2002 SUZUKI SUZUKI MOTORCYCLE Complaints

MOTORCYCLE TRANSMISSION SLIPS OUT OF GEAR: MAKE: SUZUKI MODEL: INTRUDER LC1500 YEAR: 2002 THE MOTORCYCLE WILL SLIP OUT OF 4TH GEAR AND GO TO NEUTRAL WITHOUT CAUSE OR WARNING. VERY DANGEROUS SITUATION, ESPECIALLY WHEN DRIVING ON THE INTERSTATE HIGHWAYS WITH CLOSE TRAFFICE BEHIND YOU.

HAYABUSA 2002 WITH 10 K MILES IS DEMONSTRATING A PROBLEM THAT IS ONLY RECOGNIZED AT 2ND GEAR.I BROTH THE BIKE 3 TIMES TO DEALER AND AFTER MANY WEEKS OF DIAGNOSE AND MECHANICS THEY CONFIRM THE PROBLEM.*AK 2ND GEAR IS POPPING OUT AT 7K RPM AND REPAIR DEALER WOULDNT REPAIR IT IF A AUTHORIZATION IS NOT SIGN BY ME. CALLED SUZUKI FOR WARRANTY AND THE RESPONSE WAS THAT IS THE WAY IT WORKS. SUZUKI HAVE THE WORST WARRANTY. I WILL NEVER BUY ANOTHER SUZUKI AGAIN.

SUZUKI DL-1000 V-STROM PROBLEM - CLUTCH BASKET WEARS OUT AFTER ONLY A FEW THOUSAND MILES. REPLACED UNDER WARRANTY, THE SAME PROBLEM IS STARTING TO HAPPEN AGAIN AFTER ONLY 3000 MILES. THIS LEADS ME TO BELIEVE THE CLUTCH BASKET DESIGN IS DEFECTIVE AND SHOULD BE FIXED IN A DIFFERENT MANNER RATHER THAN JUST REPLACING WITH THE SAME PARTS.*AK

VEHICLE EXHIBITS EXTREME NOISE AND VIBRATION FROM CLUTCH AREA. VISUAL INSPECTION SHOWS CLUCTH BASKET ASSEMBLY TO BE EXTREMELY SLOPPY IN FIT. OTHER OWNERS (REFERENCE: HTTP://AUTOS.GROUPS.YAHOO.COM/GROUP/VSTROM2/DATABASE?METHOD=REPORTROWS&TBL=4) REPORT CLUTCH BASKET REPLACEMENT UNDER WARRANTY RESOLVES SIMILAR COMPLAINTS. BUT MANUFACTURER IS REPLACING PROBLEM PART WITH IDENTICAL UNIT. I BELIEVE THEY NEED TO BE 'URGED' TO REDESIGN PART PROPERLY, AND RETROFIT ALL AFFECTED VEHICLES.*AK

WHILE DRIVING OIL LEAKED ONTO THE REAR TIRE. *NLM THE CAUSE WAS MASSIVE CRANK CASE PRESSURE IN WHICH THE MOTOR BUILT UP THE CRANK CASE AND POURED OIL OUT OF THE MUFFLER AIR BOX INTO THE MOTOR WITHOUT WARNING. *SCC

SUZUKI MOTORCYCLE HAD AN OIL LEAK. THE OIL LEAKED DUE TO A CRACK IN THE ENGINE CASE WHERE THE BOLT HOLE WAS POSITIONED ON THE BOTTOM OF THE MOTOR (2002 SUZUKI MARAUDER). *AK *NLM

FAILURE OF SUZUKI MOTORCYCLE TO REPLACE DEFECTIVE PISTONS IN 2001-2002 SUZUKI BANDIT MOTORCYCLES (GSF 1200). THEY ISSUED A TSB SAYING THEY WOULD DO SO IF THE MOTORCYCLE BURNED MORE THAN 1 QUART IN 600 (NOT A MISPRINT) MILES. THAT'S ALMOST A GALLON BETWEEN OIL CHANGES RELEASED INTO THE ATMOSPHERE. PLEASE SEE SUZUKI TSB #129. I BELIEVE THAT AT THAT RATE OF CONSUMPTION ENGINE SEIZURE AT SPEED COULD BECOME AN ISSUE RESULTING IN INJURY AND DEATH TO THE RIDER. SEE RELATED INFORMATION AT: HTTP://WWW.MAXIMUM-SUZUKI.COM/IBF/INDEX.PHP?S=95E46471B8A65930A70342CAB9325053&ACT=SF&F=18

THE FUEL INJECTION SYSTEM CAUSES SURGING, STALLING, AND UNEXPECTED ENGINE PERFORMANCE. UNABLE TO OPERATE VEHICLE IN SAFE MANNER DUE TO UNEVEN AND UNEXPECTED ENGINE PERFORMANCE. WHEN TRAVELING DOWN THE ROAD AT A CONSTANT RPM, THE BIKE "SURGES" BACKFIRES, MISSES, AND CAN NOT MAINTAIN A CONSTANT RPM. I HAVE RODE TWO OTHER IDENTICAL BIKES THAT DO NOT EXHIBIT ANY OF THESE PROBLEMS AND ARE SAFE TO DRIVE. SUZUKI CUSTOMER SERVICE REFUSES TO ADMIT OR ADDRESS THAT THERE ARE PROBLEMS WITH CERTAIN SUZUKI DL1000 MOTORCYCLE FUEL INJECTION SYSTEMS. DT

THE CONSUMER IS EXPERIENCING PROBLEMS WITH OIL LEAKING FROM UNDERNEATH THE BIKE, WHICH IS COMING FROM THE CYLINDER, THE CYLINDER BASE GASKET HAS HAD TWO FAILURES-WHICH IS A COMMON PROBLEM WITH THIS MAKE/MODEL. MR *SCC *NLM

(SUZUKI GS650 2002) THIS COMPLAINT CONCERNS THE ENGINES OF MOST 2001/2002 SUZUKI BANDIT 1200 MOTORCYCLES. HUNDREDS OF OWNERS HAVE EXPERIENCED SMOKING AND HIGH OIL CONSUMPTION SINCE BUYING THIS MOTORCYCLE. THEY CERTAINLY CANNOT PASS EPA EMISSIONS STANDARDS IF THEY SMOKE. *TS ***DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS***761433