2016 RAM 2500 Complaints

2016 Ram 2500 ABS and HCU have caused problems while driving. My brakes are engaged and will sometimes bring the vehicle to a stop. While having problems with my brakes, I scheduled an appointment with my local Dodge/Ram service department. On the way to the service department March 2023, the brakes again started having problems and completely engaged on a busy bridge bringing the truck to an immediate stop. Not a fun moment. The closest tow truck was two hours away and after 40 minutes, I was able able to get the brakes dis-engaged and limped the truck to the service center. The service department had trouble replicating the issue because the computer reset after i drove the vehicle in. It wasn't till the third test drive the technician had the issue happen to him. I've read about numerous other similar issues with the same truck and braking system, and this could cause a serious incident where someone could get hurt. Even after getting a new ABS, I'm still having issues 6 months later with the brakes locking up. I took it to a new service center and again, the technicians are saying there is no issue because the computer has reset when the issue went away while driving it in to get looked at. It concerns me the Ram has not stepped up to fix this issue.

We were driving our 2016 Ram in July 20, 2023 to Yakima, WA which is 200 miles away from our home. About 50 miles north of town, our check engine light came on and our power was reduced to a minimal speed. We cautiously drove to the next rest area and turned the engine off. We waited about 30 minutes, restarted the engine and continued to Yakima. We had the code checked and turned off at an Oreily's parts store. We drove it to an Independant diesel service center since the Ram dealership's schedule was 2 months out to look at it. After several hours and troubleshooting, the diesel technician determined that the Cumins Actuator and Turbo were failing. Each time they cleared the code and drove the truck, they could recreate the problem. They told us that it was the same problem that the 2015 Cumins Turbos & actuators were having. They said there is a chance that our truck was manufactured with the same parts as a 2015 Cumins. They were able to repair our truck and said that we should notify the NHTSA, Mopar and our local Ram dealer of the problem. Mopar told me there is no recall for this issue, so they cannot help. The local Ram dealer told me that since they did not do the repair, they cannot report the issue. Please help us as this was an expensive repair, not including the cost of being standed out of town for days. Our Ram only has 39,000 miles and is like new, always garaged and drove for pleasure. How can we get this investigated or reimbursed?

Abs light and traction control light came on. The rear parking sensors and 4 wheel drive were also disabled. Repair shop stated that a wheel speed sensor was bad, replaced it and on the way home the lights came on again. Took truck back to shop and they stated another wheel speed sensor was bad. Replaced and then once again, lights came back on while driving home. Took back to the shop and they stated the connections to abs module were dirty, cleaned and sent me back home. Once again, lights came back on. Lights are now on and I have no idea how to repair other than to continue throwing parts and money at it. With Abs disabled, mine and my family's safety are at risk while driving, especially considering this truck is used to tow heavy loads, including livestock. Apparently this is a wide spread issue based on internet reports and has been reported on many of these trucks, regardless of mileage.

The contact owns a 2016 Ram 2500 equipped with Landsail Tires, Tire Line: CLX-1, Tire Size: LT275/70/R18, DOT number: TBDEF75C. The contact stated while driving 50 MPH, the tread of the front passenger’s side tire separated, causing the vehicle to start shaking abnormally. The vehicle was taken to an independent mechanic where it was confirmed that the front passenger’s side tire tread had separated. The tire as not replaced. The tires were replacement tires. The dealer was not contacted. The manufacturer was not made aware of the failure. The vehicle failure mileage was approximately 42,000. The tire failure mileage was 34,449.

Abs/hcu failure causing erratic braking brakes locking up. Diagnosed idepentdant shop,not yet repaired. No inspection Abs warning

Hello! We have the driver seat and passenger seat that unlock after driving every mile. I have called the dealership and Chrysler and they say they cannot help me. This is a safety issue and I need assistance now

Right rear air bag twisted and got against the exhaust which caused the vehicles suspension to drop or not hold air. I was told it was the compressor leaking through and had compressor replaced. It is not the compressor and the vehicle right rear suspension continues to loose air. When the vehicle was looked at again the airbag was untwisted and had a burn mark from exhaust. This is definitely a safety issue concern! This has been ongoing since 2017 with no recall on this vehicle. I had it in the shop again for the same thing and was told this issue could not be resolved!

Driving truck and automatic changed to manual 4th gear - would not stay in automatic and would not go into any other manual gear at same time cruise stopped working along with the horn, seat belt light came on and would not go off , ESC light came on and did not go off, non of the steering wheel controls would work work , air bag light came in and would not go off , horn would not work at steering wheel but will when using key lock

All brake warning lights came on , cruise control stopped working abruptly, service brake system warning dinger dinging , abs not working , engine braking all stopped working while loaded going steep grade , nearly lost control of the truck and was nearly in a serious accident , abs module and hcu said to be problem , issue still persists after said problem supposed to be resolved , truck is a death trap and there are multiple complaints about it , hcu and abs module are months back ordered , this needs recalled

ABS/traction control lights on dash and cruse control won’t work with these on. Haven’t taken to dealer but researched online and believe it to be the abs/hcu unit.