2004 MERCURY MOUNTAINEER Complaints

WIFE WAS CLOSING LIFTGATE AND IT BROKE FROM THE HINGES. THE LEFT SIDE FELL AND HIT HER ON THE HEAD. WAS TRYING TO HOLD LIFT GATE SO GLASS WOULDN'T FALL AND BREAK. CALLED FORD AND THEY SAID IT WAS NOT A RECALL ISSUE. LOOKING ONLINE IT SEEMS THIS HAPPENS A LOT. *KB

TRANSFER CASE DEFECT CAUSES STEERING DIFFICULTY ON SLOW TURNS. TRANSMISSION ISSUE REPORTED TO FORD IN 2005 AT 38,000 MILES. AGAIN AT 51,000. I OPTED FOR AN AAMCO TRANSMISSION WHEN FORD REFUSED TO COVER. NOW TRANSFER CASE IS MAKING DRIVING DANGEROUS. TURNING ABILITY GREATLY REDUCED. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT A LOUD POPPING NOISE COULD BE HEARD WHENEVER THE VEHICLE WAS SHIFTED INTO REVERSE. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD JERK INTO REVERSE AND A BURNING ODOR WAS PRESENT DURING ONE OF THE OCCURRENCES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP ON VARIOUS OCCASIONS AND THE CONTACT WAS INFORMED THAT THE TRANSMISSION FLUID NEEDED TO BE REPLACED. THE TRANSMISSION FLUID WAS REPLACED ON NUMEROUS OCCASIONS, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. UPDATED 10/4/11 *CN UPDATED 10/21/11

2004 MERCURY MOUNTAINEER, REAR HATCH MOLDING WITH MERCURY EMBLEM. TWO WINTERS AGO THE MOLDING CRACKED AFTER A VERY COLD FREEZE. VEHICLE WAS UNDER WARRANTY AND THE ENTIRE HATCH HAD TO BE REPLACED. DEALER HAD VEHICLE 3 OR 4 DAYS AS NEW HATCH WAS SENT OUT TO A LOCAL BODY SHOP TO BE PAINTED, MATCHING THE VEHICLE COLOR. NOW, THE SAME MOLDING HAS BEGUN DE-LAMINATING FROM THE HATCH. DEALER STATES HATCH HAS TO BE REPLACED AND WILL COST $1000.00. *KB

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED, WITH THE REAR LIFT GATE OPENED, WHEN IT BEGAN TO ROLL BACKWARDS. WHILE ATTEMPTING TO ENTER THE MOVING VEHICLE, THE CONTACT WAS KNOCKED DOWN AND SUSTAINED INJURIES. THE VEHICLE CONTINUED TO ROLL BACKWARDS UNTIL CRASHING INTO A TREE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THERE WAS AN INVESTIGATION OPEN UNDER NHTSA ACTION NUMBER: EA09013 (STEERING POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) STEERING:COLUMN STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE) THAT MAY BE RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 82,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THE LIFT GATE GLASS HINGE DISENGAGED AND IMPACTED HER ABILITY TO DRIVE. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

I HAVE A USED 2004 MERCURY MOUNTAINEER I PURCHASED IN 12/2008 IT HAD 53,000 MILES. I HAVE DONE ALL OF THE REQUIRED MAINTENANCE OIL CHANGES,BRAKE PADS,FLUID CHANGES, AND 60,000-MILE SERVICE PACKAGE. I HAVE NOTHING BUT PROBLEMS WITH THE VEHICLE. THE FAILURES I HAVE ARE AS FOLLOWS: 1. FRONT/REAR BRAKE PADS,FRONT/REAR ROTORS,SPARK PLUGS,-DEFECTED PARTS 2. BATTERY 3. TIRES-CONSTANT FLATS 4. LUG TORQUE-DRIVER FRONT/REAR 5. HOOD SHOCKS,TIRE PRESSURE SENSOR LIGHT 6. TRANSMISSION FLUID LEAK/ FRONT PUMP SEAL LEAK 7. NOISE AT HARMONIC BALANCER 8. ROAR NOISE AND SHAKES AT ALL SPEEDS 9. HUB ASSEMBLIES MAKING NOISE FRONT LEFT/RIGHT SIDE; UNLESS REPLACED VEHICLE UNSAFE TO DRIVE PER FORD DEALERSHIP 10. BRAKE PADS- FRONT/REAR NEED TO BE REPLACED GOING BAD (SECOND TIME NEEDING TO BE REPLACED) 11. NEEDS FRONT ALIGNMENT-PULLS TO THE RIGHT SIDE 12. FUEL FILTER 13. NEEDS ALL NEW TIRES 14. IGNITION COIL -DEFECTIVE NEEDS TO BE REPLACED 15. VEHICLE GEAR SHIFTER IS STUCK WHILE DRIVING WON'T SHIFT AT ALL SOMETIMES STAYS STUCK AT CERTAIN SPEED WON'T MOVE 16.UNIVERSAL JOINTS 17. AXLE HOUSING GASKET REPAIRS AND CORRECTIONS DONE ON VEHICLE: 1.NEW BRAKE PADS ON FRONT/REAR,REPLACED SPARK PLUGS, RESURFACED FRONT/REAR ROTORS.- 8/2009 2.BATTERY REPLACED- 4/2010 3.TIRES-FLATS REPAIRED/PATCHED -8/2010,11/2010,2/2011 4.HAVE NOT REPAIRED/REPLACED 5.HAVE NOT REPAIRED/REPLACED 6.REPLACED SEAL, TRANSMISSION FILTER AND FLUID CHANGED,REPLACED SEAL-OIL-6/2011 7.HAVE NOT REPAIRED/REPLACED 8. VEHICLE IS SHAKING AND LOUD ROAR NOISE HASN'T BEEN FIXED-6/2011 9.HUB ASSEMBLIES FRONT LEFT/RIGHT SIDE REPLACED -6/2011 10.HAVE NOT REPLACED/REPAIRED 11.HAVE NOT REPLACED/REPAIRED 12.FUEL FILTER REPLACED-6/2011 13. BOUGHT BRAND NEW SET OF TIRES -6/2011 14.IGNITION COIL REPLACED-10/2009 15. HAVE NOT REPAIRED/REPLACED 16. HAVE NOT REPAIRED/REPLACED 17. AXLE HOUSING GASKET REPLACED-04/2011. *TR

AUTOMATIC TRANSMISSION SHIFTER COMPLETELY BROKE OFF WHEN CHANGING FROM PARK TO DRIVE ON A 2004 MERCURY MOUNTAINEER. *TR

THE REAR PANEL IS CRACKED AROUND THE LOGO OF MY MERCURY MOUNTAINEER. I SEE THIS ON MOST OTHER MOUNTAINEERS AND EXPLORERS FROM THIS GENERATION AND FORD HAS DONE NOTHING TO REMEDY IT. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFTGATE WAS FRACTURED FROM THE DECAL UP TO THE MIDDLE OF THE REAR GLASS. THE VEHICLE WAS NEITHER INSPECTED NOR REPAIRED FOR THE FAILURE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGE WAS 51,029.