SATURN Complaints

METAL FATIGUE ON PASSENGER CAR DOOR OF SATURN ION QUAD COUPE REDLINE, WHERE HINGE ATTACHES: THE PROBLEM OCCURRED OVER A PERIOD OF 2 YEARS DURING WHICH TIME I WOULD OPEN AND CLOSE THE DOOR EACH DAY A MINIMUM OF 10-12 TIMES TO STRAP MY INFANT INTO HIS CARSEAT. THE DOOR METAL CRACKED AND BEGAN TO SEPARATE FROM THE REST OF THE METAL, TO THE POINT WHERE THE DOOR IS READ TO DROP OFF THE HINGE. I BROUGHT THE VEHICLE TO A GM DEALER IN RESPONSE TO A RECALL ON THE CATALYTIC CONVERTER, AT WHICH TIME I REQUESTED THEM TO LOOK AT THE DOOR. THE DEALERSHIP HAD NEVER SEEN ANYTHING LIKE IT. HOWEVER, THEY CONCLUDED THAT IT WAS NOT THEIR RESPONSIBILITY SINCE THEY WERE UNABLE TO DISPROVE THE DOOR HAD NOT BEEN FORCEFULLY PUSHED BACKWARDS. *TR

TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED THAT THE VEHICLE HORN ENGAGED WITHOUT DRIVER INTENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS INFORMED THAT THE HORN MODULE HAD FAILED AND BURNED A HOLE THROUGH THE SAFETY AIR BAG. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 48,000. UPDATED 06/25/10. *LJ UPDATED 09/07/10*JB

MY SATURN ION IS HAVING THE SAME ISSUE AS CHEVY COBALT WHERE I LOOSE POWER STEERING FOR NO APPARENT REASON. ONCE IT CUTS OUT I HAVE TO PULL TO THE SIDE OF ROAD TURN OFF CAR, THEN RESTART IT AND ALL IS FINE UNTIL IT DOES IT AGAIN. THIS HAS BEEN HAPPENING FOR A COUPLE MONTHS. I HAD THE CAR CHECKED TODAY AND IT IS THE POWER STEERING MOTOR, WHICH WILL BE REPLACED AS SOON AS PART COMES IN. I FEEL GM SHOULD RECALL THESE CARS TOO. THIS COULD BE A REAL DANGER IF ON A CURVING MOUNTAIN ROAD WHEN POWER STEERING GOES. *TR

TL*THE CONTACT OWNS A 2004 SATURN ION. WHILE DRIVING AT ANY SPEED, THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. HE THEN CALLED THE MANUFACTURER WHO REFERRED HIM TO THE DEALERSHIP. THE CURRENT MILEAGE WAS 19,201. THE FAILURE MILEAGE WAS UNKNOWN.

I OWN A 2004 SATURN ION, THAT ON RANDOM OCCASIONS DOES NOT START. WAIT A FEW MINUTES AND THEN IT DOES. THIS HAS HAPPENED TO US IN BOTH WARM AND COLD DAYS. IT'S BEEN IN FOR SERVICE SEVERAL TIMES AND SERVICE TECH'S CAN'T SEEM TO LOCATE THE PROBLEM. WHEN THIS FIRST STARTED, WITH ONLY ABOUT 10 000 KL, THE CAR DID NOTHING, NO LIGHTS, RADIO ETC., COMPLETELY DEAD. *TR

THE POWER STEERING SIGNAL SHOW ON DASH DISPLAY AND POWER STEERING GOES OUT. WHEN THE CAR IS TURN OFF AND AFTER FEW MINUTES IS TURN BACK ON, POWER STEERING WORK FINE AGAIN FOR SOME TIME. FUSES ARE OK. THIS HAPPEN WHILE YOU ARE DRIVING AND IS VERY HARD TO GET KEEP OF THE CAR. THIS HAD HAPPENED SEVERAL TIMES DURING THE LAST YEAR. *TR

TL*THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING FAILED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT DROVE THE VEHICLE HOME, TURNED IT OFF AND RESTARTED IT; THE POWER STEERING SEEMED TO RESET AND FUNCTION PROPERLY. THE DEALER STATED THAT THERE WERE NO RECALLS OR WARRANTIES THAT WOULD COVER THE FAILURE; HOWEVER, THEY OFFERED TO PERFORM A DIAGNOSTIC TEST FOR A FEE. THE CONTACT HAD NOT SPOKEN WITH THE MANUFACTURER WHEN THE COMPLAINT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 102,000.

TL*THE CONTACT OWNS A 2007 SATURN ION. THE CONTACT STATED THAT THE POWER STEERING FAILED INTERMITTENTLY AND THE POWER STEERING LIGHT ILLUMINATED WHEN THIS FAILURE OCCURRED. THE VEHICLE WOULD BECOME DIFFICULT TO STEER WHEN THE POWER STEERING MALFUNCTIONED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 60,000.

TL*THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A U-TURN, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. THE CONTACT WAS ABLE TO DRIVE HOME ALTHOUGH IT BECAME DIFFICULT TO CONTROL THE STEERING WHEEL. THE POWER STEERING RESET ITSELF AFTER IT WAS TURNED OFF AND RESTARTED. THE CONTACT CALLED THE DEALER WHO STATED THAT THERE WERE NO RELATED RECALLS AND SHE WOULD HAVE TO PAY THE REPAIR COST. THE MANUFACTURER, WHEN CALLED, VERIFIED THE INFORMATION GIVEN BY THE DEALER. THE FAILURE MILEAGE WAS 44,537. THE CURRENT MILEAGE WAS 44,847. UPDATED 07/08/10 *BF THE CONSUMER SENT IN A TSB REGARDING A PROBLEM WITH THE ELECTRIC POWER STEERING. UPDATED 07/09/10/*JB UPDATED 07/15/10 *BF THE CONSUMER STATED GM/SATURN HAS AGREED TO ASSIST WITH THE STEERING PROBLEM. UPDATED 07/19/10*JB

TL*THE CONTACT OWNS A 2002 SATURN L200. THE CONTACT ATTEMPTED TO START THE VEHICLE AND WAS UNABLE TO DO SO. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED THE IGNITION CYLINDER ACCORDING TO RECALL 03V231000 (ELECTRICAL SYSTEM:IGNITION:MODULE). THE BRAKE LIGHTS WERE INOPERABLE AND THE TIMING CHAIN FAILED WITHOUT WARNING ON A SEPARATE OCCASION. THE DEALER REPAIRED THE TIMING CHAIN AND THE CONTACT PAID HALF OF THE REPAIR COST. MOST RECENTLY, THE POWERTRAIN CONTROL MODULE AND BODY CONTROL MODULE SUDDENLY FAILED. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.