2006 SATURN ION Complaints

2006 SATURN ION. CONSUMER RECEIVED REPAIRS DUE TO RECALL AND IS SEEKING REIMBURSEMENT. *TA THE IGNITION CYLINDER AND IGNITION SWITCH WERE REPLACED ON APRIL 6, 2012. ON AUGUST 8, 2012, THE IGNITION LOCK AD IGNITION HOUSING WERE REPLACED. *JB

I SMELT GAS SO I BROUGHT IT TO MY MECHANIC. HE SAYS THAT THE FUEL PUMP HAD A CRACK AT THE INLET. I SEE THAT THERE ARE 2006 AND 2007 SATURN IONS THAT WERE RECALLED BECAUSE OF THIS ISSUE. I WAS CURIOUS WHY OR IF THERE WERE SIMILAR COMPLAINTS FOR THE RANGE THAT VIN FALLS WITHIN. IT LOOKS LIKE IT DOES ACCORDING TO HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/ACM13505162/RCRIT-09V419-3422.PDF BUT SINCE I DIDN'T BUY /REGISTER IT IN ARIZONA OR NEVADA THAT IT DOESN'T APPLY. NOT SURE WHY IT WOULD ONLY APPLY TO TWO STATES SINCE MY VIN FALLS WITHIN THAT RANGE. ANY THOUGHTS ARE APPRECIATED. THANKS! *TR

WHILE DRIVING THE CAR WILL AUTOMATICALLY SHUT OFF. I CAN BE ON THE FREEWAY AT 55 MILES AND THE CAR WILL JUST DIE. I CAN BE AT A STOP LIGHT AND THE CAR WILL DIE. I HAVE TAKEN IT IN AND TWICE THEY SAID THEY FOUND NOTHING HOWEVER THE PROBLEM STILL EXIST. I THOUGHT THAT WITH THE RECALL REPAIR OF THE IGNITION SWITCH IT MIGHT HELP BUT IT HASN'T AND MY KEY STILL GETS STUCK IN THE IGNITION AT TIMES AND I DON'T EVEN HAVE ANYTHING HANGING ON THE KEY ONLY THE REMOTE. BASICALLY ONCE YOU FEEL THE CAR LOSING POWER AND ALL DASH LIGHTS SHOW UP, YOU NEED TO RESTART THE CAR TO PROCEED. VERY DANGEROUS ESPECIALLY ON THE ROAD. *TR

2006 SATURN ION. CONSUMER REQUESTS REIMBURSEMENT FOR RECALL STEERING REPAIRS. *SMD THE CONSUMER STATED IN JUNE 2010, HE BEGAN TO EXPERIENCE SUDDEN LOSS OF POWER STEERING. THE STEERING COLUMN AND MOTOR ASSEMBLY WERE REPLACED. IN OCTOBER 20104, THE CHECK ENGINE AND REDUCED ENGINE POWER LIGHT ILLUMINATED. THE CONSUMER WAS INFORMED THE LIGHTS WERE ON DUE TO A STEERING RECALL. THE CONSUMER STATED THE WORK HAD PREVIOUSLY BEEN DONE. THE CONSUMER IS NOW SEEKING REIMBURSEMENT. *JB

TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED AFTER STARTING THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE RESTARTED AND RESUMED NORMAL FUNCTION. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE STEERING MODULE IN THE STEERING COLUMN NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,189. UPDATED 3/31/15*CN THE CONSUMER STATED HE DID NOT HAVE ANY PROBLEMS, UNTIL THE DEALER REPLACED THE STEERING MOTOR. UPDATED 04/07/15

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE POWER STEERING LIGHT ILLUMINATED AND THE STEERING WHEEL BECAME TIGHT. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 233,000. THE VIN WAS UNAVAILABLE.

YET ONE MORE IGNITION HAS FAILED. I HAD THE RECALL DONE ON THE OTHER TWO RECALLS. YET, LESS THAN A MONTH AFTER THE LAST REPLACEMENT THE KEY WOULD NOT COME OUT. I TRIED LOOKING FOR THE KEY RELEASE ON THE STEERING COLUMN THAT ON PRIOR RECALLS THEY SAID WAS THERE. IT IS NOT. I HAD TO PULL THE BATTERY CABLES AS BEFORE TO GET THE INTERIOR LIGHTS OFF. I CAME OUT TO THE CAR ABOUT AN HOUR LATER AND WAS ABLE TO REMOVE THE KEY. I SPOKE TO THE GM REP WHO SAID THEY WOULD REPLACE IT WITH ANOTHER ONE (THE SAME MODEL, ETC) AND I'D HAVE TO COME BACK INTO THE DEALERSHIP. I TOLD THEM NO, I HAD RECEIVED UNBELIEVABLE HIDEOUS SERVICE THERE SINCE BUYING THE CAR AND WITH THE OTHER RECALLS. WAS TOLD TO DRIVE THE HOUR AND A HALF TO THE NEXT NEAREST ONE. AGAIN DECLINED. I WAS TOLD THAT IF I TOOK IT TO THE SHOP I USE THEY WOULD NOT PAY THE LABOR. THIS IS IGNITION NUMBER FOUR NOW. I AM TAKING IT TO THE SHOP I USE TOMORROW AND WILL DO BATTLE WITH GM AFTERWARDS. *TR

TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THERE WAS A STRONG FUEL ODOR. IN ADDITION, THE CONTACT NOTICED FUEL LEAKING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNED A 2006 SATURN ION. WHILE DRIVING AT 64 MPH, THE STEERING WHEEL SEIZED CAUSING THE CONTACT TO LOOSE CONTROL AND SWERVE TO THE LEFT LANE. ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE, CAUSING THE VEHICLE TO SPIN OUT OF CONTROL SEVERAL TIMES. THE SECOND VEHICLE CRASHED INTO THE CONTACT'S VEHICLE. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000. ..UPDATED 03-16-15 *BF UPDATED 6/18/2015 *JS

ELECTRIC POWER STEERING QUIT WORKING WHILE DRIVING; POWER STEERING ERROR MESSAGE ALSO APPEARED ON THE DRIVER INFORMATION DISPLAY. THIS VEHICLE HAS HAD THE POWER STEERING RECALL PERFORMED RECENTLY (APPROXIMATELY 3 MONTHS AGO - RECALL CONSISTS OF REPLACING THE POWER STEERING ASSIST MOTOR). WHEN IT QUIT WORKING, I PULLED OVER, SHUT OFF THE CAR, THEN RESTARTED IT, TO SEE IF THE POWER STEERING WOULD START WORKING AGAIN. SAME ERROR, STILL NO POWER STEERING. POWER STEERING RETURNED UNEXPECTEDLY WHILE GOING AROUND A TURN APPROXIMATELY 3 MILES LATER, CAUSING THE CAR TO TURN MUCH SHARPER (AS THE EFFORT NEEDED TO TURN WAS UNEXPECTEDLY REDUCED). *TR