2006 SATURN ION Complaints

I HAVE HAD A SLIGHT PROBLEM WITH MY SATURN ION SINCE I HAVE PURCHASED IT FROM MY DEALERSHIP. THE KEY WILL GET STUCK EVERY OTHER TIME I HAVE TRIED TO SHUT IT OFF. IT WAS A MINOR INCONVENIENCE AT THE MOST. BUT YESTERDAY I HAD MY KEY GET STUCK WHILE THE VEHICLE WAS RUNNING! I HAD TO HAVE THE BATTERY DISCONNECTED AND PULL A FUSE JUST TO GET IT TO SHUT OFF. I LOOKED ONLINE FOR HOURS AND HOURS AND FOUND OUT IT IS MOST LIKELY THE IGNITION LOCK CYLINDER. THERE WERE SO MANY COMPLAINTS ON THE SATURN IONS DOING THIS I WAS SHOCKED THAT A RECALL HAS NOT BEEN ISSUED. I AM FRUSTRATED AT THE DEALERSHIP SAYING IT WILL BE $90 JUST TO LOOK AT IT, AND THEN THEY WILL GIVE ME AN ESTIMATE. ONLINE I HAVE SEEN THAT THE AVERAGE COST PAID TO HAVE THIS FIXED IS $300-$500. WHY SHOULD I HAVE TO SPEND MORE OF MY HARD EARNED MONEY IF THIS IS CLEARLY THE MANUFACTURERS FAULT? IF NOTHING IS DONE ABOUT THIS I WILL HAVE LOST ALL FAITH IN PEOPLE. *TR

POWER STEERING REPEATEDLY SHOWS UP ON THE DASH AND THE POWER STEERING DOES SEEM TIGHT AND ITS A LOUD CLUNK WHEN YOU TURN THE WHEEL BACK AND FOURTH SLOWLY. ITS COMMON AND THERE HAS BEEN A RECALL IN SOME STATES A LOT OF PEOPLE GOT THIS PAID FOR AND ITS 1200 TO FIX. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE PARKED, THE CONTACT ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION BUT WAS UNABLE TO BECAUSE THE KEY HAD BECOME STUCK. THE CONTACT STATED THAT IN ORDER TO SHUT OFF THE VEHICLE OFF HE HAD TO DISCONNECT THE BATTERY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE LOCK ASSEMBLY AND THE WIRING HARNESS WOULD HAVE TO BE REPLACED. AFTER THE REPAIR THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. THE CURRENT MILEAGE WAS 121,459. UPDATED 12/11/12*LJ UPDATED 12/1212

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE. THE CONTACT MENTIONED THAT FUEL WAS LEAKING OUT OF THE RESERVOIR LINES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL MODULE AND PLASTIC RESERVOIR NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 77,752. UPDATED 11/27/12 *CN THE CONSUMER STATED THE PROBLEM WAS CRACKED FUEL LINES AT THE FUEL MODULE AND THAT THERE WAS A RECALL BUT, THE RECALL WAS NOT HONORED BECAUSE OF THE STATE THE VEHICLE WAS REGISTERED IN. THE LOCAL DEALER WOULD CHARGE TO LOOK AT THE VEHICLE AND THE COST TO REPAIR THE VEHICLE WOULD BE OVER $1000. THE VEHICLE WAS REPAIRED. UPDATED 12/11/2012 *JS

WHILE I DRIVING MY 2006 SATURN ION THE PASSENGER AIR BAG LIGHT IS ON. I THINK MY 2006 SATURN ION THE WARRANTY WAS EXPIRED. FOR SAFETY DRIVING ON THE FREEWAY I NEED HELP FOR FIX THE AIR BAGS. THANK YOU; *TR

THIS IS THE SECOND TIME THIS HAS HAPPEN. MY KEY IS STUCK IN THE IGNITION AND WONT TURN OFF. I BELIEVE GM SHOULD HELP RESOLVE THIS ONGOING PROBLEM WITH THESE IGNITION SWITCHES. FOR SOME REASON I WAS UNABLE TO PUT THE DATE THAT THIS FIRST HAPPEN, (MAY, 2011) AND NOW AGAIN THIS WEEK. *TR

DAUGHTER DRIVING FOR EXPERIENCE OF A LICENSE. WHILE DRIVING HEARD A SOUND THEN THE PWR STRNG SIGN APPEARED ON THE DASH BOARD. THE STEERING LOCKED UP. WAS VERY DIFFICULT TO TURN. HUSBAND HAD TO TAKE OVER THE DRIVING. WOULD SHUT THE CAR OFF. START IT AGAIN, A MINUTE LATER IT WOULD REOCCUR. NOT SAFE FOR A JUST LEARNING DRIVER OR MY MOTHER (78) IF IT WERE TO HAPPEN WITH EITHER ONE WHILE TURNING. CALLED SATURN, THEY ARE ACCEPTING THE RESPONSIBILITY. REFERRED US TO GM DEALER TO DIAGNOSE. IF DIAGNOSE IS CONFIRMED WITH PRIOR INCIDENTS REPORTED THEY WILL COVER THE NEW PARTS, LABOR AND DIAGNOSTIC TESTS. SATURN GETS CREDIT FOR STEPPING UP. *TR

ON SEPTEMBER 29, 2012, THE NHTSA ISSUED A RECALL NOTICE, ON ITS WEBSITE, FOR BROKEN FUEL LINES TO FUEL PUMPS TO ALL SATURN ION SEDANS FROM 2007 AND NEWER, IN ADDITION TO A LARGER NUMBER OF OTHER GM VEHICLES ALL 2007 AND NEWER. I HAVE A 2006 SATURN ION SEDAN AND THE SAME ISSUE HAPPENED TO MY CAR ON SEPTEMBER 28, 2012, ONE DAY BEFORE I WAS AWARE OF THE RECALL. THE PLASTIC PART CONNECTING THE FUEL LINE TO THE FUEL PUMP CRACKED, SPILLING GAS AROUND THE CAR AND UNDERNEATH. REPAIRS WERE $856 AND LUCKILY I HAD NO FIRE. THE FUEL PUMP MODULE AND CONNECTING FUEL LINES ALL NEEDED TO BE REPLACED.THE RECALL AS NOTED BY THE NHTSA IS LIMITED TO ONLY CERTAIN STATES AND ONLY TO 2007 AND NEWER VEHICLES, BUT THE RECALL NEEDS TO BE EXTENDED TO INCLUDE 2006 SATURN ION MODELS, AND MORE STATES BASED UPON MY SIMILAR ISSUE. THE NHTSA SAID THAT 40,000 GM VEHICLES ARE AFFECTED BUT I THINK THE PROBLEM IS LARGER. I HAVE THE PARTS IF NEEDED. I PURCHASED THE CAR USED FROM A SATURN DEALERSHIP IN PENNSYLVANIA AND I NOW LIVE IN MICHIGAN, NEITHER OF WHICH IS LISTED AS A STATE INVOLVED IN THE RECALL. YOU NEED TO LOOK INTO THIS FURTHER PLEASE, BEFORE SOMEONE DIES BECAUSE OF A FIRE. GM DENIES ANYTHING AT THIS TIME AND INDICATES THEIR RECORDS DO NOT SHOW THE RECALL AS MENTIONED IN THEIR SYSTEM AND MY VEHICLE AND VIN # ARE NOT LISTED UNDER ANY FUEL LEAK RELATED ISSUE OR RECALL. *TR

DRIVING DOWN STREET AND PWR STR MESSAGE CAME ON, POWER STEERING WENT OUT WHILE TURNING!! 1 HOUR LATER, POWER STEERING IS BACK ON AND WORKING FINE! *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE.THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP HAD DEVELOPED A CRACK. ALSO, HE STATED THAT THE FAILURE MIGHT BE RELATED TO NHTSA CAMPAIGN ID NUMBER WAS 09V419000 (FUEL SYSTEM, GASOLINE DELIVERY: FUEL PUMP). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 11/1/12 *CN UPDATED 11/1/2012 *JS