2011 MERCEDES-BENZ E350 Complaints

The rear subframe has prematurely rusted. It had a shear failure at speed on the highway when I applied the brakes. The rear end of the car swerved, almost causing me to crash. I did manage to decelerate the car in a controlled fashion. I did not know the rear subframe failed at the time. This was confirmed by an independent mechanic several days later. After research, it looks as though a recall has already been issued for this issue in Canada and potentially Germany. The mechanic tells me that until the issue is repaired the vehicle is unsafe to drive. My and others safety was put at risk due to the failure of vehicle control at 65 mph on a busy road. The problem was verified by an independent mechanic. No police, insurance provider, or Mercedes dealer has inspected the car/damage, only an independent mechanic. No prior indicators were given either directly or indirectly prior to failure. I did keep the part for inspection upon request.

Rear subframe corrosion/damage leading to rust/holes and unsafe driving. This issue can cause the bottom of the vehicle to collapse. Mercedes Benz across many countries acknowledge this as a recall and repairs free of charge except USA. USA should acknowledge this defect as well.

Rear subframe corrosion causing rear subframe failure/rusting which is a huge hazard. Mercedes Benz in several countries have recalled the rear subframe and are replacing free of charge. Mercedes Benz USA is not acknowledging this recall, it is a major issue and thousands are impacted.

Rear subframe is rusting out. I reported about a month or two ago and have not heard back from you.

I noticed about to 6 months or less that my car would shut off or stall after starting ignition and also hearing water sloshing behind the dashboard and the radio does not work and the rear camera goes on/off which is safety hazard, and the Engine symbol remain lighted up even after checking all components. Also, on a few occasion my floorboard in the passenger back seat would be soak and wet. I took the car to my mechanic, and he inform that the drain valve was not working properly. after doing some research on the internet I found that this particular incident was happening in several of Mercedes years 2009-2011 E50, that it was a recall on the water drain system. Also, on 01/17/23 my sunroof was working without any problems, I attempted to close it and it stop midday and i hear the motor working, but the sunroof did not move, I did more research and found a recall on the bonding glue for sunroof and the glass was detached without warning. Even though my vehicle is not on the recall list, my car is having the same exacts problems and issues and reported by NHTSA. I would appreciate as response or advice to solve these problems, right now my car is a safety hazard to myself and other drivers. thank you for cooperation in this matter in advance. My Case from Corporate Mercedes Customer Care#[XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I was on the highway traveling at 70 mph, when I noticed something was not right. I would switch lanes and notice the vehicle swaying in the rear I would also brake, and notice car would sway. I didn’t have any warning signs, and have deemed my vehicle unsafe to drive. Upon further inspection, I noticed that the rear subframe has been compromised with rust, fully detaching the lower control arm from driver’s side rear. This incident could have been catastrophic. I could have easily loss control of the vehicle and death could have occurred to me and others. Perhaps the whole rear axel and wheels could have detached at high speeds

There is a hole rusted through the vehicle's rear subframe assembly and it is dangerous to drive. My car is an E350 Mercedes with 78,000 miles and garage-kept. Mercedes knows of this issue and is not helping anyone with this problem. The job costs about 5000.00 to fix.

The subframe is rusting in four places in the area of the wheels. If the frame breaks I could lose control of the vehicle

Rear sub-frame is starting to rust/corrode. Understand from my repair shop that similar problems have been identified in other models using same rear subframe (W204 2008-2014 C-Class). Failure of the rear subframe may result in tire detachment and possible rupture of the fuel tank by metal fragments (per the repair shop).

I noticed fluid on the ground under my car in the driveway. Turns out it was brake fluid, the vehicle alerted me to low brake fluid. Here was a broken brake line which appears to have been caused by the subframe being rusted out. The issue is with the rear subframe on the Mercedes’ E and C class dating from 2008 on. Mine is a 2011 E class. The subframes on these vehicles rust and rot out causing issues to the brake lines and rear suspension parts rotting / rusting out due to the subframe being compromised. I’ve taken my vehicle to the dealer to look at the brake line and I was advised that the subframe was rusting out and should be replaced as well, it will only worsen, creating a safety hazard while driving because it can cause the car not to stop properly and difficult to control. I’ve taken the vehicle to repair shop and was told the same. Also was advised by both the dealer and private repair shops that this is a common issue with these vehicles, yet there is no recall by Mercedes in this country. Canada has a recall for this issue and other countries as well but not the USA. I was quoted $5000 to fix the issue by putting a new subframe, repairing is not possible. The part itself is on back order almost everywhere due to the commonality of this issue. This has caused the price to go up in cost due to the demand. A junkyard / car parts quoted me $2000 for a used subframe. As a service connected disabled Veteran I find this issue to be very concerning and ask why this is not a recall that Mercedes should replace without cost to the consumer. I hope that my complaint and hopefully others as well can get this issue resolved and hold Mercedes accountable. The subframe rust out yet other parts around it does not, this has to be a manufacturer issue with the sub frame. Reports of this issue are in warm weather southern states with no snow or salt issues as well as northern states