2011 MERCURY MILAN Complaints

2011 MERCURY MILAN. TRAVELING ON I-494 IN MINNEAPOLIS DURING RUSH HOUR TRAFFIC GOING 60MPH. VEHICLE JOLTED HARD, WRENCH LIGHT CAME ON AND ALL ACCERLATION WAS LOST. THANKFULLY I WAS IN THE OUTSIDE LANE AND WAS ABLE TO COAST OFF THE ROAD. ONCE PARKED THE CAR WAS IDLING VIOLENTLY. TURNED OFF CAR, WAITED A MINUTE AND STARTED BACK UP. STARTED FINE AND CONTINUED ON MY WAY. MADE IT 40 MILES BEFORE IT HAPPENED AGAIN. THIS TIME THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. TURNED OFF AND BACK ON AND WAS ABLE TO GET HOME. ONCE I GOT HOME, DID A QUICK GOOGLE SEARCH AND FOUND NUMEROUS POSTINGS AND COMPLAINTS ABOUT THE THROTTLE BODY BEING DEFECTIVE AND REQURING REPLACEMENT AT COST TO THE OWNER. BROUGHT THE CAR TO THE DEALERSHIP WHERE I BOUGHT IT. ENCOUNTERED THE SAME ISSUE TWICE DURING THE 25 MILE DRIVE TO THE DEALERSHIP. TOLD DEALERSHIP THAT I AM CERTAIN IT IS THE THROTTLE BODY, THEY CHECKED AND FOUND ERROR CODE P2111 AND REPLACED THE THROTTLE AND GASKET. VERY FRUSTRATING TO SEE THIS IS A SOMEWHAT COMMON ISSUE IN MILANS AND FUSIONS. CAR ONLY HAS 50K MILES ON IT. *TR

VEHICLE LOST ALL POWER AND RPM DROPPED BELOW 1000, ENGINE WOULD NOT RESPOND TO ACCELERATOR DEPRESSION. THE CHECK ENGINE LIGHT CAME ON AND I HAD THE TROUBLE CODES ANALYZED AND IT WAS THE THROTTLE BODY PART THAT WAS DEFECTIVE. I CALLED THE DEALERSHIP WHERE I PURCHASED THE CAR FROM AND THEY INFORMED ME THAT PARTICULAR PART WAS ON BACK ORDER AND THAT THEY HAVE HAD NUMEROUS VEHICLES WITH THAT PROBLEM. *TR

I HAD FIVE SEPARATE INCIDENTS WHERE MY 2011 MERCURY MILAN LOST ALL POWER AND ACCELERATION BEFORE I WAS ABLE TO TAKE IT TO A DEALERSHIP. TWICE RIGHT WHEN I STARTED MY VEHICLE THE CAR HAD NO POWER TO MOVE FROM PARK AND THE WRENCH LIGHT WAS ON. WHEN I SHUT IT OFF AND TURNED IT BACK ON IT STRUGGLED TO START AT FIRST BUT THEN STARTED AND DROVE NORMALLY. THE OTHER THREE TIMES I WAS DRIVING DOWN THE STREET (LUCKILY NOT A HIGHWAY) AT AROUND 40 MPH AND ALL OF A SUDDEN THE CAR SHOOK, THE WRENCH LIGHT CAME ON, AND I LOST ALL ACCELERATION AND POWER. I QUICKLY TURNED MY HAZARDS ON AND COASTED TO THE SIDE OF THE ROAD WHERE I SHUT OFF THE CAR. AGAIN WHEN I STARTED THE VEHICLE IT STRUGGLED A BIT BUT THEN STARTED NORMALLY AND THE WRENCH LIGHT WENT OFF AND DROVE LIKE NOTHING HAD HAPPENED. I ONLY GOT ABOUT 2 MILES DOWN THE ROAD WHEN IT LOST POWER AGAIN...AND THEN AGAIN. WHEN I TOOK IT TO THE DEALERSHIP THEY SAID IT WAS A THROTTLE BODY ISSUE AND THAT THE FUSIONS/MILANS HAVE BEEN HAVING THIS PROBLEM. I WAS SHOCKED THIS WASN'T COVERED UNDER MY 5 YR 60,000 MILE WARRANTY. WHAT WAS EVEN MORE TROUBLING IS THE FACT THERE HAS NOT BEEN A RECALL ON THIS PART GIVEN THE HUGE PROBLEM WITH IT. COME ON FORD, REALLY? IS IT GOING TO TAKE SOMEONE GETTING HURT OR WORSE KILLED BEFORE YOU ISSUE THE RECALL? ALL YOU HAVE TO DO IS SEARCH THIS ISSUE AND YOU WILL FIND DOZENS OF REPORTS AND FORUMS WITH PEOPLE HAVING THE SAME PROBLEM. LUCKILY THE DEALERSHIP I WAS ABLE TO GET MY VEHICLE TO (I TOOK IT TO THE CLOSEST ONE TO MY HOME BECAUSE I WAS AFRAID OF LOSING POWER WHILE ON THE HIGHWAY AND POSSIBLY GETTING IN A WRECK) WAS ABLE TO GET THE PART IN ABOUT 7 DAYS EVEN WITH IT BEING BACK ORDERED. IN TOTAL I ENDED UP DROPPING ABOUT $400 TO REPLACE IT. I'D BE VERY DISAPPOINTED IN FORD IF A RECALL WASN'T ISSUED AND I DIDN'T GET THIS MONEY BACK. *TR

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT THE PASSENGER BRAKE LIGHT REMAINED ILLUMINATED WHEN THE BRAKE PEDAL WAS NOT DEPRESSED AND LEFT BRAKE LIGHT FAILED INTERMITTENTLY. THE CONTACT REPAIRED THE BRAKE LIGHT MOUNTING UNIT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 48,000. ..UPDATED 07-17-13 *BF

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE JERKED AND THE WRENCH WARNING ICON ILLUMINATED. THE CONTACT COASTED TO THE SIDE OF THE ROAD TO RESTART THE VEHICLE. THE VEHICLE WAS RESTARTED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE THROTTLE BODY CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 23,000.

AFTER DRIVING ABOUT 28 MILES THE CAR LOST POWER WHILE GOING DOWNHILL AT 75 MPH ON THE FREEWAY. THE "TOOL WRENCH" LIGHT CAME ON AND THE CAR CONTINUED TO LOSE SPEED. PULLED INTO THE EMERGENCY LANE AND PUT THE VEHICLE IN PARK. PUT IT BACK IN DRIVE AND THE RPM JUMPED FROM 900-1100 RPM AND CAR SURGED AT ABOUT 3-5 MPH; IT WOULD NOT GO FASTER THAN 10 MPH. STOPPED AND PUT IT BACK INTO PARK AND TURNED OFF THE IGNITION AND LET THE CAR SIT FOR ABOUT 1 MINUTE. RESTARTED THE CAR AND IT STARTED VERY ROUGHLY, IT DID SMOOTH OUT AND IDLED AT 1000 RPM. THE "TOOL WRENCH" LIGHT WAS NO LONGER ON AND THE CAR DROVE NORMALLY THE REST OF THE WAY HOME WHICH WAS ABOUT 11 MILES. THE CAR HAS ALMOST 59K MILES ON IT. *TR

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE DECELERATED THEN STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE OCCURRED A SECOND TIME. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE THROTTLE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 41,400. *TR

I HAD JUST PULLED OUT OF MY DRIVEWAY, PUSHED ON THE GAS, AND THE CAR STARTED SPUTTERING AND JERKING AND CAME TO A STOP. THE "WRENCH" LIGHT AND "CHECK ENGINE" LIGHT WERE LIT UP ON THE DASH.THINKING PERHAPS JUST A FLUKE, I TURNED THE CAR OFF FOR A FEW MINUTES, THEN TURNED IT BACK ON AND LET IT IDLE FOR A MINUTE. THE WRENCH AND ENGINE LIGHT WERE NO LONGER DISPLAYED, SO I DROVE AGAIN.MY MAX SPEED WAS MAYBE 15 OR 20 MPH. NOT 30 SECONDS LATER, THE CAR AGAIN DID THE SAME THING, WITH THE WRENCH AND ENGINE LIGHTS COMING ON. LUCKILY I WAS AT A STOP SIGN AND IN A RESIDENTIAL NEIGHBORHOOD. I TURNED THE CAR OFF AGAIN, AND DROVE BACK HOME THIS TIME. IT WAS REALLY SCARY. LUCKILY I WASN'T DRIVING ON THE INTERSTATE AT A HIGH RATE OF SPEED! DEFINITELY A SAFETY ISSUE HERE! A FRIEND OF MINE WITH A COMPUTER DIAGNOSTIC THING, CAME OVER AND TESTED THE CAR ABOUT AN HOUR LATER. THE ERROR CODE WAS THROTTLE ACTUATOR CONTROL SYSTEM. MY FRIEND CLEARED OUT THE CODE AND I WAS ABLE TO DRIVE IT AROUND THE BLOCK WITHOUT IT HAPPENING AGAIN. I PLAN ON TAKING IT TO THE DEALERSHIP TOMORROW. ACCORDING TO THESE SIMILAR COMPLAINTS, IT APPEARS TO BE THE THROTTLE BODY AND NOT A CHEAP FIX! *TR

I WAS SITTING AT A RED STOP LIGHT, AND THEN THE TRAFFIC LIGHT TURNED GREEN. I LIGHTLY PRESSED THE GAS BUT THE CAR WOULD NOT GO, AND ALL A SUDDEN I LOOKED DOWN AND THE CHECK ENGINE LIGHT IS ON. I PULLED OVER TO THE SIDE OF THE ROAD (WHILE TURNING HAZARD LIGHTS ON), PLACED CAR IN PARK, AND TURNED THE CAR OFF. I TURNED THE CAR BACK ON (STARTED JUST FINE) AND ATTEMPTED TO GO AGAIN TO GET TO A SAFER DESTINATION (WAS RIGHT IN THE MIDDLE OF THE INTERSECTION). THE CHECK ENGINE LIGHT REMAINED ON AND THE CAR WOULD NOT GO ANY FASTER THAN ROUGHLY 5 MILES PER HOUR. THEN THE WRENCH LIGHT CAME ON (WHICH APPARENTLY MEANS A TRANSMISSION PROBLEM). I PULLED THE CAR OVER AGAIN AND CALLED FOR HELP. EVENTUALLY I GOT THE CAR INTO A PARKING LOT (MEANWHILE TRAVELING AT ABOUT 5 MILES PER HOUR AND BLOCKING 5 O' CLOCK RUSH HOUR TRAFFIC). CAR HAD TO BE TOWED TO NEARBY SHOP. THEY TOLD ME THE THROTTLE BODY HAD QUIT WORKING (STUCK CLOSED) AND THE CAR WAS NOT GETTING ENOUGH AIR INTO THE GAS FOR THE CAR TO RUN PROPERLY. 400.00$ LATER, IT WAS FIXED. I HAVE HAD THE CAR FOR A LITTLE OVER A YEAR AND PUT ABOUT 10,000 MILES ON IT SINCE PURCHASE. RIDICULOUS. *TR

2011 MERCURY MILAN. CONSUMER WRITES IN REGARDS TO PARTIAL ENGINE FAILURE IN VEHICLE AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED AT APPROXIMATELY 48,415, THE ENGINE STARTED GOING TIN A VERY ROUGH LOW RPM MODE. THE CONSUMER STATED THE WRENCH LIGHT AND ENGINE LIGHT ILLUMINATED AND THE VEHICLE RAN FINE UNDER 40 MPH. THE DEALER REPLACED THE THROTTLE BODY AND CABIN AIR FILTER.