2008 SATURN OUTLOOK Complaints

MY DRIVER SIDE HEADLIGHT (LOW BEAM) WAS WORKING INTERMITTENTLY. FINALLY IT STOPPED WORKING. I BOUGHT A NEW BULB AND WAS REPLACING IT THIS WEEKEND. WHILE REMOVING THE OLD BULB, I SAW THAT ONE WIRE HAD PULLED OUT OF THE SOCKET. I LOOKED CLOSER AT THE SOCKET AND REALIZED THAT IT WAS MELTED. THERE WERE ALSO BURN MARKS ON THE BULB PLUG AND A GREEN PLASTIC PIECE. TO MY KNOWLEDGE, THIS IS AN OEM PART. THE PART SAYS PHILLIPS H11 LL AND MADE IN GERMANY. IT ALSO SAYS 55 W, 12 V. THIS WOULD IMPLY ALMOST 5 A OF CURRENT, WHICH SEEMS ALOT FOR THE VERY SMALL WIRING SIZE. WHILE TRYING TO FIND A REPLACEMENT SOCKET, I FOUND OUT THAT THIS SEEMS TO BE A VERY COMMON PROBLEM ON THESE VEHICLES. *TR

THE VEHICLE'S TRANSMISSION FAILED AS I ATTEMPTED TO ACCELERATE. I COASTED TO A STOP AT A RED LIGHT. THE VEHICLE WAS THEN PUSHED, THROUGH A BUSY INTERSECTION, TO A GAS STATION. IT WAS LATER TOWED TO A DEALER FOR REPAIRS. *TR

THE LOW BEAM HEADLIGHT WENT OUT ON THE VEHICLE. I WENT TO AUTOZONE TO PURCHASE THE HEADLIGHT REPLACEMENT WHEN I WAS TOLD THAT IT COULD POSSIBLY BE TWO DIFFERENT HEADLIGHTS THAT I WOULD NEED TO BRING THE BROKEN ONE SO THEY CAN SELL ME A REPLACEMENT. I FOUND OUT THAT IT IS NOT VERY EASY TO REPLACE THE HEADLIGHT ON THIS VEHICLE AS SEVERAL OTHER PARTS HAVE TO BE REMOVED IN ORDER TO GET TO THE HEADLIGHT CONNECTOR. I FOUND INSTRUCTIONS AND SEVERAL COMPLAINTS FROM OWNERS INDICATING THEY HAVE REPLACED THE HEADLIGHT SEVERAL TIMES DURING THE YEAR ONLY TO BE TOLD BY DEALERS THAT THE HARNESS/CONNECTOR ARE BURNED AND THAT IS THE CAUSE OF THE PROBLEM. I PROCEEDED TO REMOVE THE UNDERLINER OF THE TIRE TO GET TO THE HEADLIGHT ON MY VEHICLE. AS SUSPECTED, THE CONNECTOR AND WIRE HARNESS WERE BURNED. I FOUND SEVERAL SERVICE BULLETINS INSTRUCTING DEALERS TO "CHECK AND REPLACE" THE HARNESS AND HEADLIGHT ON THESE VEHICLES. WHEN I CALLED SATURN I WAS INFORMED THAT THE DEALERSHIP HAD REPLACED THE HEADLIGHT IN MY VEHICLE ON APRIL 2011...HOWEVER THEY NEVER INFORMED ME OF THIS CHANGE. RIGHT NOW MY WIFE IS DRIVING THIS VEHICLE WITHOUT A HEADLIGHT AS SATURN IS REFUSING TO REPLACE THE BURNED HARNESS THAT I FOUND ON THE CAR. THIS IS NOT ONLY A SAFETY ISSUE, BUT A FIRE HAZARD ON THE VEHICLE. THIS SHOULD BE A MANDATORY RECALL BY NOW....IT IS NOT JUST HAPPENING ON SATURN OUTLOOKS, IT IS ALSO HAPPENING ON GMC ACADIAS WHICH IS EXACTLY THE SAME CAR..... *TR

WATER LEAK FROM SUNROOF TRAVELED DOWN THE DRIVER'S PILLAR AND THROUGH THE DASH, ONTO THE FLOOR. THIS CAUSED AN ELECTRICAL SHORTAGE WHICH CAUSED THE EMERGENCY BRAKE WARNING BELL TO SOUND. WATER WAS ALSO LEAKING OUT OF THE CURTAIN AIRBAG BADGE ON THE PILLAR POTENTIALLY COMPROMISING THE AIRBAG. WATER SOAKED THE DRIVER'S CARPET AND MATS. NOW THE DASHBOARD INDICATOR LIGHT FOR RPM IS OPERATING SPORADICALLY.

PASSENGER LOW-BEAM HEADLIGHT WENT OUT ON THE 2008 SATURN OUTLOOK AT 48,000 MILES. I REPLACED IT AND THE BULB BLEW OUT AGAIN ONLY TWO WEEKS LATER. I THEN DISCOVERED THE WIRING HARNESS HAD MELTED. REPLACEMENT BULBS CONTINUE TO BLOW BECAUSE OF THE DEFECTIVE WIRING HARNESS. *TR

THE PASSENGER SIDE RUNNING LIGHT WENT OUT. I HAD THE BULB REPLACED. ABOUT A MONTH LATER THE SAME LIGHT WENT OUT AGAIN. I HAD THE LIGHT TAKEN OUT AND WAS TOLD THE WIRING HARNESS WAS MELTED AND HAD CAUSED THE BULB TO GO OUT. SO I NOW HAVE TO REPLACE THE WIRING HARNESS FOR THAT SIDE. I HAVE ALSO BEEN TOLD BY OTHER SATURN OUTLOOK OWNERS THAT IS A COMMON PROBLEM WITH MOST OF THEM. *TR

MY PASSENGER SIDE HEADLIGHT SUDDENLY WENT OUT, ABOUT THE SAME TIME MY HEAT SENSOR BEGAN READING HIGH AS IF VEHICLE WAS OVERHEATING. I TOOK IT TO THE DEALER AND THEY COULD NOT RECREATE PROBLEM WITH OVERHEATING AND THEY REPLACED THE PROJECTOR BEAM. *TR NOW A MONTH LATER IM HAVING THE SAME EXACT PROBLEMS ONLY NOW I NOTICE A COOLANT LEAK. I REPLACED COOLANT AND CAR STILL ACTS LIKE ITS OVERHEATING, ALSO THE HEADLIGHT IS ONCE AGAIN OUT.

THE DRIVERS SIDE HEADLAMP ASSEMBLY OVERHEATED AND MELTED CAUSING THE LIGHT TO FAIL . THIS IS THE SECOND TIME THIS HAPPENED WITH THIS AUTOMOBILE . THE LAST INCIDENT WAS THE PASSENGER SIDE HEADLAMP ASSEMBLY SAME EXACT THING HAPPENED OVERHEATED AND MELTED CAUSING LIGHT TO FAIL. *TR

WE NOTICED THAT WE WERE GETTING WATER IN THE CAR COMING FROM THE REARVIEW MIRROR. WE WERE FINDING WATER DRIPPING THROUGH SUNROOF AND GOING TO THE MUG BOX. WE NOTICED ELECTRICAL PROBLEMS ALSO: THE HEATING/COOLING MOTOR IN THE FRONT OF THE CAR STOPPED TO WORK AND WE HAVE TO CHANGE IT. THE BUTTONS FOR REAR WIPER DOES NOT WORK ANYMORE. THE WATER OVERFLOWS INTO THE CAR AND AFTER A RAINSTORM WE HAD 1.5 INCHES WATER BELOW DRIVER AND PASSENGER SEATS. I KNOW THAT THERE HAS BEEN SEVERAL CUSTOMERS THAT HAD SIMILAR PROBLEMS WITH THE SUNROOF DRAINS. IT IS A POOR DESIGN THAT THE SATURN CORP. *TR

SERVICE AIR BAG INDICATOR MESSAGE KEEPS COMING ON AND THEN GOING OFF WHILE I AM DRIVING CAR. *TR