2020 RAM 3500 Complaints

Codes: P2002, P242F, P2463, P1451 Failures: DPF, Charge air cooler leak, PM sensors, EGR internally cracked, Catalytic Convertor, Pink tinged oil, strong diesel odor in oil - post failures. Erratic def gauge readings, unstable idling, clunking downshift when exhaust brake decelerates, warm up stumbling. Power reduced, see dealer (over and over and over and over). Limp Mode (5 MPH). Permanent ticks/taps from front left motor, front passenger wheel well, passenger side mid-truck. Extremely loose gear shifter plus an occasional “Vehicle Not in Part” message on the dash display. Manufacturers Service Center (local and ONLY Ram dealership) has reproduced the issue. Independent Diesel Mechanic shop also reproduced. Service center and Independent shop both inspected. The safety issues of a 5 MPH limp mode and risk of sudden engine stalls while driving in traffic, especially on an interstate should be fairly self explanatory… As is a constant “Power Reduced See Dealer” problem, when your truck is used to do what it’s designed to do… Tow large loads. As is an extremely loose gear shifter that doesn’t always properly register as “in Park”. The date listed below is simply the date of the very first occurrence. It’s not a representation of every date after. The most recent date was just last week.

The contact owns a 2020 Ram 3500. The contact stated while the vehicle was parked, he noticed that coolant was leaking underneath the vehicle. The EGR warning light was illuminated. The contact stated that upon adding coolant to the EGR valve, the contact noticed that coolant was still leaking. The vehicle was taken to the dealer, where it was diagnosed that the EGR valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 115,000.

The contact owns a 2020 Ram 3500 equipped with Atturo Tires, Tire Line: Trail Blade A/T, Tire Size: 235/80/R17, DOT Number: KA0HD80R4223. The contact stated while driving approximately 50 MPH, the front passenger's side tire experienced a blowout. The contact pulled over to the side of the road. Upon inspecting the tire, the contact noticed that the tread had separated, causing the tire to blowout. The contact replaced the tire with the spare tire. Additionally, the contact stated while driving at an undisclosed speed, the front end of the vehicle was shuddering. The vehicle was taken to the tire shop, where it was determined that the front driver's side tire tread had separated. The front driver's side tire was replaced under warranty. The tires were replacement tires. The tire manufacturer was not notified of the failure. The tire failure mileage was approximately 4,000. The vehicle failure mileage was approximately 28,000.

Reoccurring messages regarding DEF, Exhaust Regeneration, and DPF, causing more and more frequent ReGen for longer and longer. Numerous trips to various Ram dealerships resulting in codes being cleared and then being told it was a software issue. After 2 years of this intermittently happening, we experienced an extended Regen that lasted hours and did not clear out the error code. Ram dealer in Utah charged $280 to do a stationary regeneration and once again clear out codes. Less than 6 months later with more and more Regens, a failed regen sent truck into Low Power Mode (losing the ability to tow or excelerate quickly). We ended up having to take it to a Ram dealer over 2 hours away in S. Atlanta to have them take it apart and tell us that the factory installed wiring harness rubbed a hole in the charged air cooler boot which was then causing failed regeneration of the diesel particulates causing the filter to fill. Dealer clearly stated that had any other dealer done a visual inspection of the physical components they would have seen this occurring. We filed a claim and opened a case with Ram for the $4500 repair and waited 8 days with no response to 9 phone calls. The same day we authorized the work, we receive the coveted return call to start the process, but once the customer service rep found out we had already authorized the work we were advised that case would be closed and we would have to open another case for reimbursement. So we started the whole process again, submitted all of the documentation and paid receipts and have been denied. All attempts to contact a supervisor or manager go nowhere and Ram customer service is rude and unhelpful and went as far as to tell us that our mistake was having the vehicle repaired (as if we are just going to let an $80k vehicle sit indefinitely in an unusable state).

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 22V835000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

I live in northern California near San Francisco, and we were traveling from Cottonwood, AZ back to our home. Back in June of 2023 we were traveling near Kingman, AZ and had the front passenger tire explode, almost losing control of the truck and trailer. We were at 19524 miles on the truck. At the time I thought that maybe I had hit something. But two months later I took the trailer to Carson City, NV for work and just before I got into Reno the truck started to shake from side to side in the front and the next day I took it to a tire shop and they told me that the driver’s front tire was getting ready to come apart and I had only put about 800 miles on the truck since the first tire had exploded. This was when I realized the issue was the tires. I immediately had all 6 tires replaced. You can find a lot of bad comments about these tires on-line with comments like what happened to me. EXAMPLE [XXX] In response to your questions 1.I don’t have the tires that died just pictures. 2.After the blowout steering was difficult. 3.No Dealer confirmation. 4.No inspections. 5.Before the first tire exploded for about 20 miles I noticed a vibration in the front end. But just thought it was just the road. Tire Size - LT235/80R17 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ram 3500. The contact stated that while driving 75 MPH, the vehicle was shaking and then lost motive power. The check engine warning light later illuminated. The vehicle was towed to the dealer, where NHTSA Campaign Numbers: 21V880000 (Fuel System, Diesel), 21V398000 (Wheels), and 22V904000 (Structure) were performed. However, the failure recurred. The vehicle was then towed to Gulfgate Dodge Chrysler Jeep Ram (7250 Gulf Fwy, Houston, TX 77017), where it was diagnosed that the fuel line had failed, and the fuel injectors and fuel rail needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 150,000.

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Vehicle will not go into park and shut off. I could not turn the engine off. Not having the ability to turn the motor off is a safety concern. This has progressed to where it says vehicle is not in park while vehicle is in drive and moving. The problem is intermittent and I have documented it with multiple pictures and videos and witness accounts but the dealer has not been able to reproduce the malfunction. The service representative has been helpful but has not been able to. The vehicle has not been inspected by the police or other independent representatives. The vehicle does not have any codes associated with it. This same exact series of malfuctions occurred on my 2016 Ram 2500 and the valve pack on the transmission failed and the vehicle would not move and eventually the transmission failed. Then the emission software would not extinguish the check engine light even though there were no issues. The dealer reinstalled the software and after less than 25 miles the same issue happened. I traded in the vehicle because Ram would not honor the warranty and I could not pass smog with a check engine light on and nothing wrong with the sensors or the output. Now I am having problems with the 3500 progressively going in the exact same way as the 2500. I have had to take it to the dealer 6 or 7 times in as many months and less than 10,000 miles.