SATURN Complaints

EXTERNAL FUEL TANK LEAKAGE DUE TO BROKEN PLASTIC PART ON FUEL PUMP MODULE. THIS SAFETY HAZARD COMPLAINT IS IDENTICAL TO THE JUST PUBLISHED 9/30/12 RECALL OF 2007-2009 SATURN IONS IN FLORIDA FOR THE EXACT SAME MECHANICAL FAULT - BROKEN PLASTIC PART ON FUEL MODULE CAUSING EXTERNAL FUEL LEAKAGE. GM/CHEVY WILL NOT HONOR RECALL ON MY 2003 SATURN L-300 FOR THE SAME DEFICIENCY AND SAFETY HAZARD. INFACT MY VEHICLE WAS IN THE SHOP FOR THAT REPAIR AT THE SAME TIME A RECALL WAS PUBLISHED FOR THAT PROBLEM. I REQUEST THAT MY VIN BE INCLUDED IN THE RECALL REPAIR. *TR

GAS TANK/NECK PART OUT OF AILGENMENT AND SMELLS LIKE SOMETHING IS BURNING IN CAR. *TR

THIS IS THE SECOND TIME THIS HAS HAPPEN. MY KEY IS STUCK IN THE IGNITION AND WONT TURN OFF. I BELIEVE GM SHOULD HELP RESOLVE THIS ONGOING PROBLEM WITH THESE IGNITION SWITCHES. FOR SOME REASON I WAS UNABLE TO PUT THE DATE THAT THIS FIRST HAPPEN, (MAY, 2011) AND NOW AGAIN THIS WEEK. *TR

PASSENGER LOW-BEAM HEADLIGHT WENT OUT ON THE 2008 SATURN OUTLOOK AT 48,000 MILES. I REPLACED IT AND THE BULB BLEW OUT AGAIN ONLY TWO WEEKS LATER. I THEN DISCOVERED THE WIRING HARNESS HAD MELTED. REPLACEMENT BULBS CONTINUE TO BLOW BECAUSE OF THE DEFECTIVE WIRING HARNESS. *TR

TL* THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT STATED THAT THE BODY CONTROL MODULE SHUT OFF WHICH CAUSED THE GAUGES TO MALFUNCTIONED. THE CONTACT MENTIONED THAT THE VEHICLE TO STALL AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2003 SATURN ION II. THE CONTACT STATED THAT THE KEY WOULD BECOME STUCK IN THE IGNITION SWITCH. THE CONTACT HAD TO CALL A LOCKSMITH TO REMOVE THE KEY FROM THE IGNITION. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER TO HAVE THE IGNITION SWITCH REPLACED. THE FAILURE MILEAGE WAS 83,000.

DAUGHTER DRIVING FOR EXPERIENCE OF A LICENSE. WHILE DRIVING HEARD A SOUND THEN THE PWR STRNG SIGN APPEARED ON THE DASH BOARD. THE STEERING LOCKED UP. WAS VERY DIFFICULT TO TURN. HUSBAND HAD TO TAKE OVER THE DRIVING. WOULD SHUT THE CAR OFF. START IT AGAIN, A MINUTE LATER IT WOULD REOCCUR. NOT SAFE FOR A JUST LEARNING DRIVER OR MY MOTHER (78) IF IT WERE TO HAPPEN WITH EITHER ONE WHILE TURNING. CALLED SATURN, THEY ARE ACCEPTING THE RESPONSIBILITY. REFERRED US TO GM DEALER TO DIAGNOSE. IF DIAGNOSE IS CONFIRMED WITH PRIOR INCIDENTS REPORTED THEY WILL COVER THE NEW PARTS, LABOR AND DIAGNOSTIC TESTS. SATURN GETS CREDIT FOR STEPPING UP. *TR

ON SEPTEMBER 29, 2012, THE NHTSA ISSUED A RECALL NOTICE, ON ITS WEBSITE, FOR BROKEN FUEL LINES TO FUEL PUMPS TO ALL SATURN ION SEDANS FROM 2007 AND NEWER, IN ADDITION TO A LARGER NUMBER OF OTHER GM VEHICLES ALL 2007 AND NEWER. I HAVE A 2006 SATURN ION SEDAN AND THE SAME ISSUE HAPPENED TO MY CAR ON SEPTEMBER 28, 2012, ONE DAY BEFORE I WAS AWARE OF THE RECALL. THE PLASTIC PART CONNECTING THE FUEL LINE TO THE FUEL PUMP CRACKED, SPILLING GAS AROUND THE CAR AND UNDERNEATH. REPAIRS WERE $856 AND LUCKILY I HAD NO FIRE. THE FUEL PUMP MODULE AND CONNECTING FUEL LINES ALL NEEDED TO BE REPLACED.THE RECALL AS NOTED BY THE NHTSA IS LIMITED TO ONLY CERTAIN STATES AND ONLY TO 2007 AND NEWER VEHICLES, BUT THE RECALL NEEDS TO BE EXTENDED TO INCLUDE 2006 SATURN ION MODELS, AND MORE STATES BASED UPON MY SIMILAR ISSUE. THE NHTSA SAID THAT 40,000 GM VEHICLES ARE AFFECTED BUT I THINK THE PROBLEM IS LARGER. I HAVE THE PARTS IF NEEDED. I PURCHASED THE CAR USED FROM A SATURN DEALERSHIP IN PENNSYLVANIA AND I NOW LIVE IN MICHIGAN, NEITHER OF WHICH IS LISTED AS A STATE INVOLVED IN THE RECALL. YOU NEED TO LOOK INTO THIS FURTHER PLEASE, BEFORE SOMEONE DIES BECAUSE OF A FIRE. GM DENIES ANYTHING AT THIS TIME AND INDICATES THEIR RECORDS DO NOT SHOW THE RECALL AS MENTIONED IN THEIR SYSTEM AND MY VEHICLE AND VIN # ARE NOT LISTED UNDER ANY FUEL LEAK RELATED ISSUE OR RECALL. *TR

WHEN I WAS GOING SOUTH ON I-95 IN GEORGIA I HEARD A WARNING TONE FROM MY SATURN AND SAW A WARNING ON MY DASH THAT WAS FOR THE POWER STEERING. IMMEDIATELY I COULD TELL I HAD LOST MY POWER STEERING BECAUSE CHANGING LANES FELT SLUGGISH AND A BIT DIFFICULT. (NOT PHYSICALLY DIFFICULT BUT MORE DIFFICULT THAN USUAL) THE LIGHT STAYS ON AND I HAVE NO POWER STEERING UNTIL I SHUT OFF THE CAR AND RESTART IT. THEN IT IS LIKE NOTHING HAS HAPPENED. AT SLOWER SPEEDS THIS COULD CAUSE AN ACCIDENT DUE TO THE AMOUNT OF FORCE THAT IS REQUIRED TO TURN. THE BIGGEST PROBLEM IS NOT FOR ME BUT FOR MY WIFE WHO CANNOT PHYSICALLY CONTROL THE CAR WHEN THIS HAPPENS. THIS IS DEFINITELY A DANGEROUS PROBLEM THAT NEEDS TO BE TAKEN CARE OF. *TR

WHEN ATTEMPTING TO PLACE MY VEHICLE IN PARK IT DIDN'T RECOGNIZED THE GEAR. THE VEHICLE WOULD ROLL OUT OF GEAR AT TIME. OTHER TIMES IT WAS DIFFICULT SELECTING OTHER GEARS. FINALLY THE CAR WOULD NOT START BECAUSE IT RECOGNIZED THE CAR IN DRIVE INSTEAD IN PARK. THEREFORE I WAS UNABLE TO RESTART VEHICLE. *TR UPDATED 1/30/13 *CN ACCORDING TO THE INVOICE, THE SHIFTER CABLE WAS BROKEN. THEY REPLACED THE SHIFTER CABLE AND REPAIRED A LEAK AT THE HEATER HOSE. UPDATED 01/31/13