2003 SATURN ION Complaints

TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED WHEN THE KEY WAS PLACED IN THE IGNITION THE THEFT SYSTEM ACTIVATED AND THE ENGINE FAILED TO START. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 03V231000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 142,710.

TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED WHILE TRAVELING 10 MPH, THE POWER STEERING ASSIST SUDDENLY FAILED. THE VEHICLE WAS MOVED TO THE SHOULDER OF THE ROAD WHERE IT WAS SHUT DOWN THEN RESTARTED. THE VEHICLE RESUMED NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

STEERING LOCKS OR BECOMES EXTREMELY HARD TO TURN STEERING WHEEL WHEN CAR IS IN REVERSE FOR PARKING AND THEREAFTER IN DRIVE FOR MINUTES AT A TIME. BECOMING PROGRESSIVELY MORE AND MORE WORSE. HAVE HAD THE STEERING COLUMN SENSOR REPLACED, THE ELECTRIC MOTOR REPLACED AND PROBLEM BECOMES MORE NOTICEABLE. BEGINNING TO EFFECT DRIVING AND THE ABILITY TO MANEUVER THE CAR WHILE IT IS IN MOTION. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

SATURN ION 2 MODEL YEAR 2003 WAS SERVICED FOR 2004 TURN SIGNAL RECALL BACK IN 2005; IN THE PAST 16 MONTHS I HAVE HAD THE DRIVER SIDE TURN SIGNAL BULB CHANGED 4 TIMES BECAUSE IT STOPS WORKING, AND HAVE CHANGED IT 2 MORE TIMES BEFORE THE MOST RECENT SERIES OF INCIDENTS. AS OF TODAY I CHANGED IT A 5TH TIME AND IT STILL DOES NOT WORK. THIS IS A HAZARDOUS CONDITION PARTICULARLY SINCE IT FAILS REPEATEDLY. NOW I HAVE BEEN TOLD THAT THE BODY CONTROL MODULE MIGHT HAVE A PROBLEM MAY NEED TO BE REPLACED. THIS IS AN ISSUE FOR HUNDREDS OF SATURN OWNERS; THE RECALL SHOULD HAVE FIXED THE RE-OCCURENCE OF THE ORIGINAL PROBLEM BUT HAS NOT. *TR

2003 SATURN ION. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEMS AND SEEKS VEHICLE REIMBURSEMENT. *SMD THE CONSUMER STATED WHEN HE BACKED THE VEHICLE OUT OF THE GARAGE, AND PUT THE GEAR IN DRIVE, THE VEHICLE WOULD NOT GO FORWARD. THE CONSUMER BACKED THE VEHICLE BACK IN TO THE GARAGE. THE NEXT DAY HE TRIED IT, AND THE VEHICLE WENT FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO FIND A PROBLEM. FROM SEPTEMBER 2012, UNTIL JANUARY 2013, THE CONSUMER HAD PROBLEMS WITH THE VEHICLE GOING FORWARD. EACH TIME, IT WOULD WORK AGAIN AFTER LETTING THE VEHICLE SIT FOR AWHILE. THEN ON FEBRUARY 23, 2013, THE VEHICLE WOULD NOT GO INTO REVERSE. AFTER LETTING THE VEHICLE SIT FOR ABOUT FOUR HOURS, THE SHIFTING WORKED. AFTER DRIVING THREE BLOCKS, THE VEHICLE STOPPED AND THE SHIFTING WENT OUT AGAIN. THE VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP. THE REPAIR SHOP INFORMED THE CONSUMER THE TRANSMISSION HAD FAILED AND THE PARTS ALONE WOULD COST $3,982.58.

SIGNIFICANT RUST AND STRESS FRACTURES ON FUEL LINE RESULTING IN NOTICEABLE FUEL LEAKAGE WITH THE POTENTIAL OF INCENDIARY INCIDENT IN THE CASE OF COLLISION. AFTER VEHICLE MESSAGE BOARD QUERIES THIS PROBLEM SEEMS TO OCCUR WITH UNUSUAL FREQUENCY IN SATURN IONS SPANNING 2003-2007. PAID OUT OF POCKET TO HAVE THE FUEL LINE REPLACED; WAS TOLD THAT NO RECALL EXISTS FOR THIS PROBLEM SO I WANTED TO REPORT IT. *TR

MY SWITCH WILL NOT TURN BACK TO RELEASE MY KEYS. AT TIMES TRYING TO START THE CAR THE SWITCH WILL NOT TURN, AS WELL. EVENTUALLY IT WILL TURN, FOR NOW. *TR

THE ELECTRIC POWER STEERING WENT OUT LUCKILY IN A PARKING LOT AT A SHOPPING CENTER IN OCTOBER 2012 THE MOTORS WERE REPLACED PREVIOUSLY BEFORE SATURN WENT DEFUNCT BACK IN APPROXIMATELY 2006 AND AT APPROXIMATELY 40,000 MILES. THESE ARE EXACTLY THE SAME MOTORS THAT A RECALL WAS PROPOSED ON THE CHEVY CRUZ AND GM SAYS THEY ARE NOT COVERED OR NO COVERED UNDER THE SATURN PROGRAM. NOW OVER THE PAST 6 MONTHS THE IGNITION SWITCH WHICH GM KNOWS HAS PROBLEMS HAS SHUT THE ENGINE OFF WHILE DRIVING AND NOW IT'S TO THE POINT WHERE IT LOCKS INTERMITTENTLY NOT ALLOWING THE DISENGAGING OF THE ENGINE TRANSMISSION WHEN ATTEMPTING TO TURN OFF AND PARK. AGAIN GM SAYS THERE IS NO RECALL BUT THEY HAVE RECALLS ON OTHER GM VEHICLES. I HAVE SPENT UPWARDS OF $700 DOLLARS FOR REPAIRS AND BATTERIES AND ENOUGH IS ENOUGH. I'VE READ OF THE MANY NIGHTMARE ON THE INTERNET AND WONDER IF YOUR BUREAU CAN DO ANYTHING TO REMEDY THE SITUATIONS. THANKS.

TL* THE CONTACT OWNS A 2003 SATURN ION L3. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT PLACED THE KEY INTO THE IGNITION AND THE ENGINE DID NOT START, BUT THE SERVICE VEHICLE LIGHT ILLUMINATED ON THE INSTRUMENT. THE CONTACT STATED THAT THEY HAD TO WAIT SEVERAL MINUTES TO GET THE VEHICLE TO START. THE CONTACT STATED THAT THE KEY ALSO BECAME STUCK IN THE IGNITION. THE CONTACT SPOKE WITH THE MANUFACTURER IN REGARD TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 42,000 AND THE CURRENT MILEAGE WAS 55,000. UPDATED 4/24/13 *CN THE CONSUMER STATED THE VEHICLE NEEDS A NEW WIRE HARNESS FOR THE ALARM SYSTEM AND A NEW IGNITION LOCK TUMBLER WITH THE DIELECTRIC GREASE IN IT. THIS FAILURE ACROSS MORE OFTEN WHEN COLD. UPON MAKING SHORT ERRANDS, THE VEHICLE MUST BE LEFT RUNNING IN ORDER TO AVOID SITTING FOR 10 MINUTES. UPDATED 06/3/2013 *JS

2003 SATURN ION. CONSUMER WRITES IN REGARDS TO MALFUNCTION OF THE AIR BAG LIGHT AND DOOR LOCKS. *SMD THE CONSUMER STATED ALL OF A SUDDEN THE DOORS UN-LOCKED, THE FLASHER STARTED TO FLASH AND THE AIR LIGHT ILLUMINATED. SHE IMMEDIATELY PULLED INTO A NEARBY GARAGE AND ASKED FOR ASSISTANCE. THE SOLUTION AT THAT TIME WAS TO TURN OFF THE ENGINE AND THEN RE-START IT. THE SECOND INCIDENT OCCURRED ON NOVEMBER 16TH. THE CONSUMER WAS INFORMED THE PART REQUIRED WAS A SENSOR DIAGNOSTIC MODULE, AT A COST OF $ 399.99. HOWEVER, THE PART WAS NO LONGER AVAILABLE. IT WAS RECOMMENDED BY THE MECHANIC, THAT A PART TRY TO BE LOCATED AT A JUNK YARD.