2020 SUBARU OUTBACK Complaints

Windshield: Mid December noticed crack along right lateral side of windshield when car parked in garage. No preceding incident noted. Garage temp 40 degrees. Had windshield replaced with original Subaru replacement windshield at Safelite on 12/31/21. On 1/20/22, while driving 60 mph on highway, 33 degrees, snowing, wipers and defroster on, heard noise like a rock hitting windshield, and noticed a crack from the bottom/ middle of the windshield. There were no cars within 300 feet of my car so I doubt a rock was kicked up to hit my windshield. I believe windshield is defective. Will have it replaced again. Although this repair is covered by my insurance, repeat claims like this will cause insurance rates to go up for all consumers.

The windshield on my 2020 Subaru Outback spontaneously cracked while I was driving the vehicle on a cold morning (01/20/2021). This crack is the second such spontaneous crack that has occurred with this same vehicle. The first crack occurred in the original windshield in June 2021, after which the original windshield was replaced with an OEM windshield. This second cracking event occurred with the OEM replacement windshield. About 30 minutes into driving the vehicle at freeway speeds (65 mph), a crack with a total length of about 10 inches (5 inches vertical, 5 inches horizontal) formed spontaneously mid-length on the windshield beginning from the bottom edge of the glass. The formation of the crack occurred quickly and was associated with a loud snapping sound. The path of the crack traveled through the location of a small (2mm x 2mm) chip in the glass located approximately 2 inches from the bottom edge of the glass. This chip in the glass occurred at least 2 months prior to the cracking event and was the result of an impact from a small rock (about 1cm x 1cm). No additional damage or impact force had occurred on the chipped location between the creation of the chip and the cracking event. If the crack had been larger and the associated snapping sound louder, the startling nature of the event and loud volume of the snapping sound would likely put someone driving the vehicle at risk of reacting in a hazardous fashion and result in a crash. Furthermore, since the Subaru Outback's forward collision warning, automatic emergency braking, adaptive cruise control, lane departure warning, and lane keeping assistance all operate through a camera-based system that requires a clear view through the windshield, the crack posed a risk of impacting these systems.

The windshield on my 2020 Subaru Outback spontaneously cracked shortly after I started the car on a hot summer day (06/28/2021). Roughly a minute after starting the vehicle and turning on the air conditioning, I drove a distance of about 100 ft and heard a really loud snap, but initially didn't see the cause of the sound. About 2 seconds later, a crack quickly spread horizontally from the driver's side edge at mid height of the windshield until reaching the center of the windshield. After continuing to drive the vehicle, the crack began to spread vertically for about 6 inches, and then spread further horizontally to the right by another 6 inches, forming an S-shape. No damage or chips were known to have been previously inflicted on the windshield and the glass was visibly intact prior the cracking event. Because the crack was positioned almost exactly at eye level, visibility was noticeably distorted. If the crack and associated snapping sound had occurred while the car was being driven in actual traffic on a road or freeway, the startling nature of the event and loud volume of the snapping sound would likely put someone driving the vehicle at risk of reacting in a hazardous fashion and result in a crash. Furthermore, since the Subaru Outback's forward collision warning, automatic emergency braking, adaptive cruise control, lane departure warning, and lane keeping assistance all operate through a camera-based system that requires a clear view through the windshield, the crack posed a risk of malfunction of these systems. The windshield was inspected by a professional automotive glass installation shop and was determined to have been damaged beyond repair, requiring total replacement.

Battery draining and constant jump starting. If the car is not driven for a few days the battery is drained out. This has happened on more then one occasion. The vehicle has only 11,339 miles on it. Take it to the dealer and they claim dome lights were left on. Well a fully charged battery leaving a led dome light on won't drain the battery beyond starting. Of course they do a battery test and nothing is wrong. Well, after you drive it of course it will test good. This issue needs to be looked at or at least addressed in some form

We bought a 2020 Outback used with 12k miles from local Honda dealership July 2021. At 18k miles we took it in for service and were told there was gross misalignment and all the tires were worn down and needed to be replaced. The Subaru dealership made it sound as though this is a recurring issue with the 2020 Outbacks - the alignment is going off early and the tires are wearing down very fast. This is the car our nanny uses to transport our kids - we are concerned that there could be other families out there that don't realize how quickly their alignment and tires are going downhill and could result in safety issues.

The battery on the vehicle began dying repeatedly. At first, the service provider said there was nothing wrong, however the vehicle died again the next day after inspection. Subaru replaced the battery after I brought it in a second time and the vehicle died again the next day. I brought it in a third time, and It turned out that there was a problem in the electrical system that was draining the battery. Subaru has since fixed the issue but I had heard that lots of other Subaru Outbacks were having the same problem so I wanted to report this.

The car fails to start in cold conditions (~20 degrees F). This behavior started less than 18 months after taking possession of the vehicle and ~6000 miles.

Purchased my outback in January of 2020, Sometime in that same month I noticed a small crack in the windshield, down at the bottom on the passenger side. No idea how it cracked. by the next day the crack had grown to over 8 inches. I called subaru dealership and they stated that wasnt covered under warrantee and that they didnt deal with insurance companies directly so I would have to get it fixed by them, pay up front and get my insurance company to reimburse me directly. Called my insurance company and they said to just go to safelight. I explained it was a brand new car and I wanted original factory glass and they said ok. work was done, safety eyesight recalibrated and car was brand new again. Fast forward to today (jan 5 2022), about exactly 2 years from the first time. Driving down the road, heard a pop, didnt see a rock or debris hit me, look at the windshield and see a small crack in the uper driverside windshield. Knowing how fast the last crack grew I immediately headed to safelight. By the time I arrived there, the small crack (about 1/4 inch) had grown to over 12".

The contact owns a 2020 Subaru Outback. The contact stated that after parking the vehicle, the next morning it was discovered that the front windshield had cracked on the passenger’s side. The contact indicated that no object had struck the vehicle to cause the failure to occur. The manufacturer was notified of the failure. The local dealer was not yet notified of the failure. The failure mileage was 15,000. It was determined by the dealer that something very small caused an extremely tiny impact not an internal issue.

Battery issue: 2020 Subaru Outback When I purchased the vehicle in April 2020 I drove it for 3 Months then the battery died. The Dealer told me it was a faulty battery and then replaced it. (Battery #2) For the last year and a half I've been experiencing Problems starting/Navigation & Display Screen not working correctly. Three days ago guess what happened? My Battery died again....Called the Dealer and they told me to bring it right down and they'll look at it. They charged the battery and said you're good to go! I told them that is not the answer because as soon as I leave the battery is going to die again! They looked at me and said OK we'll put it on the big diagnostic machine and sure enough it came back with a need a new battery report! So they replaced it! (Battery #3). On the way home from the dealership I turned to my wife and said this car is not safe. It's like driving a moving time bomb. You'll never know when it's going to die again. That's when I decided to look it up and there it was "Subaru Battery law suit". Could you please help me? [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).