side. It was repaired out of pocket because of the hazard and lack of dealership accountability. Because the dealership wanted to charge $1000 to provide a water intrusion inspection so we went to an a MB authorization independent mechanic to repair the vehicle.This leaking lead to the growth of mold and lack driver visibility.Lastly they were no warnings before the leak happened.

There is a strong odor of gasoline inside the passenger compartment and around the outside of the vehicle when the gas tank is filled. A previous maintenance code of 0456 was triggered. Several repairs have been done to try and solve this problem, but the issue still remains. There is currently no recall for this specific VIN model but Mercedes Benz have issued the recall for other models with the same issue.