2005 SATURN ION Complaints

WHILE TRAVELING ON HIGHWAY, I STOPPED AND FILLED UP GASOLINE AND I NOTICED A CONTINUING STRONG GAS SMELL IN CAR. THOUGHT I SPILLED GAS ON MYSELF BUT LATER UPON INSPECTION IN MY GARAGE, I FOUND GAS DRIPPING FROM PLASTIC FUEL LINE (UNDER CAR, RIGHT BEHIND DRIVER'S DOOR). DUE TO DANGER, I IMMEDIATELY SET UP APPOINTMENT WITH POLAR CHEVROLET, WHO DECIDED THE FUEL LINE NEEDED REPLACEMENT. COST WAS $623.44

ENGINE FAILED AT 125,000 MILES. ENGINE SPECIALIST DETERMINED CYLINDER #4 OIL STARVATION AS THE CAUSE. OIL CHANGE INTERVALS HAVE ALWAYS BEEN APPROXIMATELY 7500 MILES. ENGINE STALLED OUT AND WOULD NOT CRANK TO RESTART. ENGINE WILL NEED TO BE REPLACED. COST: APPROXIMATELY $4,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING SEIZED AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRIC POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL BECAME HARD TO MANEUVER. THE POWER STEERING AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE, BUT THE FAILURE OCCURRED ONCE MORE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,200.

THIS HAS HAPPENED SEVERAL TIMES IN RECENT MONTHS, BUT HERE IS WHAT HAPPENED THIS MORNING: I WAS ON THE INTERSTATE, GOING ABOUT 60MPH, AND I SPED UP TEMPORARILY TO PASS THE SEMI NEXT TO ME SO THAT I COULD MERGE INTO THE RIGHT LANE AND CATCH THE NEXT EXIT. UPON MERGING, I RELEASED THE GAS PEDAL BUT IT DID NOT COME BACK NATURALLY WITH MY FOOT AND INSTEAD WENT TO THE FLOOR AND MY CAR STARTED ACCELERATING AS I EXITED THE INTERSTATE ONTO A FLYOVER RAMP. I IMMEDIATELY HIT MY BRAKES AND WAS ABLE TO REGAIN CONTROL OF THE SPEED, BUT IT SCARED ME, ESPECIALLY AS THE FLYOVER RAMP REQUIRES A SLOWER SPEED ALONG THE CURVE. TO THE BEST OF MY RECOLLECTION, IN ALL CASES WHERE THIS HAS HAPPENED, I HAVE BEEN GOING AT LEAST 35 MPH WHEN IT HAPPENED, AND MY CRUISE CONTROL WAS ON BUT NOT ACTIVE (IN OTHER WORDS I HAD IT AVAILABLE TO ME BUT IT WAS NOT CURRENTLY SET AT ANY PARTICULAR SPEED). I HAVE SEEN MULTIPLE SIMILAR COMPLAINTS IN FORUMS ONLINE, BUT I AM NOT AWARE OF A RECALL. THIS IS OBVIOUSLY AN EXTREMELY DANGEROUS ISSUE, ESPECIALLY AT HIGH SPEEDS IN DENSE TRAFFIC. PLEASE INVESTIGATE FURTHER -- I CANNOT AFFORD TO HAVE MY MECHANIC REPLACE ALL THE POSSIBLE FAULTY PARTS WITH OTHER POTENTIALLY FAULTY PARTS, AND I WOULD HATE TO BE THE CAUSE OF AN ACCIDENT BECAUSE THE CAR WAS OUT OF MY CONTROL THROUGH NO FAULT OF MINE.

TL* THE CONTACT OWNS 2005 SATURN ION. THE CONTACT STATED THAT THE IGNITION KEY FAILED TO DISENGAGE FROM THE VEHICLE CAUSING THE CONTACT TO HAVE TO RESTART THE VEHICLE SEVERAL TIMES BEFORE IT COULD BE REMOVED. THE CONTACT MENTIONED THAT THE FAILURE CAUSED THE BATTERY TO BECOME INOPERABLE ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 88,256.

TL* THE CONTACT OWNS A 2005 SATURN ION. WHEN THE VEHICLE WAS STARTED, THE POWER STEERING LIGHT ILLUMINATED. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NOTICED LIQUID DRIPPING FROM DRIVER SIDE OF CAR BY REAR WHEEL WHILE CAR WAS PARKED IN MY PARKING STALL. TOOK THE CAR INTO DEALERSHIP. DEALER CONFIRMED FUEL LINES HAD RUSTED OUT. FUEL LINES AND FUEL FILTER WERE REPLACED.

TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE IN PARK, THE CONTACT NOTICED FUEL LEAKING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL LINES WERE LEAKING AND HAD CORRODED. THE MECHANIC STATED THAT THE FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

ABSOLUTELY ABYSMAL CUSTOMER SERVICE EXPERIENCE WITH ORANGE BUICK GMC ORLANDO. I HAD THEM DO TWO RECALLS ON MY '05 SATURN: THE IGNITION SWITCH (WHICH WAS GIVING ME PROBLEMS DUE TO THE PASSLOCK SYSTEM), AND THE ELECTRIC STEERING ASSIST (WHICH I'D HAD _ZERO_ PROBLEMS WITH PRIOR, IT WAS DONE AS A PRECAUTION). AFTER THE STEERING MOTOR WAS REPLACED, I STARTED HAVING INTERMITTENT POWER STEERING CODES ON STARTUP WITH NO ASSIST (TURNING THE CAR OFF THEN ON CLEARS IT). THEY REPLACED THE MOTOR AGAIN. PROBLEM STILL OCCURS. NOW THEY'RE SAYING THE STEERING COLUMN IS SUSPECT, IT'S NOT COVERED UNDER THE RECALL, AND THEY WON'T DO ANYTHING ABOUT IT. HOW FUNNY THAT THE COLUMN WOULD HAVE BEEN TOUCHED BY THEIR TECHS FOR BOTH THE MOTOR AND IGNITION REPLACEMENTS.