2024 MERCEDES-BENZ SPRINTER 2500 Complaints

The contact owns a 2024 Mercedes-Benz Sprinter 2500. The contact stated while driving approximately 65-70 MPH, the vehicle stalled without warning. The contact attempted to depress the accelerator pedal however, the vehicle revved but failed to respond. The contact was able to pull to the side of the emergency lane. The contact had called the dealer at that point who advised the contact to turn off the vehicle and lock the vehicle, then reopen and restart the vehicle to reset the computer system. The contact completed the instructions, and the failure did not reoccur. The contact stated that approximately 2 to 3 months later while driving approximately 60-65 MPH, the ABS suddenly activated causing the vehicle to stop unintendedly. The instrument panel displayed that the vehicle had detected an object nearby, causing the brake assist to activate and then go completely black. The contact depressed the accelerator pedal causing the vehicle to accelerate abruptly. The dealer had not been contacted. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 5,000.

The drive shaft to front differential (part # A9070410-09-00) in MY23 and MY24 Sprinter AWD has structural flaw in the sense that: (1) it is so short that the shaft can easily fall off during normal road conditions. (2) the clip and O-ring to secure the A9070410-09-00 is not strong enough to handle the normal stress of this driver shaft. If A9070410-09-00 falls off, severe vibration occurs and the Sprinter can only drive 2mile/hour or even stop functioning. There is a good chance that the driver can get stuck in the middle of nowhere without the reach to any help. This is a SERIOUS design failure and needs to have a recall and permanent fix ASAP! For more information, pls refer to this Youtube video by [XXX]: [XXX] My brand-new van only has 2600 miles on it and there is no offroad at all. The front drive shaft is almost completely falling off and it sits in a MB dealer for repair now. Pls address this serious safety risk ASAP! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)