2020 SUBARU OUTBACK Complaints

The contact owns a 2020 Subaru Outback. The contact stated that while seated in the vehicle in the driveway of the residence, the front windshield cracked without impact. The vehicle was taken to the dealer; however, the contact was informed that the failure was not caused by a manufacturing defect. The windshield was replaced. The contact stated that the windshield had been replaced three times and was in the process of a fourth replacement. The contact stated that the first three windshield replacements were due to a small gravel striking the windshield. The contact stated that failures had occurred while driving, and it was very scary, she was very nervous when she heard the loud popping sound from the windshield. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 500.

The Thermal control valve went out in May while I was traveling though Texas, I took it to a dealership right away to see what the issue was and was told once again it was the thermal control valve. When it goes out you have the check engine light come on, the eyesite, and cameras all stop working along with all The warning lights staying on. They replaced it and I was told I should most likely get a refund for when I had the part first replace in July 2021. Which at that time my car was only 7 months old. I was told I would get a reimbursement for that part. However ever since Subaru warranty sent me an approval for reimbursement of this service ( letter dated May 21, 2024 for $1071. 00 that should happen in 30 -45 days, they are now stalling and stating it will be 90 days for checks to be mailed out. This is a faulty part they knew it 3 years ago and failed to handle, now more and more vehicle owners are having the issue, so they will replace the part ONLY if you have any issues. This is fraud on the part of Subaru to their customers.

This is a safety issue regarding the durability of windshields. I have had 2 incidents now with my 2020 subaru outback having a cracked windshield. Both times it came on suddenly with at least a foot long crack or more the first time and an 18 inch crack the second time just recently. I reported the incident to the service manager this time and he put me in touch with customer advocacy at subaru who is waiting for a report from the diagnosis on Monday, July 22. The first crack was in March 2024. Prior to the crack happening, I noticed a drip of dried substance running down the inside of my windshield from the top of the windshield. I thought it must be sealant and was going to contact subaru. However, without warning, I pulled out of my garage one morning to find a crack across the driver side of the windshield at least a foot or longer. There had been no incident of any rock hitting my windshield that I noticed and there was no damage to the paint on frame close to where the crack started which was on the outer edge of the windshield. The crack grew larger and crossed over the driver's visibility. I asked if there had been a recall since I thought this was odd and spontaneous but there was none. The service repair person said if a rock chip occurs in the defroster area in the perimeter of the windshield, the windshield will sustain a long crack. So I believed that something like that must have happened in my lack of knowledge of prior issues with subaru windshields. I had a $1000 deductible on my insurance and the repair was over that. Subaru refused to negotiate with State Farm to reduce the price so I paid the entire amount out of pocket. The second crack occurred while I was driving in the rain. I turned off my wipers to find an 18 inch long crack on the passenger side of the windshield starting at outer edge of glass. No incident of a rock chip, no damage to paint on frame.

The contact owns a 2020 Subaru Outback. The contact stated while driving at various speeds, the vehicle stalled without warning. The contact stated that the battery was replaced several times; however, the failure persisted. The vehicle was taken to a local dealer, where it was determined that the battery was not big enough for the turbocharger installed in the vehicle. The battery was replaced; however, the failure persisted. The contact also stated that while driving at undisclosed speeds, the driver's side seat moved forward and backward unexpectedly. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000. The VIN was not available.

On [XXX], I was driving east on [XXX] on the North side of Toledo Ohio close to the intersection with [XXX] . The "Check Engine" warning came on, all the vehicle "Eyesight" functions were automatically turned off, and Pre collision braking and Pre collision throttle control features were activated. There was no danger of a collision at this time, but all of this left me stranded in the middle of this busy four lane highway. I was able to literally crawl to the shoulder of the road. I was not hit, but it was just good fortune that prevented that. This is where my safety was at greatest risk. After about 10 minutes during which I started and stopped the car numerous times, the pre collision braking and throttle were deactivated and I was able to drive the car. I located the nearest Subaru dealer (Yark Subaru Toledo, Ohio) and drove there. The cause of the Check Engine light was diagnosed as a failure of the Thermal Control Valve. I had received a letter from Subaru dated May 1, 2024 stating that this part might fail and extending the warranty for this part. That letter specifically stated that nothing needed to be done until the part failed. There was no mention of the fact that the car would be disabled when it happened. Part was eventually replace on July 1, 2024 two days later. Since then I have spoken to 3 people at Subaru of America seeking to understand why a Check Engine situation caused the vehicle to be disabled. I also asked the Service Advisor at Yark Subaru to explain. They have all been friendly and attentive, but they cannot or will not give an explanation. My main concern is that a Check Engine situation may cause this Pre Collision shut down to happen again. Based on the danger I was in when this happed, I think that there should have been a recall and the Thermal Control Valve replaced before failure. To be clear, the repairs were completed under warranty and Subaru has sent me a $350.00 coupon for future service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

The contact owns a 2020 Subaru Outback. The contact stated that while the vehicle was parked, the front windshield unexpectedly shattered. There was no impact to the windshield that could have caused the windshield to shatter. The vehicle was taken to the dealer, who suggested that the contact file a claim with the insurance company to replace the front windshield. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 90,000.

Hi: When I was driving yesterday, the engine warning light and brake warning light both turned on. The car was like frozen on the road cannot be moved no matter how to press the gas pedal. The police helped to call tow and move my car out of the road. The tow driver left my car at a flat parking lot. On the lot, when I tried to restart my car, the car started to shake side to side and up and down. I can feel some part is dislocated and one piece of heavy thing was swaying in the car. The engine warning light was on for two times during the last two years. First time when I sent the car to the dealership, they performed the check and fixed it by free. The customer service person told me the problem is the sensor failing and the fixing was free. So, I guess it is the system defect and the manufacture already knew it. So the repairing was free. However, with one year, the situation happened again. The second time I sent the car for fixing, the service person told me it was the same problem of sensor failing but they charged me around two hundreds dollar for the second time fixing. Yesterday, the same situation happened again with the brake warning light on at the same time. It is almost another one year after the second time I sent car for repairing. My most concern is the car completely suddenly stopped during the driving. If I was on the highway, serious collision may happen and I am already passed away.

Rear trunk door won’t lock when closed and open up while driving. It’s unsafe as I have to constantly keep an eye in rear view mirror to see if door popped open by itself. Took to service station and they said it’s tied to battery and it is preventing door to close because trunk door takes power to open. I do not understand how trunk door locking close cannot be independent of battery. It is quite unsafe for vehicle occupants and poses danger to other vehicles driving behind.

I have a occupancy sensor error which has turned off the airbags on the passenger seat. I looked up the issue and found an open recall with Subaru regarding this issue. I spoke with multiple case managers to resolve the issue. They said they have reported the issue to NHTSA but it is not an active recall because they have yet to find a solution. So they have no responsibility to fix the issue at this time. They are unwilling to provide me with an alternate option than driving my car with the exact issue they issued the recall for.

The contact owns a 2020 Subaru Outback. The contact stated while turning off the vehicle, the Data Communication Module (DCM) remained running, causing the battery to become drained twice. The vehicle was taken to a local dealer but was not yet diagnosed. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 25,000. The VIN was not available.