2003 MERCURY MOUNTAINEER Complaints

2003 MERCURY MOUNTAINEER AWD 4.0L. WE PURCHASED OUR MOUNTAINEER IN JUNE OF 2004, WITH 22,000 MILES ON THE ODOMETER. APPROXIMATELY 300 MILES INTO OUR OWNERSHIP, WE EXPERIENCED A FRONT BEARING WINE. DEALERSHIP COVERED DEFECT UNDER 3 YEAR / 36,000 MILE WARRANTY. OTHER DEFECTS COVERED...REPLACEMENT OF THE REAR SPEED SENSOR AT 23,454 MILES. A 2ND ABS PROBLEM REQUIRED A NEW ACTUATOR SPEED CONTROL SWITCH ASSEMBLY AT 28,419 MILES. TRANSMISSION SHIFT SOLENOID REPLACED AT 32,075 MILES. DRIVER SIDE PASSENGER WINDOW MOTOR REPLACED AT 33,443 MILES. RECALL ON REAR GLASS HATCH LIFT STRUTS AT 27,379 MILES. JANUARY 23, 2006 OUR MOUNTAINEER NOW HAS 42,777 MILES ON THE ODOMETER. WE NOTICED A LOW PITCH NOISE STARTING AT 25-30 MPH AND BECOMING HIGHER IN PITCH AT HIGHER SPEEDS. OUR LOCAL LINCOLN / MERCURY DEALERSHIP SERVICE ADVISOR DETERMINED WE HAD A FAULTY REAR AXLE RING & PINION GEAR SET. THEY REBUILT OUR REAR AXLE USING THE VIN # TO DETERMINE ACTUAL BILL OF SALES DATE, WHICH WAS JUNE OF 2003. THIS GAVE US A WARRANTY UNTIL JUNE OF 2006 THUS NEARING THE END OF OUR 36 MONTHS WARRANTY. WE REGRETFULLY ADMIT PAYING A $200.00 DEDUCTIBLE THE DEALERSHIP ASKED FOR. WE DROVE OFF WITH OUR NEWLY REBUILT AXLE IN OUR MOUNTAINEER. OUR NOISY AXLE NEVER WENT AWAY. THE DEALERSHIP BLAMED THIS DUE TO WORN AND NOISY TIRES. WE REPLACED THESE TIRES AT 47,500 MILES OR 4,500 MILES AFTER THE ORIGINAL AXLE NOISE COMPLAINT WITH NO REAL APPARENT CHANGE TO OUR NOISY PROBLEM. OUR MERCURY MOUNTAINEER WENT BACK INTO THE SHOP AT 48,300 MILES WITH A NOISE STILL DISTINCTIVE FROM THE REAR. AGAIN OUR LOCAL MERCURY DEALERSHIP TOOK A LOOK AT THE SUV WITH THE SERVICE MANAGER RIDING IN THE VEHICLE. HIS COMMENT... SOUNDS LIKE AN ON-GOING REAR AXLE ISSUE. HE WOULD CHECK WITH HIS DISTRICT MANAGER ABOUT REPLACING THE ENTIRE AXLE ASSEMBLY THIS TIME AROUND. THEY CONTACTED US BY PHONE THE NEXT DAY. THEY DIDN'T BELIEVE IT WAS THE AXLE, BUT ONE OF THE REAR OUTER HUB WHEEL BEARING ASSEMBLIES. IT WOULD COST US $270.00. *JB

VEHICLE IS 2003 MERCURY MOUNTAINEER AWD/ THE VEHICLE KEEPS ON LOSING THE POWER TO THE TRANSMISSION AND YOU JUST SIT THERE WATCHING THE RPM RACE WITH NO POWER HAPPINESS AT ALL SPEEDS WHICH HAS ALMOST CAUSED MANY CRASHES RE PULLING OUT INTO TRAFFIC. HAS BEEN TO THE DEALER AND THEY CAN NOT FIND ANYTHING . ON GOING PROBLEM X 2 YEARS AND IS AT THE DEALERSHIP NOW RE I FEEL I'M GOING TO GET KILLED IN THIS VEHICLE. *NM

2003 MOUNTAINEER TRANSAXLE HOUSING BROKE IN HALF. THE OIL FROM THE TRANSAXLE LEAKED ON THE EXHAUST CAUSING A SMALL FIRE. *TS THE DRIVER INDICATED THAT SHE MAY HAVE HIT AN OBJECT IN THE ROAD. *NM

DT*: THE CONTACT STATED THE FRONT SEATBELTS WOULD NOT RETRACT. THE DEALERSHIP INSTALLED A MODIFIED REPAIR KIT AND THERE HAVE BEEN NO FURTHER PROBLEMS. ALSO, THE FUEL GAUGE WAS NOT READING THE CORRECT AMOUNT OF FUEL. THE DEALERSHIP REPLACED THE FUEL GAUGE, BUT THE LOW FUEL WARNING LIGHT HAS BECOME INOPERABLE. ADDITIONALLY, WHILE THE MOON ROOF WAS BEING OPENED, IT BUCKLED. THE DEALERSHIP AND MANUFACTURER DETERMINED THIS WAS HOW THE VEHICLE WAS MANUFACTURED.

AT 34,500 MILES, TRANSMISSION BEGAN A NOTICEABLE DELAY IN MAKING THE SHIFT INTO REVERSE GEAR. GAVE A LIST OF GRIPES TO CHAMPION MERCURY DEALERSHIP, WHERE I BOUGHT THE VEHICLE, TO BE FIXED BEFORE THE 36K WARRANTY RAN OUT. THE DEALERSHIP DID NOT INCLUDE THIS TRANSMISSION GRIPE IN THE LIST THEY INPUT INTO THEIR COMPUTERS. VISITED THE DEALERSHIP AGAIN AT 39K MILES, WITH THE TRANSMISSION PROBLEM GETTING WORSE, AND THE DEALERSHIP DENIED HAVING THAT GRIPE AIRED WITHIN THE WARRANTY PERIOD. SO NOTHING WAS DONE ABOUT THE TRANSMISSION. NOW, AT 43K MILES, THE TRANSMISSION BANGS INTO REVERSE GEAR AFTER A LARGE DELAY, AND THE SHIFTS FROM 2-3 AND 3-4 INCLUDE A HEAVY SHUDDER, CONSISTENTLY. *JB

DT: THE AUTOMATIC TIRE WARNING SYSTEM HAS NOT WORKED SINCE THE CONSUMER PURCHASED THE VEHICLE. HOWEVER, THERE WAS NO PROBLEM WITH THE TIRES. EVERY TIME HE TOOK IT TO THE DEALER THEY RECALIBRATED THE COMPUTER EVERY 3,000 MILES, BUT THIS HAS NOT IMPROVED THE CONDITION. WHEN HE CONTACTED THE MANUFACTURER THEY TELL HIM TO TAKE IT TO THE TIRE DEALER. THE TIRE DEALER REFERRED HIM BACK TO FORD BECAUSE IT WAS A PROBLEM WITH THE VEHICLE ITSELF. THE CONSUMER FELT THAT IT WAS A SAFETY ISSUE BECAUSE THE COMPUTER DID NOT WARN HIM IF THERE WAS A LOSS OF AIR PRESSURE IN ANY OF THE TIRES. THIS OCCURRED FIRST IN 12-2003, AND HAPPENED AGAIN WHEN THE CONSUMER HAD TAKEN A TRIP IN 5-2004, AND IT KEPT RECURRING. *AK UPDATED 12/27/2005 - *NM

DT: CONTACT STATES WHILE DRIVING 2003 MERCURY MOUNTAINEER SHE WAS TURNING AND PRESSED ON THE BRAKES THE PEDAL FELL OFF. THE SERVICE DEALER STATED THE REASON THIS HAPPENED WAS BECAUSE THE BRACKET BROKE. *AK THE BRAKE PEDAL FELL OFF WHEN PRESSED BECAUSE A SELF LOCKING BOLT WAS NEVER INSTALLED DURING ASSEMBLY. *NM

WHEN USING THE RECLINE SEAT HANDLE, THE SEAT WOULD LURCH FORWARD, THIS CAUSED A MINOR HEAD INJURY. *JB WHILE THE CONSUMER WAS LOWERING THE MIDDLE BACK SECOND ROW SEAT SHE BENT OVER THE SEAT TO GAIN ACCESS TO THE RELEASE LEVER. THIS ACTION POSITIONED THE RIGHT SIDE OF THE CONSUMER'S FACE LEVEL WITH THE SHOULDER HARNESS ASSEMBLY. WHEN THE LEVER WAS RELEASED THE SEAT SPRUNG FORWARD WITH ENOUGH FORCE TO CRUSH THE CONSUMER'S RIGHT EYE. THE CONSUMER NO LONGER HAS VISION IN HER RIGHT EYE. *NM

I READ AN ARTICLE FROM THE CHICAGO TRIBUNE TITLED "STICKY THROTTLES." I HAVE A 2003 MERCURY MOUNTAINEER AND THE UNINTENDED ACCELERATION HAPPENED TO ME ON JULY 13TH. I WAS COMING TO A STOP AT A STOP LIGHT AND JUST AS I WAS ABOUT TO A COMPLETE STOP, WITH MY FOOT ON THE BRAKE, IT TRIED TO ACCELERATE AND THEN STOPPED. SO YOU MAY ALSO WANT TO LOOK A THE 2003 MODEL ALSO. THE ARTICLE I MENTIONED IS BELOW. STICKY THROTTLES CHICAGO (CHICAGO TRIBUNE)--THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION IS INVESTIGATING 690,000 2002 FORD EXPLORERS AND MERCURY MOUNTAINEER SPORT-UTILITY VEHICLES AFTER COMPLAINTS OF STICKING THROTTLES AND UNINTENDED ACCELERATION. THE AGENCY'S PRELIMINARY INVESTIGATION OF VEHICLES WITH 4- LITER, 6-CYLINDER ENGINES WAS PROMPTED BY 15 COMPLAINTS. NHTSA IS INVESTIGATING 2003 AND 2004 FORD MUSTANG, MUSTANG CONVERTIBLE AND MUSTANG GTS AFTER COMPLAINTS OF ACCELERATOR PEDAL INTERFERENCE WITH THE CAR'S CARPET. THE PROBE INVOLVES ABOUT 20,000 MUSTANGS. NHTSA INVESTIGATIONS CAN LEAD TO VEHICLE RECALLS.

LAST DECEMBER THE ENGINE REVVED AND ACCELERATED VERY HIGH, AROUND 6,000 RPMS. AFTERWARDS, THE TRANSMISSION ENGAGED, ACCELERATION LOWERED AND THE TRANSMISSION CHANGED GEARS WHILE ENTERING A STREET IN ONCOMING TRAFFIC. WHEN ATTEMPTING TO ACCELERATE THE ENGINE REVVED BUT THE VEHICLE DID NOT MOVE. ATTEMPTED THIS 3 TIMES TO NO AVAIL. ON 4TH ATTEMPT THE TRANSMISSION ENGAGED AND THE VEHICLE MOVED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER SAID IT WAS THE SOLENOID PACK AND AN OIL ADDITIVE THAT THEY BELIEVED WERE CAUSING THE PROBLEM. THEY PERFORMED THE REPAIRS. THE PROBLEM RECURRED IN JUNE. TOOK THE VEHICLE BACK TO THE DEALER. THE DEALER FOUND NOTHING ON THE DIAGNOSTIC MACHINE AND COULD NOT DUPLICATE THE PROBLEM. THE PROBLEM RECURRED AGAIN IN JULY. TOOK THE VEHICLE TO THE DEALER AND AGAIN THE DEALER COULD NOT FIND ANYTHING WRONG. THE DEALER REPLACED THE SOLENOID PACK AGAIN BECAUSE THEY DID NOT KNOW WHAT ELSE TO DO. THE MECHANIC SPOKE OF ONGOING PROBLEMS WITH FORD MOUNTAINEERS AND EXPLORERS. YESTERDAY WHILE ON THE HIGHWAY THIS PROBLEM OCCURRED AGAIN WHILE ATTEMPTING TO ACCELERATE. AFTER SEVERAL ATTEMPTS THE TRANSMISSION ENGAGED. CALLED FORD, WHO REFERRED ANOTHER DEALER STATING THERE WAS NOTHING THEY COULD DO. CALLED DEALER AND THEY OFFERED TO REPLACE THE TRANSMISSION. *AK