2022 RAM 2500 Complaints

Truck will regen every 100 miles, then Truck will come up with regen message then immediately come up with see dealer full dpf. Truck will start shutting down causing a safety hazard for family in truck. Dealer and ram will claim nothing is wrong with truck. And that we need to continuously pay for dpf manual regen $500 per manual regen (happens once a year). Truck has 32,000 miles and is a 2022. Dealer claims they did the recalls.

Hydraulic roller lifter failure. Very common these pickups . Mine went in for a ticking noise hydraulic roller lifter failed got stuck in the bore. They replaced all 16 they test drove it stuck exhaust lifter #2 they replaced that lifter and the camshaft. Engine still has a very loud clatter and ticking noise. Did not do this when it was brand new

The Mass Air Flow (MAF) sensor on my 2022 Ram 2500 failed, causing multiple system malfunctions. It triggered inaccurate Diesel Particulate Filter (DPF) codes and showed abnormally high idle hours that do not reflect actual vehicle use. This defect is tied to a known issue identified by Stellantis in Technical Service Bulletin #18-002-24, which acknowledges improper MAF sensor calibration or compatibility on vehicles like mine. The bulletin was verbally confirmed by the dealership as applying to my truck. This faulty sensor caused emissions system errors, degraded engine performance, and may impact emissions compliance. There was a persistent check engine light, reduced fuel economy, and the risk of engine derating. The problem was reproduced and confirmed by Encore Chrysler (Mobile, AL), an authorized Ram dealership. Stellantis has agreed to cover the repair under Goodwill, but the issue appears systemic. Safety was potentially compromised by inaccurate sensor data that may cause sudden engine derate or failure during operation. Additionally, the incorrect idle hour readings could affect warranty determinations and long-term diagnostics if not corrected. The check engine light first appeared on May 21, 2024. The vehicle has been out of service since May 22, 2024, and repairs are still pending. The MAF sensor and affected systems are available for inspection upon request. This issue may affect a broader set of Ram 2500 trucks, and given the manufacturer’s internal bulletin, it may merit a recall review.

The radio screen will cut out and turn black randomly but will continue playing music. When this occurs, the screen will not turn back on even if the truck is put in reverse. This is a serious safety concern since the back up camera is inoperative. This has happened three separate times in the past month, and I have video of two instances that was provided to the dealership.

I bought my 2022 Ram 2500 brand new as a factory order. It is currently in the shop at Ron Lewis Ram in Cranberry Twp, PA to get a rear window water leak diagnosed. The dealer has told me that the rear windows frame is cracked in multiple places and wont be covered by my 8 year/125,000 mile max care warranty. I told them that it should be covered since its apparently a factory defect that caused the issue. They informed me that since I am at 55,000 miles, Ram wont pay to repair the issue, that I had until 36,000 miles to have this issue and have it repaired. Through the power of Google search, I was able to find that countless Ram 1500 trucks have had this identical issue and a TSB exists for it. The TSB for the Ram 1500 (23-098-23 Rev A) states that it was caused by a manufacturing issue, that the repairs will be made, and that Ram will cover the repair until the truck hits 8 years/ 150,000 miles. I cannot find a TSB for the 2500 trucks that have the identical issue and I can't believe for a second that I have the only 2500 Ram on the road with this issue, especially after seeing the identical problem with the Ram 1500 and even the Jeep Gladiator, all from the same manufacturer of Stellantis- who owns both Ram and Jeep. The dealer says that I will have to pay a couple of thousand dollars out of pocket to have these repairs made on my own.

5th gen ram with the 6.7 Cummins diesel have a massive problem with lifters. Extremely common for trucks with under 10k miles needing the extensive repair done. I’ve read in some cases people whole motors breakdown due to this failure while on the highway pulling a load. My specific truck had to have all the lifters replaced at 76k miles. There needs to be a manufacture recall on these.

Seat belt system seems to have stopped retracting on both front seats. Truck has a little over 36k miles. Almost never has a passenger.

I was out plowing when my wipers stopped working. brought it in for service and they first said the wiper motor was bad cost for diagnoices was $169.00 issue was not the motor. after second trip for service they found a defaulty fuse box additional charge over $800.00. I have read severl other complaints about the fuse boxes causing issues such as lose fuses etc. Repair Estimate Service Advisor Jonnah Matthews (031) [email protected] PREPARED FOR [XXX] [XXX] Date 03/29/2025 03:53 PM 2022 Ram RAM PICKUP 2500 VIN [XXX] Mileage 40,478 RO# [XXX] Service Name Price [Primary]: DIAG2 - STANDARD DIAGNOSIS SYSTEM STANDARD DIAGNOSIS SYSTEM WIPER MOTOR IS INOP, WIPERS WILL NOT WIPE. INSTALLED IN ANOTHER TRUCK AND IT WORKED OKAY, PLEASE CHECK $0.00 Fuses: fuse box $798.88 Printed on March 29, 2025 Quote expires on April 28, 2025 Subtotal $798.88 Total $798.88 McGee Chrysler Dodge Jeep Ram of Barre 1365 U.S. Route 302 Barre, VT 05641 8024764724 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We own a RAM 2500 truck with an Integrate Brake Controller that is used to activate the trailer brakes on our 10,000+ lb 5th wheel RV. On our last rv trip, the Brake Controller test was not producing the necessary braking function on the trailer (putting more stress upon the trucks braking system). We became acutely aware of this as we attempted to stop on a downhill grade (highway exit ramp) where the traffic control switched to Red. We were barely able to stop in time, which had not happed in the past. When we arrived home, we did research and decided to switch the RV brakes from Drum to Disc brakes based upon research and our belief that the brakes were simply not sufficient for the RV Trailer. We had an RV shop install a brand new disc brake (electric/hydraulic) brake system. When we went to pick up the RV, we tested the brakes and they continued to be very weak (despite working on the RV dealers test equipment and truck). We had the RAM dealership test the brake controller and they said that it was "operating", despite the fact that it is not triggering the necessary braking action. When I went on-line to research, I found many posts in the RAM owner forum that discussed this exact issue from many RAM owners. All had pursued repairs from their dealers, all to no avail. RAM denies that their controller is the problem, yet owners who go through the process of replacing their OEM equipment with aftermarket controllers all report that their brakes now operate as intended. These posts encourage folks who have similar problems to report to this website in the hopes that an investigation and recall would be triggered. I can't wait for the government to finally get convinced that this is a problem as I cannot go on the road with this brake controller in its current state. It is an incredibly dangerous condition, and I sincerely hope that you will take action to investigate and take the appropriate action with RAM/Dodge.

Vehicle has continuous ongoing issues since day of purchase with big screen radio display. System randomly changes screens and drops connection with source over and over again while vehicle is in operation. This is also affecting the rear parking assist sensor system making it work randomly at times and give false triggers or sometimes no triggers when collision is about to happen. The random screen changes are an EXTREME distraction while driving because the screen is extremely large in the center stack and when the image is randomly changing in your peripheral vision it draws driver's attention off the road. These connection issues also affect audio sources and make it necessary for the driver to interact with touch screen a ridiculous number of times per short drive further distracting the driver. There has been ongoing issues with this vehicle since the day I purchased it new. Multiple attempts by multiple different Ram dealerships to repair/resolve the issues with no solutions found yet. Actual radio unit in dash was replaced with 2 new units by dealers in attempts to resolve issues with no improvements. Dealerships have worked with Ram engineering and opened multiple STAR cases on vehicle in relation to these problems. Contacted Ram customer care multiple times and requested Ram buyback or deem this vehicle as lemon law vehicle. To date vehicle has been in for attempted service for these issues more than 4 times and would have been in 2-3 times this number of visits if not such an extreme inconvenience. Demanded Ram buyback the vehicle and have got pushback from them. Vehicle has been in service since May 2023, was purchased new from dealer with less than 100 miles on odometer.