2020 SUBARU OUTBACK Complaints

The contact owns a 2020 Subaru Outback. The contact stated while the vehicle was parked, he became aware that the passenger’s side of the windshield was severely cracked. The dealer was contacted but the vehicle was not repaired. The contact was concerned that the vehicle was a safety hazard and could cause severe injuries to occupants in the vehicle. The manufacturer was notified of the failure and referred the contact to the Insurance Provider for assistance. The approximate failure mileage was 34,000.

Windshield Cracked on vehicle, this is the 2nd incident and second full windshield replacement In 2 years, noth OEM.

A small horizontal crack recently appeared on my Outback's front windshield while it was sitting in a garage overnight. The crack started from the passenger side and has now crept over to the middle of the windshield. Previous to this incident, the car had been sitting unused for over a month, so there was no opportunity for rocks or other debris from the road to cause the crack. This is the second time that the windshield has developed a crack out of thin air. I have replaced the windshield at least five times since owning the vehicle, in addition to having small chips from rocks repaired twice. These incidents are potentially dangerous and could possible interfere with the vehicle's automated systems such as collision detection and cameras.

As my husband & I were traveling to Augusta, GA on Memorial Day weekend with our niece, we approached the [XXX] outside Chattanooga, Tennessee in heavy traffic and heavy rain on Saturday [XXX] 2024 at approximately [XXX] When we stopped for a small accident ahead of us, the “auto stop-start engine” feature stopped the car engine as normal. However, almost instantly, all of the electronics in the car appeared to fail and the car would not restart. The dashboard indicated that Eyesight and RAB were disabled and to "check the owner's manual." Normal traffic quickly resumed around us, but we were stranded in the #2 lane with several close calls of a rear-end collision--not to mention the cars at risk swerving to avoid us. My husband is a retired firefighter & our niece is a nurse in Los Angeles. Frankly, we were terrified! We were stranded on the interstate in the #2 lane for about 20 minutes before being pushed into the "gore zone" between [XXX] & [XXX] by a TDOT truck. We spent about 40 minutes in the gore zone where we were nearly hit twice by cars driving across the zone. We were finally towed to Crown Subaru in Chattanooga, TN and arrived there about 11:40 a.m. The general manager of the dealership, Keith Aviles, told us there was a sudden, massive failure of a battery cell controlling the electronics of the car, and the battery was replaced. We never had any indication or evidence prior to this incident that there were issues with the battery. Also, we have never received a notice from Subaru about battery problems. However, we are now aware that Subaru settled a class action lawsuit to avoid a recall of these batteries. I have notified six friends who own Subarus. Three have had issues with their batteries, but were also unaware of the class action lawsuit. This is absolutely shocking for a vehicle manufacturer that touts safety to sell vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The windshield has cracked every year since I purchased the vehicle in May 2020. I fortunately bought the insurance but that only covers the windshield once a year. The windshield cracks within a month or two of replacing every single year. The cracks generally start from the edge of the windshield and there is no indication that it was hit be a rock as the start of the crack is clean. There have been two incidents where I heard a pop prior to the start of the crack. I am currently on my fourth windshield.

The driver’s side (front left) power seat adjust motor has lost the inside end cap of the worm drive control assembly. Only the outside left rail will move. Subaru will not sell the part to repair, they only will supply the entire lower seat assembly for $1000. .

This vehicle is equipped with a driver monitoring system. This system will flash warnings and activate audible alarms directing the driver to keep his/her eyes on the road. At times this system malfunctions and blares warning after warning non-stop to keep eyes on the road when in fact the driver is absolutely looking straight ahead giving the road and traffic full attention. This erroneous non-stop alarm is distracting to the driver and will continue non-stop. Mostly the alarm can be ended by stopping the vehicle and shutting it off and then restarting the vehicle. The distracting nature to the driver is not the only issue. Is that false driver attention alarm being recorded to some black box to be recovered by any investigator, law enforcement or otherwise? If I should be in an accident while the vehicle erroneously has recorded that the driver was not attentive, then in fact I was, how could I prove otherwise? After all, the computer said otherwise. Once, the alarm begins, there is no way to safely stop the vehicle on the interstate, rush hour beltways and such. There is no way to safely stop the vehicle and turn off the ignition. My vehicle electronic system has been updated several times under the warranty period, yet this erroneous distracting safety alarm persists on an intermittent basis. I never know when. it is going to happen. There is reference in the manual to turning the system off, however I question whether just the alarm is turned off and the false data is till being recorded for anyone to find and place me in jeopardy should an accident occur. This is a known problem discussed in multiple forums and discussion groups. This has been and intermittent problem since 2020.

Spontaneous crack in windshield with no other signs of chips or damage. Car was sitting in the driveway when it occurred.

This was December2023Clicking noise when turning. "Rear swaybar bushing replaced (have gap in them when loaded)" also replaced 2 front Axle/CV Boots. Said they were worn. Additionally today, 5/3/2024 got in my car and there is a crack in my windshield that occurred overnight. Crack comes from bottom corning on drivers side up about 12 inches.

Windshield developed crack without impact. Crack runs from the bottom of windshield in front of steering wheel up to the middle of the windshield, impairing visibility. This is the fourth failed windshield on this vehicle within 4 years and 60,000 miles. Average lifespan of windshield on this car is less than 12 months. Previous windshields cracked with minor hits from pebbles at highway speeds. Windshield has not been inspected by manufacturer, police, or insurance representatives, but is available for inspection.