2002 MERCURY MOUNTAINEER Complaints

REAR LIFTGATE GLASS SHATTERED ON 2002 MERCURY MOUNTAINEER. HINGE CAME OFF AND THE ENTIRE GLASS WINDOW EXPLODED FILLING ENTIRE VEHICLE WITH FLYING GLASS. *KB

I JUST FINISHED GETTING GAS. I TURNED ON THE IGNITION AND PUT THE CAR IN REVERSE AND THE GEAR SHIFT SNAPPED OFF IN MY HAND. IT IS JUST DANGLING. I HAD TO PUT THE EMERGENCY BRAKE ON AND TURN THE CAR OFF IMMEDIATELY SO THAT IT WOULD ROLL BACK AND CRASH INTO SOMEONE ELSE CAR OR JUST A PEDESTRIAN. I PAID TO HAVE THE CAR TOWED TO MY HOME FOR $59. UPON GOING HOME, I CALLED SEVERAL FORD DEALERSHIPS WHO CLEARLY WERE FAMILIAR WITH THE PROBLEM BECAUSE I WAS GIVEN A QUOTE FOR THE PART AND LABOR IMMEDIATELY AFTER I TOLD THEM ABOUT THE ISSUE. I TOOK IT ONE STEP FURTHER AND WENT ONLINE TO CHECK FOR RECALLS. THERE WEREN'T ANY RECALLS HOWEVER, I HAVE READ SEVERAL FORUMS ONLINE AND THIS SEEMS TO BE AN ONGOING ISSUE WITH THE 2002 MERCURY MOUNTAINEERS AND 2002 FORD EXPLORERS. THIS IS RIDICULOUS AND I AM OUTRAGED AND I FEEL FORD NEEDS TO TAKE OWNERSHIP REGARDING THIS ISSUE. *TR

TRANSMISSION WOULD NOT SHIFT INTO THIRD GEAR. 70000 MILES NO TOWING JUST STREET DRIVING. HAD TO HAVE THE TRANSMISSION REBUILT. SEEMS TO BE COMMON ISSUE FOR FORD ON 2002 MERCURY MOUNTAINEERS AND FORD EXPLORERS. *TR

I HAVE THE SAME PROBLEM WITH MY 2002 MERCURY MOUNTAINEER, 85,000 MILES, AS CASE NUMBER 10187427. RUBBING SOUND IN DRIVER'S SIDE REAR WHEEL AS WHEEL ROTATES; GOING FRONTWARDS OR BACKWARDS BRAKES, PADS, ROTORS, CALIPERS ALL HAVE BEEN REPLACED AND NOISE HAS NOT CEASED. *TR

TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THE VEHICLE HAD A VERY HARD SHIFT FOR A FEW MONTHS. WHILE DRIVING THE TRANSMISSION FAILED AND THE OVERDRIVE LIGHT CAME ON PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES SINCE IT WAS PURCHASED AND WAS ALWAYS TOLD THAT NOTHING WAS WRONG WITH THE TRANSMISSION. THE DEALER RECENTLY STATED THERE WAS A BLOW HOLE AT THE BOTTOM OF THE TRANSMISSION AND THE HOLE EXPANDED WHICH CAUSED THE FAILURE. THE DEALER TOLD THE CONTACT THERE WAS A REPAIR KIT THAT COULD BE USED, BUT NOT UNTIL THE TRANSMISSION FAILED COMPLETELY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 75,000. UPDATED 10/18/11*LJ UPDATED 3/22/12 *CN UPDATED 8/11/12

2002 MERCURY MOUNTAINEER HAS UNEXPECTED IGNITION MISFIRING CODES, CAUSING HARD IDLE. AND THIS IS CAUSING COSTLY DIAGNOSTIC SERVICING THAT CANT LOCATE THE PROBLEM. I HAD ASKED 25 OTHER OWNERS AND THE ARE HAVING THE SAME PROBLEM...VIN # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DROVE TO GROCERY STORE AND ATTEMPTED TO PLACE CAR IN PARK AND UNABLE TO GET IT INTO PARK. IT WILL GO IN EVERY OTHER GEAR BUT WILL NOT GO INTO PARK. ALREADY HAD TO REPLACE GEAR SHIFT AFTER THE GEAR SHIFT ARM BROKE OFF IN MY HAND WHILE TRYING TO GET IT OUT OF PARK A FEW MONTHS AGO. NOW LOOKING AT MORE MONEY ON THIS PIECE OF JUNK CAR. NOW MUST LEAVE CAR IN GEAR AND LEAVE KEYS IN THE CAR. THIS IS JUST AN ACCIDENT WAITING TO HAPPEN WITH YOUNG CHILDREN AROUND. *TR

NEW SHOWROOM 2002 MERCURY MOUNTAINEER. THE ENGINE IN THIS VEHICLE MALFUNCTIONED TWICE WITHOUT WARNING; NO OVERHEATING, NO DASHBOARD LIGHT INDICATORS EITHER TIME. JULY 2004/ODOMETER READING 92213, THE MECHANICS AT THE FREEWAY LINCOLN MERCURY WERE BAFFLED. THEY ADVISED ME THAT ALL THE FLUIDS WERE IN THE VEHICLE. LATER (ONE WEEK) THEY FOUND A "HOLE" IN THE RADIATOR. I WAS TOLD I HAD A NEW ENGINE, WITH A NEW WARRANTY. 2ND TIME WAS JUNE 06, ODOMETER 166199,(NEW ENGINE 73986) NO WARNING, NO DASHBOARD LIGHTS, NO OVERHEATING. PER A DIFFERENT CERTIFIED MECHANIC NOT ONLY WAS THE ENGINE NOT NEW BUT IT HAD SEVERE CORROSION IN IT AND SHOWED SIGNS OF MULTIPLE OVERHEATING CONDITIONS. THEY TOLD ME OF AN "ALL TECHNICAL SERVICE BULLETIN" DATED 1/21/02 FOR MY VEHICLE'S ENGINE REGARDING THE "ENGINE HEAD GASKET"---"SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHICLE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA DUE TO PARTICLE CONTAMINATION OR SCRATCHES AND DENTS TO BLOCK MATING SURFACES." ACTION: REFER TO THE FOLLOWING SERVICE INFORMATION FOR RECOMMENDED GASKET SEALING SURFACE PREPARATION PROCEDURES. IF THE ENGINE DIAGNOSIS POINTS TO A FAULTY HEAD GASKET (LEAKS OIL, LEAKS COOLANT, OIL OR COOLANT CONTAMINATION, OR AIR IN COOLANT), THOROUGH CLEANING PROCEDURES ARE NECESSARY FOR A SUCCESSFUL HEAD GASKET REPAIR. DIAGNOSIS AND POST- REPAIR CONFIRMATION CAN BE DONE SUCCESSFULLY UTILIZING LEAK DETECTION METHODS SUCH AS A BLACK LIGHT DYE PROCESS. SERVICE PROCEDURE:TO SUM UP, A SUCCESSFUL LEAK REPAIR DEPENDS ON:ACCURATE DIAGNOSIS OF THE LEAK USING FORD-RECOMMENDED TEST EQUIPMENT AND PROCEDURES .SURFACE PREPARATION AND GASKET INSTALLATION USING THE APPROVED TOOLS, CLEANERS, AND METHODS.EXERCISING CARE AND CLEANLINESS DURING DISASSEMBLY/ASSEMBLY OF COMPONENTS USE OF GENUINE FORD OEM REPLACEMENT PARTS<USE OF A FORD REMANUFACTURER

TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE VEHICLE WAS PARKED WHEN THE CONTACT OPENED THE REAR LIFTGATE WINDOW AND THE HINGE FRACTURED FROM THE VEHICLE. THE WINDOW FELL ONTO THE CONTACT AND ANOTHER INDIVIDUAL RESULTING IN TWO INJURIES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED NOR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,596.

TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED SHE WAS AT THE DEALER PURCHASING THE VEHICLE WHEN SHE NOTICED THE AIR BAG LIGHT WAS ILLUMINATED. THE TECHNICIANS REPAIRED THE VEHICLE. THE CONTACT WAS NOT SURE OF THE REPAIRS MADE. AFTER THE REPAIRERS WERE MADE, THE CONTACT WAS PARKED WHEN THE FRONT DRIVER SIDE AIR BAG DEPLOYED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TECHNICIANS REPLACED THE AIR BAG AND THE RESTRAINT CONTROL MODULE. HOWEVER, THE AIR BAG DEPLOYED A SECOND TIME. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HER TO CONTACT THE MANUFACTURER. THE MANUFACTURER WAS CONTACTED AND STATED THEY WOULD HAVE TO PERFORM A DIAGNOSTIC TEST ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.