2011 MERCURY MILAN Complaints

THE VEHICLE WAS RUNNING NORMALLY BUT SUDDENLY FALTERED AND ENTERED THE "LIMP HOME MODE" WHERE THE ENGINE SPEED IS LIMITED TO 900 RPM. I TURNED OFF THE BUSY STREET ON TO A SIDE ROAD AND TURNED OFF THE ENGINE. UPON RESTART, THE ENGINE RAN MORE OR LESS NORMALLY, ALBEIT WITH THE CHECK ENGINE LIGHT ILLUMINATED, FOR A FEW MINUTES AND THEN ENTERED "LIMP HOME MODE" AGAIN. THIS HAPPENED TWICE MORE ON A 4 MILE DRIVE. *TR

DRIVING NEAR 55 MPH ON LOCAL HIGHWAY AND APPLYING PRESSURE TO GAS PEDAL TO ACCELERATE. FELT AND HEARD A 'CLUNK'. VEHICLE IMMEDIATELY LOST ABILITY TO ACCELERATE WITH PRESSURE APPLIED TO GAS PEDAL. EXITED TO SHOULDER. NOTICED YELLOW SERVICE (WRENCH) INDICATOR LIGHT WAS ON. PUT THE CAR INTO PARK AND TURNED OFF IGNITION. RE-STARTED VEHICLE; SERVICE INDICATOR LIGHT DID NOT COME BACK ON. PUT THE CAR INTO DRIVE AND RE-ENTERED TRAFFIC FLOW. DID NOT HAVE AN INCIDENT IN ANOTHER 30 MILES OF DRIVING. TOOK THE VEHICLE TO DEALER FOR DIAGNOSIS. DEALER DIAGNOSED PROBLEM AS REQUIRING NEW THROTTLE BODY. VERY DANGEROUS SITUATION. *TR

DRIVING ON A STRAIGHT AWAY THE VEHICLE SUDDENLY MAKES A NOISE AS IF IT WERE SHIFTING VERY HARD ALTHOUGH IT WAS NOT. IMMEDIATELY LOST ACCELERATION AND DASHBOARD LIGHT ILLUMINATES. PULLED VEHICLE TO THE SIDE OF THE ROAD AND RPM NEEDLE BOUNCED AS CAR LUNGED BUT WOULD NOT ACCELERATE. CALLED FOR ROADSIDE ASSISTANCE AND MY DEALER'S SERVICE DEPARTMENT WHO KNEW BASED ON MY DESCRIPTION A POSSIBLE CAUSE. VEHICLE TOWED TO DEALER, DIAGNOSTICS PROVED THROTTLE BODY NEEDED TO BE REPLACED. REPAIR MADE. RESEARCH PROVED THAT THIS IS A KNOWN PROBLEM BUT NO RECALL HAS BEEN MADE. IT WAS A VERY FOGGY MORNING AND SEVERAL MULTI CAR ACCIDENTS HAD BEEN REPORTED. HAD I BEEN ON BUSIER STRETCH OF ROAD AT THE TIME OF THE BREAK DOWN I COULD HAVE EASILY BEEN KILLED WITH SLOWING DOWN SUDDENLY AND WITHOUT ANY EVIDENT CAUSE. A RECALL SHOULD BE ISSUED AND REFUNDS MADE TO THOSE WHO HAVE ALREADY EXPERIENCED THIS FAILURE. *TR

I WAS DRIVING DOWN A LOCAL ROAD AT ABOUT 35 MPH. ALL OF A SUDDEN, WITHOUT WARNING, I COULD NOT GET MY GAS PEDAL TO DO ANYTHING, LIKE IT WAS OUT OF GEAR, AND THE ENGINE SEEMED TO BE SPUTTERING. I PULLED OFF THE ROAD, SHUT THE CAR OFF AND AFTER A FEW SECONDS, RESTARTED THE CAR, IT RESTARTED AND DROVE FINE. IT DID THE SAME THING AGAIN THE NEXT DAY. IT HAS HAPPENED A NUMBER OF TIMES SINCE THE FIRST TIME... HAPPENING ABOUT ONCE PER DAY. IT SEEMS TO START UP OK AFTER I SHUT IT DOWN, BUT VERY UNSAFE TO BE DRIVING DOWN THE ROAD AND THEN HAVE NO POWER AND HAVE TO PULL OFF. *TR

ON 10/3/13 WHILE DRIVING HOME IN HEAVY TRAFFIC ON THE INTERSTATE MY 2011 MILAN WITH 44,000 MILES ON IT SPUTTERED AND DIED AT FREEWAY SPEED. STILL HAD ELECTRICAL POWER AND THE WRENCH WARNING LIGHT ON THE DASH WAS LIT UP. I WAS ABLE TO COAST TO THE SHOULDER AND STOP THE VEHICLE. ONCE RESTARTED THE CAR WENT THREE DAYS BEFORE AGAIN DYING ON THE INTERSTATE IN HEAVY TRAFFIC, AFTER DOING SOME RESEARCH I DISCOVERED THIS WAS A COMMON PROBLEM WITH FORD THROTTLE BODIES ON SEVERAL MAKES AND MODELS. 10/12/13 I PURCHASED A NEW THROTTLE BODY FROM MY LOCAL FORD DEALER AND INSTALLED IT THE SAME DAY. I TEST DROVE THE VEHICLE AND IT APPEARS THAT THE NEW THROTTLE BODY FIXED THE ISSUE AND ALSO ANOTHER SYMPTOM I HAD BEEN NOTICING, IT WAS A VERY SLIGHT HESITATION IN THE TRANSMISSION IN ALL GEARS. *TR

I MADE A LEFT TURN FROM A COMPLETE SIGN. IN THE MIDDLE OF THE INTERSECTION, THE CAR DECELERATED AND THE WRENCH SYMBOL ON THE DASH CAME ON. AS I PULLED OVER, THE CAR STARTED SHAKING AND CUT OFF. I HAD MY CHILDREN GET OUT OF THE CAR BECAUSE I WAS UNSURE OF WHAT WAS GOING ON. I TURNED THE CAR OFF, TOOK THE KEY FROM THE IGNITION. I WAITED ABOUT 5 MINUTES AND THEN RESTARTED THE CAR. I STARTED AND EVERYTHING WAS OK. ON 9/25/13, THIS HAPPENED WHILE I WAS DRIVING ON A STRAIGHT ROAD. 9/28/13 - IT HAPPENED WHILE DRIVING 65 MPH ON THE INTERSTATE. 9/30/13 - AFTER FILLING THE CAR WITH GAS, ON A MAJOR ROAD. 10/1/13 - JUST DRIVING. 10/8 - MAKING A LEFT TURN . THERE IS NOT A WARNING BEFORE IT HAPPENS. *TR

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE POWER STEERING FAILED AND THE SERVICE POWER STEERING NOW WARNING MESSAGE DISPLAYED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

CAR LOST POWER WHILE DRIVING. YELLOW WRENCH LIGHT CAME ON AND CAR CONTINUED TO IDLE ROUGHLY. SHUTTING CAR OF AND RESTARTING WOULD RESET EVERYTHING, BUT IF CONTINUE TO DRIVE THE SAME THING HAPPENED. NO SPEED OR RPM INCREASE HAPPENED WHEN STEPPING ON THE GAS. HAD TO TOW CAR TO FORD DEALER AS I COULDN'T DRIVE IT. MECHANIC STATED THROTTLE BODY HAD GONE BAD AND HAD TO BE REPLACED. THEY NEVER TOLD ME THAT FORD WAS HAVING AN ISSUE WITH THIS PART. COST ME $460 TO HAVE THIS REPLACED. LOW MILEAGE AND NEWER CAR THIS SHOULD NOT HAVE HAPPENED. COULD HAVE HAD A TERRIBLE ACCIDENT IF I HAD BEEN DRIVING DOWN THE FREE WAY AT RUSH HOUR AS I LIVE IN A METROPOLITAN AREA. *JS

DRIVING CAR WHEN IT LOST ALL POWER. WHEN STEPPING ON THE GAS NOTHING HAPPENED, NO SPEED OR RPM INCREASE. WAS ABLE TO PULL OVER TO SIDE OF ROAD. YELLOW WRENCH LIGHT CAME ON. CAR WHEN DRIVABLE WOULD JERK LIKE NOT GETTING ENOUGH GAS. I HAD TO PAY $430 TO HAVE THIS REPLACED. THIS SEEMS TO BE A KNOWN DEFECT FOR THIS CAR AND YEAR. I HAD THE EXTENDED WARRANTY ON MY CAR BUT WAS TOLD BY THE MECHANIC THAT THIS PART WAS SPECIFICALLY EXCLUDED. EVIDENTLY THEY KNEW THIS PART HAD A PROBLEM SO THEY DIDN'T COVER IT. COULD HAVE HAD A VERY BAD ACCIDENT IF THIS HAD HAPPENED IN RUSH HOUR TRAFFIC. *JS

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE WRENCH WARNING SYMBOL ILLUMINATED AS THE VEHICLE BEGAN TO DECELERATE RAPIDLY. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. AFTER RESTARTING, THE VEHICLE WAS ABLE TO RESUME NORMALLY. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS HOWEVER, THE TECHNICIAN WAS UNABLE TO DETECT A TROUBLE CODE OR DUPLICATE THE PROBLEM. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.