2003 SATURN ION Complaints

POWER STEERING GOES OUT RANDOMLY WHILE IN MOTION. SOMETIMES IT LASTS 5 MINUTES SOMETIMES UP TO 25-30 MINUTES. GOES OUT EVERYDAY ON MY WAY TO WORK (26 MILE COMMUTE). EXTREMELY DANGEROUS WHEN TRYING TO PARK OR TURN FROM A LIGHT AND I DON'T REALIZE THAT THE ASSIST IS OUT. OBVIOUSLY ON HIGHWAY NOT AS MUCH OF AN ISSUE BUT WHEN DRIVING AT SLOWER SPEEDS IT IS DIFFICULT.

TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE DRIVING 65 MPH, THE STEERING SEIZED AND THE STEERING WHEEL COULD NOT BE TURNED AT ALL. THE CONTACT PULLED THE VEHICLE OVER AND WAITED FOR AWHILE. AFTERWARD, THE STEERING RETURNED TO NORMAL. THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC WAS CONTACTED, BUT COULD NOT REPAIR THE VEHICLE BECAUSE THEY DID NOT HAVE THE EQUIPMENT TO REPAIR ELECTRIC VEHICLES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 152,000.

TAKATA RECALL, MY 2003 SATURN ION HAS RECALLS ON THE IGNITION SWITCH AND CYLINDER WHICH IS CAUSING MY CAR TO BE IMPOSSIBLE TO DRIVE. THIS RECALL IS CAUSING THE SYSTEM TO HAVE A SHORT WITH ALL MY ELECTRICAL. FOR EXAMPLE, WINDOWS DON'T ROLL DOWN/UP, WIPERS DON'T WORK, HEATER DOESN'T WORK, BLINKERS DON'T WORK, DASH LIGHTS STAY ON CAUSING BATTERY TO CONSTANTLY BE DEAD. ALL BECAUSE THERE ARE RECALLS THAT NEED TO BE FIXED.

FUEL LINE ROTTED SO MUCH THAT ONE DAY I START MY CAR AND EVERY DROP OF GAS I HAD POURED OUT ONTO THE GROUND UNDER MY DRIVERS SEAT. IT WAS A FIRE HAZARD AND NOW I AM STUCK WITHOUT A CAR. THE GARAGE WANTS OVER $600 TO REPLACE THE FUEL LINE AND I LITERALLY HAVE NO WAY TO FIX IT. THE VEHICLE WAS ON A CITY STREET.

TAKATA RECALL THE SEAT BELTS WHEN STOPPING SUDDENLY DO NOT ALWAYS LOCK UP. THIS IS VERY DANGEROUS ESPECIALLY WITH KIDS. THE FUEL SYSTEM HAS BEEN PRODUCING A CHECK ENGINE LIGHT AT CERTAIN TIMES OF FUELING UP. AND THE FUEL PUMP WILL KNOCK OCCASIONALLY EVEN AFTER IT'S BEEN CHANGED. THE SUSPENSION IS REALLY BAD AND DANGEROUS, RATTLING NOISE AND SHAKING.

THE IGNITION SWITCH IS NOT WORKING PROPERLY. SOMETIMES, WHEN VEHICLE IS PARKED AND AN ATTEMPT MAKE TO TURN IGNITION TO OFF POSITION, IT WON'T GO. IT SEEMED TO TAKE 10 - 60 SECONDS FOR IT TO RESET AND THEN KEY COULD BE REMOVED. THE LATEST INCIDENT OCCURRED ON 5/12-13/2018. THE VEHICLE WAS PARKED, TRANSMITION IN PARK POSITION, AND AN ATTEMPT MADE TO TURN IGNITION TO THE OFF POSITION. THE KEY COULD NOT BE MOVED. IT DID NOT RESET ITSELF. KEY WAS STUCK IN THE IGNITION, COULD BE TURNED SLIGHTLY TO THE RIGHT, VEHICLE COULD NOT BE RESTARTED. THEN ALL POWER WAS LOST, AS THOUGH THE BATTERY WAS DEAD. THE VEHICLE COULD NOT BE LOCKED OF UNLOCKED WITH THE KEY FOR, HAD TO USE A SECOND KEY TO LOCK AND UNLOCK THE VEHICLE. THIS VEHICLE WAS RECALLED FOR IGNITION SWITCH PROBLEMS IN 2015 AND WAS REPAIRED. THE SAME PROBLEM IS OCCURRING AGAIN. GM TELLS ME THE NEW REPAIR IS NOT GOING TO BE COVERED BY THEM. THE REASON, I'M TOLD, IS BECAUSE THE VEHICLE HAD TO CHECKED INTO THE DEALERSHIP NO LATER THAN 5/17/18. THE VEHICLE WAS TOWED TO THE DEALERSHIP ON THAT DATE. DUE TO SEVERE STORMS IN THE AREA THE TOW TRUCK DRIVER ARRIVED AT THE DEALERS SHIP A FEW MINUTES AFTER THE SERVICE DEPARTMENT CLOSED AND DEPOSITED THE KEY IN THE LOCK BOX. A REP FROM GM WAS SUPPOSED TO HAVE CALLED THE DEALERSHIP ON 5/17/18 BETWEEN 5:45 AND 6:00 TO ALERT THEM THE VEHICLE WAS ON THE WAS AND MIGHT BE A FEW MINUTES LATE AND TO PLEASE ACCEPT THE VEHICLE AND GET IT CHECKED IN. I AM ADVISED BY THE DEALERSHIP THEY RECEIVED NO SUCH CALL. THIS IS GOING TO BE AN EXPENSIVE REPAIR, I DID EVERYTHING THE GM REP ASKED OF ME, I AM 70 YEARS OLD AND HAVE A VERY LIMITED INCOME. I CAN'T BE THE ONLY PERSON THIS HAS HAPPENED TO. PLEASE HELP ME.

FUEL LINE TO THROTTLE BODY LEAKED FUEL DUE TO STRESS CRACKS. PART THAT FAILED IS " NO LONGER AVAILABLE" ACCORDING TO GM PARTS SALES. .MECHANIC WELDED CRACKED PIPE AND SAID EH HAS FIXED QUITE A FEW OF THESE. I HAVE RECEIPT FROM REPAIR SHOP

FUEL LINE LEAK. I OWN A 2003 SATURN ION 3, WITH 120,481 MILES ON IT. THE CAR WAS GARAGE KEPT TILL THE PAST 6 MONTHS. WHEN DRIVING ON 4/15/18, THE CAR SUDDENLY DEVELOPED A STRONG FUEL SMELL. THE VEHICLE WAS BROUGHT INTO THE REPAIR SHOP ON 4/16/18. THE VEHICLE WAS DIAGNOSED WITH A LEAKING, RUSTED FUEL LINE. THE LEAK WAS FROM LINE COMING OUT OF FUEL PUMP. MY RESEARCH SHOWS THIS WAS A KNOWN AND COMMON FOR THE SATURN ION, ALSO SEEMS THAT GM IS AWARE OF THE ISSUE. FUEL LINE/S SHOULD NOT RUST THROUGH LIKE THIS. THIS CAR IS WELL MAINTAINED, INSPECTED REGULARLY AT EVERY 3000 MILE OIL CHANGE INTERVALS. THE VEHICLE WAS MAINTED BY SATURN AS LONG AS THEY WERE IN BUSINESS. THIS IS A SAFETY RELATED DEFECT THAT SHOULD BE INVESTIGATED AND A RECALL CAMPAIGN STARTED AND I SHOULD BE REIMBURSED FOR THE REPAIR.

2003 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH AND POWER STEERING RECALL NOTICES ISSUES. *SMD *CN

CAR JUST RECENTLY POPPED UP POWER STEERING ONLY HAPPENS WHEN ITS SITS OVER NIGHT AND WHEN I START IT UP IN THE MORNING IT'S VERY STIFF TO TURN BUT IF I DRIVE IT LIKE THAT FOR A LITTLE AND SHUT THE CAR OFF THE STEERING IS FINE. THE DASH LIGHTS FLICKER OFF AND ON AND WHEN DOING SO CAUSES HEAT OR A/C TO CUT OUT AFTER DRIVING IT FOR ALITTLE BIT. THE KEY LOCKS IN THE IGNITION SWITCH WHEN I GO TO SHUT OFF THE CAR AND I HAVE TO PRESS THE PLUNGER FOR IT TO RELEASE. KEEPS SAYING COOLANT WHEN GOING DOWN THE ROAD EVEN THOUGH THE COOLANT IS WHERE IT NEEDS TO BE. *TR