2023 RAM PROMASTER Complaints

The contact owns a 2023 Ram ProMaster 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

The contact owns a 2023 Ram ProMaster 2500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

On December 23, 2025, a 2023 RAM ProMaster 2500 Van used as a commercial fleet delivery vehicle in [XXX] suffered an engine compartment fire. The vehicle was declared a total loss by the insurance carrier. At the time of the fire, the vehicle was subject to open Safety Recall 25V-720 / Manufacturer Recall 67C, issued by FCA US LLC for a defective cooling fan module with premature bearing wear and inadequate fuse protection on the 400W fan circuit — the exact defect identified as a known fire risk. No remedy was available at the time of the incident. The interim recall notification letter had been received but the vehicle could not be repaired as FCA had not yet developed or made available a fix. The vehicle was inspected by insurance representatives and declared a total loss. No warning lamps or prior symptoms were observed before the fire occurred, consistent with NHTSA's own warning that affected vehicles may fail suddenly with no prior dashboard alert. The component believed to have failed is the cooling fan module. It is unknown whether the component remains available for inspection as the vehicle has been transferred to the insurance carrier as part of the total loss settlement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Ram Promaster 2500. The contact stated that while driving at an undisclosed speed, the steering wheel was shaking abnormally. The Forward Collision Avoidance warning light was illuminated. Additionally, the contact stated that the failure had occurred while driving over a speed bump or while turning the steering wheel. The vehicle was taken to an independent mechanic, where it was diagnosed with EPS control module connector failure. The contact was informed that the EPS control module connector needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but provided no assistance. The contact stated that the failure was a known failure with the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.

The electronic power steering system randomly cuts out. While turning on the on ramp, speeding up to get up to highway speeds the power steering randomly cuts out when hitting small bumps. This caused the van to almost drive into the wall going 40+ mph. I had to use 2 hands an a lot of force to correct the steering. This is especially scary because I regularly drive on snowy roads on i70 in the winter. On a slick surface this would cause me to loose control of the van with no way to correct it. The problem has not been confirmed by a dealer. The vehicle has not been inspected by the manufacturer/police/insurance. There were no warning signs.

EcoFlow unit wires crimped, may be inadequate on size of wire from alternator to EcoFlow unit . Leading to overheating and potential fire danger .

On 3/13/26 we were driving to a location to make a delivery when the steering locked up causing loss of control, the driver was able to correct the van and was able to limp it back to our location, we contacted our dealer Bob Johnson Chrysler in Avon NY where we just dropped it off today 3/17/26 , He stated that he hadn't heard of any issues with that vehicle, but I looked up the cause and saw that there has been a ongoing problem, luckily our driver was going slow enough to be able to gain control before he crashed. this van was purchased new from this dealer in November of 2022 and only has 13500 miles on it. The dealer hasn't looked at it yet but said its out of warranty and probably wont be covered

The contact owns a 2023 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Steering wheel hard to turn. Not able to react quickly. Confirmed by independent service center that the rack and pinion is faulty. Not inspected by anyone else, and no warning lamps illuminated. Independent repair shop is going to replace rack and pinion.

Emergency call system has never worked. Dealership and Chrysler have done nothing to resolve the issue