2017 MERCEDES-BENZ SPRINTER 3500 Complaints

TRAVELING ON I-95 WITH THE CRUISE CONTROL SET AT 70 MPH. SUDDENLY THE VEHICLE DECELERATED AND THREE WARNING LIGHTS (ABS, TRACTION & THE ACCELERATION SKID CONTROL / ELECTRONIC BRAKING ASSIST) CAME ON THE DASH. THE VEHICLE FELT SLUGGISH AND THE CRUISE CONTROL WOULD NO LONGER WORK. THERE ARE ONLY 21,200+ MILES ON THE VEHICLE AND THIS WAS A VERY DANGEROUS SITUATION FOR MY FAMILY AND I WHILE TRAVELING ON THE INTERSTATE.

I PURCHASED A 2017 RV (17,00 MI) MERCEDES BENZ CHASSIS IN DEC 2019 AND IN FEB 2020 WHILE DRIVING HOME FROM A CAMPING TRIP (55 MPH HIGHWAY) THE WARNING LIGHT COME ON AND VEHICLE WAS SURGING. I LOOKED UP THE ISSUE (WHEEL SENSOR FAILURE) AND SLOWLY DROVE HOME. GOT APP WITH MB DEALER AND REAR SENSOR REPLACEMENT MADE UNDER WARRENTRY. I TALKED WITH PREVIOUS OWNER AND WAS GIVEN THE HISTORY OF REAR WHEEL SENSOR FAILURES WITH THIS RV. BELOW IS HIS RECORD NOV 2018 (12,00 MI) BOTH REAR WHEEL SENSOR FAILURES AND REPLACED. APRIL 2019 REAR WHEEL SENSOR FAILED AND REPLACED. JULY 2019 ONE SENSOR FAILED AND REPLACED. I HAVE READ WHERE THIS HAS BEEN A CONTINUED FAILURE ISSUE WITH MB WHEEL SENSORS. PLEASE LOOK INTO THIS ISSUE AND GET MB TO CORRECT THE PROBLEM. THANK YOU

WHEEL SPEED SENSOR FAILURE. ABS, TRACTION CONTROL SIT DOWN UNTIL REPLACED SENSOR.

BODY PARTS ARE FALLING OF FOR RUNNING BOARDS, PARTS HAVE FALLEN OFF ON THE HIGHWAY AND HIT OTHER VEHICLES. DEALER UNABLE TO FIND PARTS TO RESOLVE ISSUE.

I HAVE A 2018 THOR SIESTA MOTOR HOME BUILT ON A MERCEDES BENZ 3500 CHASSIS. I WENT ON A 6700 MILE CROSS COUNTRY TRIP AND UPON RETURN FOUND THE FRONT PASSENGER TIRE FLAT. A LOCAL SHOP DISCOVERED THAT THE RIM WAS LEAKING AIR FROM A BAD WELD SPOT/CRACK ON THE INSIDE. I REPLACED THE RIM BACK ON MAY 27, 2019. I THEN WENT ON A 1000 MILE ROUND TRIP AND THE FOLLOWING DAY I NOTICED ANOTHER FLAT TIRE THIS TIME ON THE INSIDE REAR DUAL ON THE PASSENGER SIDE. MY LOCAL SHOP CONFIRMED THE SAME ISSUE WITH A WELD/CRACK ON THE INSIDE OF THE RIM ON MAY 29, 2019. I HAD TO REPLACE THAT RIM ALSO. BOTH TIMES I NOTICED THE FLAT TIRES AFTER PARKING THE VEHICLE UPON RETURNING FROM LONG ROAD TRIPS. ON THE SECOND WHEEL REPLACEMENT, I WAS SHOWN WHERE THE LEAK WAS DETECTED WHICH WAS AT THE CORNER OF THE INSIDE WELD SPOT. THERE ARE 8 WELD SPOTS ON THE INSIDE OF EACH RIM. EACH TIME THERE WAS AIR LEAKING AT THE SITE OF A WELD SPOT. I CALLED MY LOCAL MERCEDES BENZ DEALERSHIP TO INQUIRE IF THERE WAS A REPORTED ISSUE FROM THE FACTORY AND WAS TOLD NO. I THEN CALLED MY MOTOR HOME DEALERSHIP WITH THE SAME INQUIRY AND WAS TOLD THAT THEY HAVE NOT BEEN MADE AWARE OF ANY SUCH ISSUE.

THIS IS A FOLLOW-UP TO MY COMPLAINT OF AUGUST 27 2018, NHTSA NUMBER 11122749. I PREVIOUSLY REPORTED THE DATES AND CIRCUMSTANCES OF 3 WHEEL (RIMS) FAILURES DUE TO A CRACKED WELD WHERE THE TWO PIECES OF THE RIM ARE JOINED, CAUSING AIR TO LEAK AND TIRES TO DEFLATE. ON APRIL 12, 2019, I HAD ANOTHER FLAT TIRE DUE TO THE SAME REASONS AS STATED IN MY PREVIOUS REPORT, A WELD IN THE RIM THAT FAILED TO HOLD AIR. THUS FAR, FOUR OF THE SEVEN WHEELS/RIMS ON MY VEHICLE HAVE FAILED OVER AN 8 MONTH PERIOD AND 6500 MILES. DURING MOST OF THIS PERIOD THE VEHICLE WAS IN STORAGE. I DISCOVERED ALL THE PROBLEMS DURING MORNING AIR PRESSURE CHECKS AFTER DRIVING THE PREVIOUS DAY. I HAVE NO IDEA HOW MUCH DAMAGE COULD HAVE BEEN SUSTAINED TO THE TIRES WHEN THEY WERE AT 61PSI AT THE START OF ONE DAY AND AT 30PSI THE NEXT MORNING AFTER A 400 PLUS MILE DRIVING DAY. THEY WERE ALL SLOW LEAKS THAT MANIFESTED THEMSELVES AFTER A DAY OF DRIVING. THE VEHICLE WAS PURCHASED NEW IN NOVEMBER, 2018. IT IS A 2018 WINNEBAGO VIEW ON A 2017 SPRINTER CHASSIS.

THE RECALL HAS BEEN EFFECT SINCE 2013. AND YOUR NOTIFING MY NOW IN 2019 !?! WHAT'S WRONG WITH YOU PEOPLE!!

SPRINTER COMPLETELY LOST ELECTRICAL POWER, ENGINE AND DRIVE TRAIN PROPULSION. THE TACH AND SPEEDOMETER FROZE IN PLACE AT 2500 RPM AND 15MPH. 60 SECONDS PASSED AND THE DASH LIGHTS BLINKED AND THEN ALLOWED ME TO RESTART VEHICLE. IT WAS LIKE THE SYSTEM RE-BOOTED ITSELF. LUCKILY I WAS NOT AT SPEED OR IN A DRIVING LANE WHEN THIS HAPPENED. I HAD JUST FILLED THE TANK WITH DIESEL, MY DEF WAS AT 80% FULL AND I WAS DEPARTING THE SERVICE STATION. I WAS ABLE TO START VEHICLE AND RETURN HOME, 10 MILES. WHEN I ATTEMPTED TO RESTART THE VEHICLE AT HOME THE STARTER MADE A GRINDING NOISE AND THE MB DEALERSHIP HAS HEARD THE SAME NOISE. CALLLED MERCEDES SPRINTER HOTLINE AND GOT THE SPRINTER TOWED TO THE DEALERSHIP. *DT CONSUMER CONTACTED MANUFACTURER FOR THE SERVICE CALL.*JB