2004 SATURN ION Complaints

TRANSMISSION FAILURE - SHORTLY AFTER THE 2004 SATURN ION HIT 100K MILES, THE TRANSMISSION FAILED. I HAD TO REPLACE THE TRANSMISSION AT THE DEALER FOR A COST OF $4,620.93. IN DOING RESEARCH IT APPEARS THAT FAILING 2004 SATURN ION TRANSMISSIONS ARE WIDESPREAD AROUND THE 100K MILE MARK. *TR

WENT TO HAVE THE IGNITION RECALL PERFORMED. CAR WAS WITH GM FOR OVER A MONTH. PICKED UP THE CAR. DROVE TO WORK. NEXT DAY DID NOT START. CALLED TO HAVE CAR TOWED BACK TO GM. GM HAD CAR FOR A DAY OR SO. REPLACE THE, IGNITION CYLINDER. HOPEFUL THAT IT IS REPLACED. CONCERN IF THE POWER STEERING HAS AN ISSUE. BEFORE GOING BACK TO WORK AFTER THE CYLINDER WAS REPLACE. TECH, FORGOT TO SET OR REPLACE THE COLUMN. STEERING OUT OF PLACE. I LIFTED THE COLUMN BACK INTO PLACE. UNKNOWINGLY, I DROVE IT FROM THE DEALER WITH IT OUT OF PLACE. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) HOWEVER, THE PART TO PERFORM THE REPAIRS WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 09/02/14*LJ UPDATED 09/17/2014 *JS

COMPLETE POWER STEERING FAILURE AT LOW SPEED. POWER STEERING DID NOT RETURN, AND CAR WAS MANUALLY STEERED DIRECTLY TO THE DEALERSHIP WHEREUPON THE DIAGNOSIS WAS THE POWER STEERING MODULE. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER THE NHTSA CAMPAIGN ID NUMBER: 14E021000 (IGNITION SWITCH). THE CONTACT STATED THE REPAIR DID NOT REMEDY THE FAILURE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

S10 DIRECT REPLY- TO THE SECRETARY FROM CONSTITUENT RE EXPRESSING CONCERNS REGARDING GENERAL MOTORS RECALLS ON 2004 SATURN ION (RECALL NOS. 14063/14113 AND 14115. DATE OF PURCHASE DEC. 27, 2013). *SMD THE CONSUMER STATED ON JANUARY 10, 2014, THE VEHICLE WOULD NOT START. ROADSIDE SERVICE WAS CALLED, AND THEY CHARGED THE BATTERY. AS THE CONSUMER BEGAN BACKING OUT OF HER PARKING SPACE, SHE NOTICED THE VEHICLE SEEMED VERY STIFF; SHE DID NOT IMMEDIATELY NOTICE THE POWER STEERING SIGNAL AND CONTINUED TO MANEUVER THE VEHICLE. SHE DROVE TO THE DEALER, ABOUT A MILE AWAY WITH POWER STEERING. WHEN SHE ARRIVED, SHE MENTIONED THE POWER STEERING ISSUE AND THEY REPLACED THE BATTERY. A FUSE WAS REPLACED, WHICH CORRECTED THE ISSUE, BUT ONLY TEMPORARILY. THE CONSUMER STATED THE POWER STEERING AND IGNITION PROBLEM WERE RESOLVED. HOWEVER, WITHIN THE PAST TWO WEEKS, SHE ENCOUNTERED ANOTHER PROBLEM. THEY KEY BECAME STUCK IN THE IGNITION AND WOULD NOT RELEASE. WHEN THE KEY FINALLY RELEASED, THE VEHICLE WOULD NOT START, EVEN THOUGH THE INTERIOR LIGHTS WERE ON. UPDATED 11/19/14. *JB UPDATED 11/24/14. JB UPDATED 12/04/14*JB

KEY AT TIMES DOES NOT COME OUT OF IGNITION SWITCH. EVEN THOUGH THE SWITCH WAS REPLACED TWICE.THIS HAS BEEN A ON GOING ISSUE AND STILL HAS PROBLEMS TODAY. *JS

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT SMELLED GASOLINE FUEL COMING FROM THE VEHICLE AND NOTICED A FUEL LEAK. THE DEALER STATED THAT THE FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 94,000.

THE COMPUTER - BCM - FAILED AND ALL IT CONTROLS WENT OFF. THIS INCLUDED LIGHTS, DOOR LOCKS, RADIO. *TR

LOST POWER STEERING AFTER POWER STEERING WARNING LIGHT CAME ON. THIS WAS 3RD INCIDENT IN 10 DAYS. TURNED OFF CAR, RESTARTED AND POWER STEERING RETURNED. THIS HAS HAPPENED WITHOUT WARNING 3 TIMES. LOSS OF POWER STEERING MAKES TURNING DIFFICULT. VERY SCARY. *TR