2020 RAM 3500 Complaints

The contact owned a 2020 Ram 3500. The contact stated that the vehicle would surge whenever he depressed the accelerator pedal while driving. There were no warning lights illuminated. The contact then received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel). The contact notified several unknown dealers of the failure. The dealers informed the contact that though the failure was associated to the recall, they could not assist as the manufacturer had not authorized them to repair the vehicle. The contact then inquired assistance with obtaining the parts for repair and the dealer informed the contact that the manufacturer did not authorize them to sell the parts for repair. The manufacturer was notified of the failure and informed the contact that they would not assist as the vehicle was safe to drive. The vehicle was not diagnosed or repaired. The contact later sold the vehicle to an auction. The failure mileage was approximately 13,300.

The contact owns a 2020 Ram 3500. The contact stated while driving 5 MPH, the oil pressure warning light illuminated. The contact then drove back to his residence. Upon opening the hood to check the oil pressure, the contact noticed that the oil consistency was like jelly. The vehicle was towed to the dealer where it was diagnosed that lack of engine oil, caused engine to cease and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer then followed up with the dealer who provided an estimate for the repair. The manufacturer informed the contact that the engine replacement would not be covered under the warranty however, a vehicle buy back would be considered. The failure mileage was approximately 140,867.

0N 4/4/2022 while traveling on interstate 64 E in WV ,towing an R V camper , no warning signals on the dash screen, my truck started losing power and went completely dead,just missed by a tractor trailer rear ending me, as I rolled off to the side of the road. Iwas towed to the nearest Dodge dealership. When I arrived at the dealership a mechanic came and open the hood, he found diesel leaking and a metal rod of the camshaft sitting on top of the engine, which he stated shot through the engine block. Warranty company doesn't want to tear down engine after I gave approval to investigate issue. This is my work truck and source of income. Four weeks later, I am not getting help from dealership that sold me the truck and warranty. Warranty company is trying to use loop hole to get out of paying. I found similar complaints, reported to the NHTSA, engines falling apart while driving down the road. I had to pay for my truck to tow from WV to Charlotte NC to my driveway. I have a case# with the Dodge Customer Care Department and they are just informing me that the truck has recalls, but parts are not avaible at this time.

While towing 5th wheel vehicle check engine light came on I was out of state in arizona vehicl then started to stall I canceled my trip checking all fluids headed back to California as I was nowhere near a dealership made a appointment at ram dealer when I got there light went out I talked with technician he said would have to leave it for 3 weeks before they could look at vehicle needless to say I took it home then in early Feb about 3 weeks after the first incident the check engine light came on again made appointment which was 3 weeks away just to check it in shop and a week before they even looked at the issue they found a cracked hose on inter cooler dealer stated vehicle ok well again on March 4 2022 vehicle again has check engine light on I took to auto store to check code same as before vehicle regeneration frequency it Regenerates ever 100 miles runs poorly uses excessive fuel hesitates when pedal depressed and long cranking time so now I have to be without a vehicle again

The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. UPDATE AS OF 6/24/22: Normandin Chrysler Jeep Dodge Ram, San Jose CA has put owner on a waiting list for parts. Service Director says that the manufacturer will only allow them to order one (1) parts kit for the Y78 / NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) recall once every 7 business days. The dealer says they have a waiting list of approximately 40 customers waiting for repair of this recall. Has told contact that it is expected to be several months before the Y78 recall can be fixed on the contact’s 2020 Ram 3500. Contact finds that this is unacceptable to have such an extreme delay in parts availability for the recall.

The contact owns a 2020 Ram 3500. The contact stated while driving 55 MPH, the Diesel Exhaust Fluid (DEF) warning light illuminated. The contact was able to continue driving to his residence. The vehicle was taken to the dealer on three separate occasions to be repaired; however, the repair failed to correct the failure. The manufacturer was notified of the failure. The approximate failure mileage was 27,000.

DEF reservoir got low and light came on indicating about 300 miles until truck goes into limp mode 5 MPH. Added 1 gallon of DEF and the guage showed to be in the safe zone. The computer system never registered that fluid was added and truck went into limp mode on the way home. When in limp mode you are unable to move vehicle off the roadway in a safe manner or even drive on any roadway without major risk of getting hit. Truck has to be towed to a dealership to have the computer reset. EXTREMELY DANGEROUS. Ironic that first responder and government vehicles with this same engine ect are omitted from the limp mode function due to safety concerns but not the general public.

The contact owns a 2020 RAM 3500. The contact stated that while driving at 15 MPH, the oil warning light was illuminated, and the vehicle made abnormal sounds. Additionally, there was smoke coming from under the hood of the vehicle. The contact pulled over and refilled the oil reservoir; however, the failure recurred with oil leaking from the vehicle. The vehicle was towed to the dealer and diagnosed with engine damage and connecting rod failure, which punctured the engine block. The engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. Upon investigation, the contact related the failure to NHTSA Campaign Number: 20V511000 (Engine and Engine Cooling, Electrical System) however, the VIN was not included in the recall. The failure mileage was approximately 213,000. The oil light did not come on until after the engine had started knocking rapidly. The engine oil also ran out quickly as well. Consumer immediately refilled the oil and drove for 5 minutes and the engine stopped knocking for a few seconds before there was louder knocking, smoke and spewing oil. Consumer had previously reported to the customer care FCA group 2 times last August about metal shavings on the fuel filter. The fuel pump continued to produce metal shavings in the filter every time the filter was change.

This Laramie trim level truck has an electronic drop tailgate with a button to drop the tailgate on the overhead console and one on the key fob. The tailgate on my truck was closed during my pre-trip and entering the vehicle. I had a trailer hooked to the receiver hitch and drove ten miles before realizing the tailgate was now in the down position and caused significant damage to the tailgate because the tailgate made contact with the trailer. With the electronic release tailgate on this particular year truck there is not a warning message alerting the driver that the tailgate is ajar. There is such an alert on newer models (2021-2022) I went to a local dealership to check. I’m sure the tailgate drop button somehow was pressed on the key fob while in my pocket entering the truck. But I did not receive any alert on the instrument cluster or even hear the tailgate open because the tailgate has a soft open feature. I see this being a serious safety concern to possibly lose cargo and cause a more serious accident.

The contact owns a 2020 RAM 3500. The contact stated while her husband was making a right turn, the vehicle began to stall. The contact stated do not turn off the vehicle until arriving at destination warning message was illuminated. The driver was able to continue driving under 15 MPH until arriving at a local dealer. The local dealer was unable to duplicate or diagnose the cause of the failure. The contact was informed that a specialist was needed to diagnose the vehicle. The contact stated that the dealer called back 2 days later and stated that some unknown cables needed to be replaced. The vehicle was repaired but continued to experience the same failure. The contact stated that the failure had been experienced a third time. The VIN was associated with NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) and 21V398000 (Wheels). The manufacturer had not been informed of the failure. The failure mileage was approximately 24,000.