SATURN Complaints

Rack and pinion is going bad, my mechanic said it's a common issue in these vehicles. When going around a corner it will want to float the opposite way, the steering will eventually get tight my mechanic said until I loose all steering. I am a single mother and have already replaced the whole front end on this vehicle pretty much. I know I've read so many others experiencing the same issues with their Saturn Ion, so I wanted to make it aware that this should be a recall and fixed before someone who knows nothing about vehicles ends up in a severe accident due to this big issue. Also the Key don't want to come out most of the time. An there is an issue with the car not wanting to come out of park sometimes. Not to mention it eats ball joints like crazy every other month I'm replacing the ball joints in this car. If I could afford another vehicle trust me I would but I can't even save for a new car due to all the repairs I've made. It's just frustrating that so many people are having this issue and no mechanic wants to do the rack and pinion job with out charging a fortune.

The contact owns a 2008 Saturn Outlook. The contact stated while driving approximately 65 mph, the steering wheel became difficult to turn. The contact pulled over however, the steering functionality did not return. The contact stated that there was no warning light illuminated. The vehicle was diagnosed and repaired; however, the failure persisted. The manufacturer was not informed of the failure. The failure mileage was approximately 138,000.

The contact owns a 2005 Saturn Ion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel became very difficult to turn in either direction. During the failure, the power steering message was displayed. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer was notified of the failure. The manufacturer was not contacted. The contact stated that the vehicle was previously repaired under the NHTSA campaign number: 14V153000 (Steering) but the failure occurred. The failure mileage was 167,000.

The contact owned a 2006 Saturn Ion. The contact stated while driving at 50 mph and there was a stopped vehicle in the middle of the road, in order to avoid crashing the contact veered to the right lane but crashed into the rear of a truck. The air bags failed to deploy. A police report was not filed. The contact sustained neck, shoulder, arm, and chest injuries that required medical attention. The vehicle was not drivable and was towed to an impound lot. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact was relating the failure to NHTSA campaign number: 14V047000 (Air bags, Electrical system). The manufacturer had been informed of the failure and informed the contact to file for the class action lawsuit. The failure mileage was 90,000.

Multiple time my vehicle became wet in the inside due to a sun roof drainage tube issue. My vehicle stopped while in motion and there was a burning smell. Now none of my windows will go up and the car no longer starts. I have a loud knocking sound coming from the dash when I turn the heater or AC on. Now my dash shows service theft deterrent system. The first time I thought maybe the tube was clogged. I now come to find out that is was/is a on going issue with GM. I could've lost my life or been possibly rear-ended at highway speed due to GM not knowing how to make a sunroof.

The passenger seat airbag sensor has failed for a second time. This issue was the subject of a GM recall 17036 dated May 2017. Under this recall my seat sensor failure was corrected. This car is driven very little (about 2000 miles per year average) and 99 percent of the time with no passenger. Battle Field Chevrolet says the warranty for the recall has expired and gave a written quote R.O. 6030264/1 dated 4/12/21 of $792.88 to repair/correct the failure. I have paper copies of the recall notice and the reference quote. This is a vehicle safety issue. A Passenger would be at risk riding in the seat until repaired. The vehicle cannot pass the annual state safety inspection until corrected. This is a design flaw on the part of General Motors and should again be repaired at no expense to the vehicle owner.

We purchased this vehicle recently. 1 week later we discovered loss of power steering assist while attempting to parallel park. We spoke with the seller (repair shop) and they discovered the Recall Notice 14V153000: Loss of Power Steering Assist. When I attempted to schedule a recall service at a GM dealership it was shown that this vehicle already had this particular recall service performed on the vehicle. 1. Power steering Assist 2. Loss of control of steering. 3. No (issue is intermittent) 4. No (original recall was performed though; it is happening again) 5. No warnings.

HVAC blower motor stopped working via the control knob. Through online forums & repair guides, I did some troubleshooting to determine which component I might need to order (i.e. fuse, relay, blower motor assembly, blower resistor, etc). During that research, many others noted that the blower resistor is known to become defective, and that melting of the resistor & the harness connector are common. This is exactly the situation I found, and it is not at all unreasonable to conclude that this could have easily resulted in a fire. These same parts are shared by the Pontiac Solstice and the Hummer H3 (for which, I believe, a recall was issued). The parts to fix this problem are not overly expensive & readily available -- and the replacement process is not difficult. What IS difficult is to think this is a known problem which can (& has) caused vehicle fires, and yet no recall or official notice has been issued to warn vehicle owners.

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO DEFECTIVE SHIFTER SWITCH SAFETY RECALL. THE CONSUMER STATED THE VEHICLE BECAME DIFFICULT TO TO TURN OFF. THE CONSUMER HAD TO JIGGLE THE KEY TO GET THE VEHICLE TO POWER OFF. THIS OCCURRED ON MULTIPLE OCCASIONS. REPAIR ATTEMPTS HAVE BEEN MADE BUT, THE FAILURE PERSISTED. THE MANUFACTURER WAS CONTACTED AND REIMBURSED THE CONSUMER FOR THE REPAIR.

In 2019 I took my car in for a recall I had received. It was for the PPS. Instead of replacing the faulty system, they simply put a "reinforcement" piece of tape over the faulty system. I rarely drive the car and I rarely have passengers. 2 years and almost 5k miles later, now the faulty system is broken. The sensor in the seat has failed. No surprise there. The dealership is trying to charge me $1400 to replace the faulty sensor that should have been replaced 2 years ago. This is causing anyone who possible is a passenger in my car to be at risk, since now that the sensor is broken, the air bag will not deploy. Other people with this car have had or are having the same issue. I do not understand why a tape fix was approved and implemented for something so serious as the safety of my passengers.