2005 SUBARU BAJA Complaints

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 SUBARU BAJA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V359000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOLS CONFIRMS PARTS NOT AVAILABLE.

RECEIVED A LETTER 8-1-16 PASSENGER SIDE AIR BAG STATING THAT PARTS ARE UNAVAILABLE AND NOT TO LET ANYONEDRIVE IN THE FRONT PASSENGER SIDE. MFG CAN NOT GIVE A DATE. WILL THIS HAVE NO END? THEY JUST NOTIFIED ME NOW AND NOTHING CAN BE RESOLVED?

I RECENTLY HAD ISSUES WITH THE SUSPENSION WHILE THE CAR WAS IN MOTION, SO TOOK THE VEHICLE TO MY MECHANIC. I WAS INFORMED THAT THE REAR SUB FRAME AND UPPER CONTROL ARM MOUNTING EARS HAVE ROTTED OUT.

IT IS A COMMONLY KNOWN PROBLEM WITH SUBARUS OF THIS ERA THAT THE HIGH PRESSURE RUBBER FUEL LINES UNDERNEATH THE INTAKE MANIFOLD WILL BEGIN TO LOSE THEIR ELASTICITY AS THEY AGE AND LEAK PROFUSELY WHEN THE TEMPERATURE DROPS BELOW 30 DEGREES FAHRENHEIT. MECHANICS KNOW THIS AND IT IS DISCUSSED EXTENSIVELY ON THE SUBARU FORUMS. THIS HAPPENED TO MY 2005 SUBARU BAJA WHEN I WAS TRAVELING IN THE MOUNTAINS. WHEN I STARTED THE VEHICLE IN THE MORNING, FUEL WOULD BEGIN PUDDLING ON THE TOP OF THE ENGINE. IT WAS VERY NOTICEABLE DUE TO THE FUEL VAPORS PRODUCED. AS THE ENGINE WARMED THE RUBBER WOULD SWELL AND STOP THE LEAK AFTER A GOOD 30 MINUTES OR LONGER DEPENDING ON THE OUTSIDE TEMPERATURE. I HAD TO TRAVEL WITH A FIRE EXTINGUISHER AT THE READY AND COULD NOT KEEP ANY VENTS OPEN IN THE CABIN. IT WAS EXTREMELY DANGEROUS AND COULD NOT BE REMEDIED UNTIL I WAS BACK FROM MY TRIP. SUBARU ISSUED A RECALL A FEW YEARS AGO FOR A SMALL PART NEAR THE FUEL PUMP AND TANK BECAUSE IT HAD THE POTENTIAL TO LEAK, BUT THEY HAVEN'T ADDRESSED THIS FAR MORE PERVASIVE ISSUE AT ALL. THE REMEDY REQUIRES A DIFFICULT AND COSTLY REMOVAL OF THE INTAKE MANIFOLD AND THE REPLACEMENT OF ALL THE RUBBER LINES THAT RUN BETWEEN THE HARD PIPES ON THE HIGH PRESSURE FUEL CIRCUIT. I SUSPECT THIS IS WHY THEY ARE NOT ISSUING A RECALL. IT IS A VERY REAL PROBLEM AND NEEDS TO BE ADDRESSED IMMEDIATELY.

TL* THE CONTACT OWNS A 2005 SUBARU BAJA. AFTER STARTING THE VEHICLE, A STRONG FUEL ODOR ENTERED THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09277000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

STRONG GASOLINE SMELL IN PASSENGER COMPARTMENT, DEALER CAN NOT LOCATE PROBLEM,PROBLEM PERSISTS. AFRAID CAR WILL CATCH ON FIRE

MY VEHICLE HAS HAD SEVERAL DEFECTS/PROBLEMS. THE ENGINE VALVE LEAKED, CHECK ENGINE LIGHTS, AUTO TRANSMISSION PROBLEMS SINCE FIRST PURCHASED INHERENT TO VEHICLE. VEHICLE BURNS ENGINE OIL AND TOO HOT.. I AM AFRAID TO DRIVE CAR LONG DISTANCES I CURRENTLY HAVE 113,000 MILES ON AUTO.

MY CAR BEGAN OVERHEATING, SO I HAD MY NEPHEW (A MECHANIC) REPLACE THE THERMOSTAT - TWICE. MY NEXT STEP WAS TO TAKE IT INTO THE DEALER, AND HAVE THEM CHECK IT OVER. THEY TOLD ME I NEEDED A NEW WATER PUMP, AND HAD DROPLETS AROUND MY HEAD GASKET, BUT IT WAS NOTHING TO WORRY ABOUT (THAT WAS AT 98,000 MILES). I EXPLAINED THAT I WAS TAKING MY 91 YEAR OLD MOM, AND 17 YEAR OLD DOG TO L.A. FROM SACRAMENTO, AND WANTED TO MAKE SURE IT WAS SAFE. THEY SENT ME ON MY WAY WITH THE ASSURANCE THE CAR WOULD BE FINE. I OVERHEATED GOING OVER THE GRAPEVINE. SUBSEQUENTLY, I'VE HAD THE WATER PUMP, RADIATOR, TIMING BELT REPLACED, AND IT'S STILL OVERHEATING. IN THE LAST MONTH OR SO, IT STARTED LEAKING SO I LOOKED UP ONLINE ANY COMPLAINTS AND FOUND MULTIPLE COMPLAINTS REGARDING HEAD-GASKETS, AND THAT SUBARU HAD EXTENDED THE WARRANTY TO 100,000 MILES OR 8 YEARS. TOO BAD FOR ME, HUH? WHEN I TOOK IT BACK INTO THE DEALER (AT 104,000 MILES) THEY TOLD ME THE EXTENSION DIDN'T APPLY TO MY CAR. NOT ONLY DO I RESENT THE FACT THAT I FEEL RIPPED OFF, I RESENT THEM SENDING ME OUT THE DOOR WHEN IT WASN'T SAFE TO BE STUCK ON THE FREEWAY WITH AN ELDERLY PARENT, AND ELDERLY DOG.

IT'S BEEN COLD IN MA LIKE PAST WINTERS AND THIS IS THE FIRST TIME THIS HAPPENED SINCE OWNING MY BAJA FOR 10 YEARS NOW, WHICH I BOUGHT NEW. I NOTICED THAT WHEN I FIRST START UP MY CAR WITH THE HEAT VENTS OPEN TO WARM IT INSIDE, THE CAR FILLS WITH STRONG FUEL/GAS FUMES. I TOOK MY CAR TO BE SERVICED AT A SUBARU DEALER AND THEY CHECKED ALL THE FUEL LINES; TIGHTENED THEM, BUT COULD NOT FIND WHAT IS CAUSING THIS PROBLEM. SO NOW I RECIRCULATE THE CABIN AIR AND DON'T DRAW IN FRESH AIR TO TRY TO KEEP THE FUMES OUT. IT STILL CONTINUES TO EMIT FUMES WHEN IT'S COLD OUT, BUT IT NEVER HAPPENED IN THE PAST...10 YEARS OF COLD WINTERS AND NOW THERE'S A PROBLEM WITH GAS FUMES? SOMETHING IS VERY WRONG AND I DO FEAR A FIRE. *TR

DURING THE AFTERNOON OF THE DECEMBER 21ST ICE STORM IN BOZEMAN MONTANA, MY 2005 SUBARU BAJA SLID OFF THE ROAD AND DOWN A STEEP INCLINE. ALTHOUGH I ONLY SUSTAINED BUMPS AND BRUISES, THE CAR WAS TOTALED. THE ACCIDENT COULD HAVE EASILY BEEN FATAL. THE WINDSHIELD WAS HEAVILY DAMAGED, THE CAR AXLES WERE BROKEN, THERE WAS SEVERE DAMAGE TO THREE SIDES OF THE VEHICLE. I WONDERED WHY THE AIRBAGS HAD NOT DEPLOYED. WHEN I RESEARCHED THE SITUATION I FOUND THERE WAS A RECALL ON 2005 SUBARU AIRBAGS. SUPPOSEDLY A FAULTY RELEASE SWITCH AND POTENTIALLY A RELEASE OF METAL SHARDS UPON DEPLOYMENT. MAYBE I WAS LUCKY THE AIRBAGS DIDN'T GO OFF. I CONTACTED SUBARU TO SEE IF IN LIGHT OF THIS SITUATION, THEY WOULD POTENTIALLY CONSIDER ASSISTING ME WITH A REPLACEMENT VEHICLE. AFTER A 2 WEEK DELAY, ROB THE CSR TOLD ME THAT PER PAGE XXX OF THE OWNER?S MANUAL THE AIRBAG WOULD NOT DEPLOY UNLESS THE VEHICLE WAS HIT FROM THE FRONT OR BACK. ALSO, ALTHOUGH I READ THAT MY CAR WAS INCLUDED IN THE RECALL, HE SAID IT WAS NOT. APPARENTLY, THE COMPANY FEEL NO OBLIGATION WHAT SO EVER TO ASSIST WITH THE SITUATION. POSSIBLY THEY WOULD HAVE PAID MORE ATTENTION IF I WAS INJURED OR DEAD. I AM NOW AN EX-SUBARU CUSTOMER. I WILL BE SEEKING AN ATTORNEY TO SEE IF OTHERS HAVE HAD SIMILAR EXPERIENCES. *TR