2016 SUBARU OUTBACK Complaints

For the past 6 months out key has become very hard to remove. The ignition system will not disengage and release the key. Multiple methods have been tried and sometimes are effective. Placing the car into park, then neutral, back to park and so on eventually releases the key. The service center said to play with the breaks and shifters to fix the issues. I’ve been reading of multiple problems that keep occurring with these cars.

Unable to remove key from ignition when car is parked. I am unable to leave car without threat of it being stolen. An internet search indicates this is a common problem and repair cost can be several hundred dollars

Battery has died several times over the past few months. The last time (7/3/21) within 48 hours of being fully charged. Subaru replaced the battery several months ago, so it’s a fresh battery. They did not mention the electrical system problems they know about and have known about since 2017.

Over the last 7-8 months. Has gotten progressively worse. With car parked and turned off cannot get key out of ignition. Have to sometimes restart car and move it forward and backward and that doesn’t always release key after turning off. Or move shift lever from park to drive many times and that doesn’t always work. Or turn ignition key back and forth and pushing in on it . Does it on both level parking and inclined parking Has taken as long as 15 minutes to be able to get key out and leave my car. Called three dealerships . One said yes he’s heard of it happening , other to 2 other Subaru dealerships said they have to diagnose the problem . I found 3 technical service bulletins on Nhtsa web site referring to identical problem . It was called “shift lever complete “ for 2016 Subaru Outback and Legacy.Service bulletin# 16-112-18R

The ignition sensor is faulty and doesn't consistently recognize when the car is in park, and as a result, will not release the key from the ignition. After some research, many other Subaru owners have experienced this same issue.

On 8/30/2018, the car wouldn’t start after it was driven to a parking lot. The battery was jumped, car taken home, and then the battery was charged at local car parts store. On 6/7/2021, the car wouldn’t start after two days of no use. The battery was jumped and driven for 30 min. On 6/12/2021, the battery was replaced, and driven intermittently 6/12 and 6/13. On 6/16/2021, the car wouldn’t start with no panel or indicator lights working at all.

The contact owns a 2016 Subaru Outback. The contact stated that the battery had failed on several occasions after starting the vehicle. The contact stated that the battery warning light intermittently flashed during the failure. The contact had taken the vehicle to three separate independent mechanics and had the battery replaced however, the failure persisted after each battery replacement. The contact then took the vehicle to a dealer where the technician discovered that the radio was causing an electrical drain on the battery which could render the battery defective. The battery was replaced for a fourth time and the radio was disconnected however, two weeks after the repair, the battery failed again and the vehicle was returned to the dealer where it remained in their possession. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 68,000.

For the past four years the car has insufficiently charged the battery. On two occasions the car would not start and had to be jumped. At first I attributed it to something I may have done like leaving an interior light on, but after the second incident I found out that other owners of the same car were having similar problems. I called the dealer and they said it might help to install a higher CCA rated battery.I replaced the original battery in 2018 with a higher rated Interstate CCA battery. That battery was also over time not being charged sufficiently and I took it back to the Firestone dealer who installed another Interstate Brand battery replacing it in 2020 under warranty. I called the dealership again and they said there was no reported issues with Subaru Outbacks insufficiently charging and that I just had to drive the car more frequently. So far the car has failed to start on 5 occasions, stranding either myself or my wife, twice in unsafe situations. I now routinely have to charge the battery in my garage about once a month to keep it operational, even after driving the car frequently. On 5/3/2021 I took the car back to the dealer for some service work. I asked again if there was any fix for the charging issue. They tested the battery and recorded that it "came up as deeply discharged". They said there was "No abnormal draw found ---vehicle charging normally."

The issue I am reporting is an issue with the electrical system that is causing battery to drain to dear overnight. This past Sunday I experienced a completely dead battery without any warning lamps or messages and no prior symptoms to indicate battery was not charging. After replacing the battery the next day, the car started with no problem. However, the next morning that brand new battery was dead. After jump-starting and allowing to run for a period of time to recharge the battery, I turn the car off and restarted several times. Once again, the next morning the battery was completely dead. Upon replacement of the newest battery, I checked the vehicle to ensure that nothing was left on that would cause the battery to drain overnight. There appears to be some type of "parasitic drain" within the electrical system that is causing this rapid battery drain. Luckily, this did not take place while my family and I were traveling which would have potentially placed us in a position which would have put our safety at risk. After researching information regarding this on the internet, it appears to be a known problem with my year and model vehicle.

Lately when i put the car in park I can not remove the key. I need to either play around with the shift lever or usually start the car, back up, and forward and try again until I get the key out. Not a good solution. I have been reading about the problem of the defective shift selector and the associated service bulletin # 16-112-18R. I would like to get this fixed rather than using the on-line suggestions of jumpering the switch which seems like a possible safety problem. Because this is happening due to a defective shift selector I think Subaru should be picking up the cost to make this right. The car has only 45,000 miles on it. I have contacted Subaru but ahve not heard back from them yet. The dealer cost to repair this is approximately $600