2020 RAM 2500 Complaints

I WAS TRAVELING AND AROUND 655 MILES FROM HOME. MY TRUCK WAS IDLEING AND STARTED MAKING A LOUD KNOCKING NOISE. I TURNED IT OFF AND THEN IT WOULDN'T START AGAIN. I CALLED CHRYSLER ROADSIDE ASSISTANCE AND HAD IT TOWED TO THE NEAREST DEALER, BLUEBONNET CHRYSLER DODGE AND RAM. AFTER MY VEHICLE SAT THERE FOR 4 DAYS, THEY FINALLY LOOKED AT IT AND DETERMINED THAT MY CP4 FUEL INJECTOR PUMP HAD FAILED. IT IS ALL COVERED BY WARRANTY, BUT NOW I'M 655 MILES FROM MY TRUCK WITH NOTHING TO DRIVE.

WINDSHIELD BROKE . NOTHING HIT IT. I TURNED THE DEFROST ON AND IT JUST STARTED CRACKING. TRANSMISSION IS SLIPPING DEF PUMP WENT OUT HUB CAPS KEEP FLYING OFF

TRUCK DIED IN TRAFFIC. LOST ALL POWER STEERING, BRAKES, ETC. ALMOST CAUSED A MULTIPLE VEHICLE ACCIDENT, AND LEFT ME STRANDED IN THE MIDDLE OF TRAFFIC UNTIL I COULD GET ASSISTANCE TO MOVE. THERE WAS NO WARNING OR NOTICE BEFORE THE TRUCK JUST QUIT WORKING. A WARNING LIGHT CAME ON AFTER THE TRUCK DIED AND STATED "EXHAUST SYSTEM FAILURE. SEE DEALER IMMEDIATELY".

WHILE COMING TO A STOP I LOST COMPLETE POWER STEERING AND WAS BARELY ABLE TO TURN THE WHEEL TO MOVE TO THE SIDE OF THE ROAD. NO MESSAGES, LIGHTS OR CODES CAME UP ON THE DASH. TRUCK ONLY HAS 4,900 MILES ON IT AND WAS FULL ON POWER STEERING FLUID. AFTER CHECKING EVERYTHING I ATTEMPTED TO DRIVE FROM THE SIDE OF THE ROAD. WHEN THE RPM'S ROSE THE POWER STEERING WORKED NORMAL. WHEN I APPROACHED THE NEXT STOP AND LET MY FOOT OFF THE GAS AND THE RPM'S LOWERED, I LOST POWER STEERING AGAIN AT APPROXIMATELY 30 MPH, LEAVING ME UNABLE TO STEER.

2020 SILVERADO 2500. CONSUMER WRITES IN REGARDS TO SAFETY RECALL. *LD THE CONSUMER STATED THE RECALL REPAIR CALLED FOR THE USE OF DUCT TAPE. AFTER COMPLETION OF THE RECALL, DUCT TAPE WAS VISIBLY PROTRUDING FROM THE TRIM OF THE VEHICLE. *JS

FCA SWITCHED FROM PROVEN CP3 FUEL PUMP TO A CP4.2 FOR MODEL YEARS 2019 AND 2020. THEY HAVE NOW SWITCHED BACK TO CP3 FOR 2021 DUE TO NUMBER OF FAILURES. WHEN IT FAILS IT TAKES OUT THE ENTIRE FUEL SYSTEM AND IT COST 10K FOR REPAIR. MY COMPLAINT IS THAT THEY SHOULD RECALL THE FUEL PUMPS ON THE 2019/2020 RAM 2500 MODELS. IT IS THE RIGHT THING TO DO.

LOSING POWER WHILE DRIVING DOWN THE ROAD. LOSING POWER WHEN PUSHING ON GAS PEDAL. MAKES AWFUL NOISE WHEN STARTING. ALMOST SOUNDS LIKE A BAD STARTER

'POWER STEERING UNAVAILABLE SERVICE REQUIRED' MESSAGE APPEARED ON INSTRUMENT CLUSTER AT 4,596 MILES. POWER STEERING FAILURE OCCURRED WHILE DRIVING IN LIGHT CITY TRAFFIC AND STOPPED AT AN INTERSECTION. THE VEHICLE IS DIFFICULT TO CONTROL WITHOUT POWER STEERING ASSIST. POWERING CAR OFF AND ON DID NOT CLEAR THE ERROR. NOR DID DISCONNECTING/RECONNECTING BATTERY TERMINALS. VEHICLE SAT OVERNIGHT IN GARAGE AND POWER STEERING FUNCTION SEEMED TO RETURN THE FOLLOWING DAY, ONLY TO FAIL AGAIN AFTER 15-20 MINS OF LIGHT STREET DRIVING.

THE 2019 TO 2020 MODEL YEAR RAM 2500 HEAVY DUTY EQUIPPED WITH A 6.7L CUMMINS DIESEL ENGINE HAS A MAJOR SAFETY ISSUE THAT COULD CAUSE A STALL AND INCREASE THE RISK OF A CRASH. THE BOSCH CP4.2 FUEL INJECTION PUMP HAS A VERY HIGH RATE OF SUDDEN FAILURE LEADING TO IMMEDIATE STOPPAGE ON THE ENGINE AND ENGINE BRAKING SYSTEM. THE PUMP DESTROYS ITSELF AND TAKES OUT THE REST OF THE ENTIRE FUEL SYSTEM LEADING TO REPAIRS IN THE $20,000 USD RANGE. FCA & RAM HAVE ATTEMPTED TO REVISE THE PUMP IN LATE (JULY) 2020 TO SOLVE THE ISSUE BUT THE FAILURES KEEP OCCURRING. FOR THE 2021 MODEL YEAR, FCA & RAM HAVE CHANGED THE PUMP ENTIRELY AND REVERTED BACK TO USING AN OLDER, SAFER, MORE RELIABLE DESIGN. NO PUBLIC ANNOUNCEMENTS OF NEITHER THE PUMP REVISION IN 2020, NOR THE PUMP CHANGE IN 2021 HAVE BEEN MADE. THE ISSUE IS SO PREVALENT THAT THE REPLACEMENT PUMPS AND REPAIRS GENERALLY HAVE A 30-90 DAY WAIT PERIOD WHERE THE CUSTOMER IS WITHOUT THE PRIMARY VEHICLE. THIS PROBLEM IS A SUBSTANTIATED SAFETY RISK. ACCORDING TO A TEXAS JUDGE IN A BOSCH CP4.2 LAWSUIT, WHEN ANOTHER AUTOMAKER, GM TRIED TO DISMISS THE CASE SAYING THE PUMP FAILURE IS NOT A SAFETY ISSUE, THE COURT RESPONDED: "THE WORST CASE SCENARIO OF A TRUCK SPONTANEOUSLY STALLING AT HIGH SPEEDS IS NOT A MERE INCONVENIENCE. NOR IS IT A MERE INCONVENIENCE TO SPEND BETWEEN $8,000 TO $20,000 ON REPAIRS TO MAKE THE TRUCKS FIT FOR THEIR ORDINARY PURPOSE. THE COURT REJECTS GM'S SUGGESTION THAT THE RISK OF SPONTANEOUS ENGINE FAILURE WHILE DRIVING IS NOT, AS A MATTER OF LAW, UNREASONABLY DANGEROUS, DEPRIVING THE VEHICLES OF FITNESS FOR THEIR PURPOSE OF TRANSPORTATION.". TOYOTA AGREES: "IF A VEHICLE STALL OCCURS WHILE DRIVING AT HIGHER SPEEDS, THIS COULD INCREASE THE RISK OF A CRASH". FCA & RAM HAVE REMEDIED THE SITUATION FOR THE 2021 MODEL YEAR HOWEVER, THE 2019 AND 2020 OWNERS ARE STILL AT RISK. THE NHTSA NEEDS TO FORCE FCA TO RECALL THESE TRUCKS.

THE 2019 TO 2020 MODEL YEAR RAM 2500 HEAVY DUTY EQUIPPED WITH A 6.7L CUMMINS DIESEL ENGINE HAS A MAJOR SAFETY ISSUE THAT COULD CAUSE A STALL AND INCREASE THE RISK OF A CRASH. THE BOSCH CP4.2 FUEL INJECTION PUMP HAS A VERY HIGH RATE OF SUDDEN FAILURE LEADING TO IMMEDIATE STOPPAGE ON THE ENGINE AND ENGINE BRAKING SYSTEM. THE PUMP DESTROYS ITSELF AND TAKES OUT THE REST OF THE ENTIRE FUEL SYSTEM LEADING TO REPAIRS IN THE $20,000 USD RANGE. FCA & RAM HAVE ATTEMPTED TO REVISE THE PUMP IN LATE (JULY) 2020 TO SOLVE THE ISSUE BUT THE FAILURES KEEP OCCURRING. FOR THE 2021 MODEL YEAR, FCA & RAM HAVE CHANGED THE PUMP ENTIRELY AND REVERTED BACK TO USING AN OLDER, SAFER, MORE RELIABLE DESIGN. NO PUBLIC ANNOUNCEMENTS OF NEITHER THE PUMP REVISION IN 2020, NOR THE PUMP CHANGE IN 2021 HAVE BEEN MADE. THE ISSUE IS SO PREVALENT THAT THE REPLACEMENT PUMPS AND REPAIRS GENERALLY HAVE A 30-90 DAY WAIT PERIOD WHERE THE CUSTOMER IS WITHOUT THE PRIMARY VEHICLE. THIS PROBLEM IS A SUBSTANTIATED SAFETY RISK. ACCORDING TO A TEXAS JUDGE IN A BOSCH CP4.2 LAWSUIT, WHEN ANOTHER AUTOMAKER, GM TRIED TO DISMISS THE CASE SAYING THE PUMP FAILURE IS NOT A SAFETY ISSUE, THE COURT RESPONDED: "THE WORST CASE SCENARIO OF A TRUCK SPONTANEOUSLY STALLING AT HIGH SPEEDS IS NOT A MERE INCONVENIENCE. NOR IS IT A MERE INCONVENIENCE TO SPEND BETWEEN $8,000 TO $20,000 ON REPAIRS TO MAKE THE TRUCKS FIT FOR THEIR ORDINARY PURPOSE. THE COURT REJECTS GM'S SUGGESTION THAT THE RISK OF SPONTANEOUS ENGINE FAILURE WHILE DRIVING IS NOT, AS A MATTER OF LAW, UNREASONABLY DANGEROUS, DEPRIVING THE VEHICLES OF FITNESS FOR THEIR PURPOSE OF TRANSPORTATION.". TOYOTA AGREES: "IF A VEHICLE STALL OCCURS WHILE DRIVING AT HIGHER SPEEDS, THIS COULD INCREASE THE RISK OF A CRASH". FCA & RAM HAVE REMEDIED THE SITUATION FOR THE 2021 MODEL YEAR, HOWEVER THE 2019 AND 2020 OWNERS ARE STILL AT RISK. THE NHTSA NEEDS TO FORCE THE HAND OF FCA TO RECALL.