2020 MERCEDES-BENZ SPRINTER 2500 Complaints

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated while driving approximately 35 MPH, the instrument cluster lost functionality and the screen went blank. The contact stated no warning was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. Additionally, the contact stated that the vehicle had experienced cold start failures. The contact stated that occasionally several attempts were needed to start the vehicle. The contact stated that the failures were intermittent. The manufacturer had been informed of the failure. The contact researched online and related the instrument cluster failure to NHTSA Campaign Number: 23V204000 (Electrical System). The failure mileage was approximately 11,000.

The adaptive cruise control, auto emergency breaking and collision warning stopped working on the vehicle on a clear day as I was entering the freeway for a long drive. It said sensors were dirty. I stopped, shut off vehicle, cleaned all sensor locations, and restarted vehicle. Sensors worked for 5min and then stopped again and have yet to start functioning after 4 days and extensive driving. It appears that this is a common issue for other 2019+ Sprinter owners. This definitely reduces the safety of the vehicle for the driver, passengers and other vehicles. Shut-off without warning, reduces speed unexpectedly in traffic is a risk. The distractions of looking down for solutions to see what's going on and trying to reset system.

Driving at speed (70-75 mph) in the HOV lane of the I-5 Freeway south of Los Angeles, a warning signal would occasionally light up and sound when the van passed under HOV signage indicating HOV exits. Then, with a completely clear lane ahead – no vehicles, no obstacles – the van's braking system activated just before the van reached one of these overhead signs. The brakes fully locked, the van skidded briefly before the brakes released. The driver of the car following behind slammed on his/her brakes to avoid rear-ending the van. A very dangerous situation and major accident was only avoided because the traffic was relatively light in that particular section of the freeway at that time of day.

crosswind assist randomly kicking in, acting in a dangerous manner. Vehicle swirl, almost fish tailing. Other times it randomly slams on the brakes, slows down by 10mph, almost got rear ended.

The automatic awning fully extended while I was moving at approximately 50 MPH. I was alone in the vehicle. Vehicles in the lane to my right had to change lanes and break to avoid colliding with awning. I contacted Carefree of Colorado, the manufacturer of the awning (model name: Freestyle Evolution). The technicians could not diagnose the problem and suggested that I take it in for service. There was no warning lamps or beeps before or during the spontaneous deployment. I was aware of the problem after hearing a loud noise, flapping and was able to visually confirm that the awning was extended. there is only one switch used to extend and retract the awning and it is out of reach of the drivers seat. Upon inspection, I found the switch in the "in" position, which means that it is retracted.

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 22V796000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The rear camera has gone out on numerous occasions. When I place the vehicle in reverse, my infotainment displays a black area with a camera with a line through it, indicating the rear camera is not working. I’m not sure if it’s the same issue as issue “21V411” that affected other 19-21 Mercedes Sprinter vans but it seems like it from what was described.

None responsive throttle, driving on highway and engine loses power and loses all throttle response causing rapid slowing to traffic behind the vehicle. No warning lamps and CEL’s. Problem occurs at random times with no CEL or warning.

Cross wind assist kick on for random reason, not able to disable this feature. It slams on the brake dropping my speed by 10MPH with vehicle almost rear ending me. At times it steers the vehicle in such a way that it almost fish tail.

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while driving at an undisclosed speed, the vehicle was jerking. The vehicle was taken to the dealer; however, no cause of the failure was found. The contact related the failure to NHTSA Campaign Number 22V796000 (Power Train). The manufacturer was made aware of the failure. The failure mileage was approximately 32,000.