2004 SATURN ION Complaints

APPROACHING CURVE IN ROAD WHEN STEERING WHEEL WOULD NOT TURN TO THE RIGHT. IT FELT COMPLETELY LOCKED, NOT JUST LOSS OF POWER STEERING, TO ME. I WAS ABLE TO STOP ON THE SHOULDER ON THE OTHER SIDE OF THE ROAD (FACING THE WRONG WAY) AND AFTER A FEW MINUTES, THE STEERING WORKED NORMALLY AGAIN. SINCE THAT TIME, IT HAS COME AND GONE A FEW TIMES, SOMETIMES WHEN I START THE CAR, IT FEELS LIKE THE MECHANICAL STEERING LOCK IS STILL ENGAGED, BUT AFTER SHAKING AND WIGGLING FOR A FEW MINUTES, IT USUALLY BEGINS TO WORK. SOMETIMES I CAN TURN ONE WAY, BUT NOT THE OTHER. IT SEEMS TO BE RANDOM WHETHER IT FAILS TO THE LEFT OR RIGHT. THERE IS POSSIBLE CORRELATION TO LOW TEMPERATURES, BUT I DO NOT HAVE ENOUGH DATA TO BE CERTAIN OF THIS YET. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AS THE STEERING WHEEL SEIZED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. AFTER RESTARTING, THE VEHICLE WAS ABLE TO OPERATE NORMALLY. THE CONTACT MENTIONED THAT THE FAILURE WOULD RECUR SPORADICALLY. THE VEHICLE WAS NOT TAKEN TO DEALER FOR A DIAGNOSTIC TEST OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 70,000.

WHEN SLOWING TO PARK MY CAR THE POWER STEERING WENT OUT. I COULD NOT OPERATE THE STEERING WHEEL AT ALL. DRIVING IT WOULD BE UNSAFE. I SHUT OFF THE CAR AND TURNED IT BACK ON. I DID THIS TWICE BEFORE THE STEERING WOULD WORK AGAIN. THIS HAS HAPPENED TWICE NOW, THE DATE LISTED ABOVE AND AGAIN SATURDAY 10-26-2013. I LOOKED UP ON THE INTERNET FOR ANY REPORTED PROBLEMS ON SATURN ION STEERING. I FOUND THAT THERE IS A REPORTED PROBLEM AND NHTSA HAS MOVED THEIR INVESTIGATION TO AN ENGINEERING ANALYSIS AS OF OCTOBER 2011. PLEASE ADVISE IF THERE IS GOING TO BE A RECALL ON THIS PART, OR IF A RECALL HAS ALREADY BEEN ISSUED. IT IS OBVIOUSLY NOT AN ISOLATED PROBLEM. I APPRECIATE ANY HELP AND INFORMATION YOU CAN PROVIDE ME ON THIS. *TR

I WAS DRIVING APPROXIMATELY 10MPH ON A RESIDENTIAL STREET WHEN SUDDENLY MY POWER STEERING LIGHT CAME ON JUST AS I WAS ATTEMPTING A TURN. AT THAT VERY MOMENT THE STEERING WHEEL LOCKED UP AND MADE IT IMPOSSIBLE TO TURN. I THEN PULLED OVER AND TURNED THE CAR OFF. I WAITED FOR ABOUT 5 MINUTES AND THEN RESTARTED THE CAR, IT WAS WORKING AGAIN BUT THEN 10 MINUTES LATER THE LIGHT CAME ON AGAIN. THIS IS BECOMING A HASSLE. I HAVE TWO SMALL CHILDREN AND I AM NOT GOING TO RISK THEIR LIVES FOR SOME FAULTY CAR MOTOR. SO THIS IS TO THE CAR MANUFACTURES, COULD YOU PLEASE FIX THIS PROBLEM BEFORE IT REALLY HURTS SOMEONE. *TR

FIRST INCIDENT OF LOSS OF POWER STEERING OCCURRED IN SNOWY CONDITIONS AT ABOUT 45MPH ON THE HIGHWAY. HEARD CHIME TO ALERT ME TO LOSS OF POWER STEERING. STEERING COLUMN COMPLETELY LOCKED UP, SAFELY MADE IT TO THE SIDE OF THE HIGHWAY AND WHEN I RESTARTED THE VEHICLE POWER STEERING HAD RETURNED AND DASHBOARD ALERT HAS GONE AWAY. NO FURTHER ISSUES WITH POWER STEERING UNTIL 9/15 GOING ABOUT 15 MPH ON AN INCLINE; AGAIN CHIME AND ALERT FOR NO POWER STEERING, STEERING COLUMN LOCKED UP. POWER STEERING REGAINED UPON RESTART. SINCE 9/15 POWER STEERING LOSS OCCURRING AT VARIABLE SPEEDS AND CONDITIONS AND ON A MORE FREQUENT BASIS. TOOK VEHICLE TO TECHNICIAN WHO CHECKED FLUID, FLOAT, ALL CONNECTIONS AND HOSES AND RELAYED THAT A LIKELY CAUSE MIGHT BE A ELECTRIC PUMP OR ELECTRIC PUMP MODULE TO CHECK WITH THE DEALER ABOUT POSSIBLE RECALLS. FULL VEHICLE INSPECTION AND TUNE UP WITH NO SOLUTION. POWER STEERING PROBLEM PERSISTS. ALL COMMUNICATION WITH SATURN HAS BEEN UNHELPFUL, THEY FULLY DENY ANY DEFECTS. SATURN KEEPS TELLING ME THAT NO RECALL FOR MY VIN HAS BEEN ISSUED AND NO ASSISTANCE IS AVAILABLE FROM SATURN FOR THE ISSUES I AM EXPERIENCING. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING FAILED TO OPERATE INTERMITTENTLY AND THE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE MECHANIC STATED THAT THE STEERING COLUMN HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 120,000.

DRIVING ON THE FREEWAY, AT APPROXIMATELY 65 MPH, WHEN A CHIME WENT OFF. STEERING IMMEDIATELY BECAME DIFFICULT AND I NOTICED THAT THE POWER STEERING INDICATOR LIGHT WAS ON. I EXITED THE FREEWAY CAREFULLY AND PULLED OVER, TURNED OFF THE CAR, THEN RESTARTED IT AND THE POWER STEERING CAME BACK ON. SINCE THIS INITIAL INCIDENT THE PROBLEM HAS BECOME MORE FREQUENT. I AM UNABLE TO SAFELY DRIVE THE CAR AND HAVE BEEN TOLD IT WILL COST OVER $1,000.00 TO REPLACE A POWER STEERING MOTOR IN THE STEERING COLUMN. ALSO I HAVE DISCOVERED THIS TO BE A FREQUENT ISSUE FOR THIS MODEL VEHICLE. WITH THE DANGER INVOLVED SHOULDN'T A RECALL BE IN ORDER? *TR

ODOMETER DINGS AND DISPLAYS POWER STEERING WARNING; POWER STEERING FAILS. TURNING THE CAR OFF AND BACK ON CORRECTS THIS, UNTIL IT HAPPENS AGAIN (TYPICALLY AFTER THE CAR HAS BEEN RUNNING ABOUT 10 SECONDS). THIS IS A KNOWN ISSUE, AND SATURN EXTENDED WARRANTY COVERAGE TO UNDER 100,000 MILES. MY CAR DID NOT START DOING THIS UNTIL AFTER 100,000 MILES. STEERING IS A SAFETY ISSUE. THIS SHOULD BE A RECALL. *JS

TL* THE CONTACT OWNS A 2004 SATURN ION II. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED AND THE STEERING WHEEL COULD NOT BE TURNED IN EITHER DIRECTION. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 107,000.

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MOVE. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT HAD HER BROTHER DIAGNOSE THE FAILURE, WHO INFORMED HER THAT THE POWER STEERING MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 126,924.