SUZUKI Complaints

EXCESSIVE TIRE WEAR ON FRONT INSIDE TIRES. TIRES WEAR THROUGH TREAD ON INSIDE WHEEL WITHIN 5,000 MILES OF BEING PLACED ON FRONT OF CAR. MANUFACTURER REFUSES TO DO ANYTHING ABOUT . CAR HAS BEEN IN 4 TIMES TO SUZUKI DEALER.*AK

PURCHASED A 2004 VERONA ON 10/01/2003 AND THIS IS MY FOURTH TRIP BACK TO THE DEALER FOR SERVICE FOR THE SAME ISSUE OF ROUGH IDLE, HESITATION AND THICK WHITE SMOKE COMING OUT OF THE EXHAUST. VEHICLE HAS ALSO STALLED AND I CONSIDER A SAFETY RISK WHEN TRYING TO ACCELERATE FROM STOPS THE VEHICLE DOES NOT MOVE OR WHEN TRYING TO PASS OTHER VEHICLES OR GOING UP AN UPGRADE AND THE VEHICLE DOES NOT DOWN SHIFT AT TIMES.*AK PE04062_CAT

RE: 2003 SUZUKI SCOOTER AN 650 BURGMAN. ELECTRONIC (LCD) DISPLAYS OF SPEED AND OTHER DATA ARE IMPOSSIBLE TO READ IN BRIGHT LIGHT WHEN TRAVELING. THIS MAKES IT IMPOSSIBLE TO ACCURATELY CONTROL SPEED ON THE VEHICLE. THIS UNIT SHOULD BE REPLACE BY ANALOG GUAGES WHICH CAN BE READ IN ALL LIGHT CONDITIONS.*AK

WHILE DRIVING AT 30 MPH CLUTCH FAILED. DEALER AND MANUFACTURER STATED IT WAS CONSUMER'S PROBLEM, CLUTCH WAS NOT COVERED UNDER WARRANTY. *AK

DEFECTIVE HEADLIGHT ASSEMBLIES THAT BECOME USELESS AT NIGHT. THE HEADLIGHT ASSEMBLY IS A SEALED UNIT. AFTER 5000 MILES, MY HEADLIGHT WAS FULL OF A BLACK POWDERY SUBSTANCE WHICH COATED THE INSIDE SURFACE OF THE LENS THEREBY RENDERING THE LIGHTING POOR AT BEST. *AK THERE WERE ALSO NUMEROUS SMALL PIECES OF GLASS FROM THE EDGES OF THE PROJECTOR BEAM LENS RATTLING AROUND INSIDE THE ASSEMBLY. THE MOTORCYCLE COULD NOT BE RIDDEN AT NIGHT DUE TO THE LACK OF ADEQUATE LIGHTING. I HAD REPORTED THIS DEFECT TO THE SUZUKI SAFETY DEFECT HOTLINE AND SUBSEQUENTLY THE MANUFACTURER HAS REPLACED MY OLD ASSEMBLY (FURNISHED THE PART ONLY, NO LABOR). THE NEW ASSEMBLY APPEARS TO BE OF THE SAME CONSTRUCTION AND CARRIES THE SAME PART NUMBER. I FULLY EXPECT THAT THIS ASSEMBLY WILL LIKELY PERFORM NO BETTER THAN THE ONE IT REPLACED. THERE ARE NUMEROUS OTHERS THAT I KNOW THAT HAVE THE SAME MOTORCYCLE WITH THE SAME PROBLEM.*AK

VEHICLE WAS INVOLVED IN A HEAD ON COLLISION AT 20 MPH AND THE AIR BAGS DID NOT DEPLOY.*MR THE CONSUMER CONSIDERED THE CAR TO BE A VERY UNSAFE VEHICLE AND HAS MADE A REQUEST FOR A SAFER CAR.*CB *JB

WHILE DRIVING, THE ENGINE MAKE A TICKING NOISE AS IF IT NEEDED OIL, BUT IT DIDN'T. UPON INSPECTION OF THE VEHICLE BY THE DEALERSHIP THEY INDICATED THAT THE NOISE WAS CAUSED BY AN INTERNAL ENGINE PROBLEM. *AK *CB *JB

WHILE DRIVING ON FLAT ROAD, THE VEHICLE DID NOT ACCELERATE OVER 50-60 MPH. THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM. *AK THE CONSUMER PURCHASED THE VEHICLE WITH WHAT SHE THOUGHT WAS MINOR COSMETIC PROBLEMS THEN THEY STARTED TO GET WORSE AS TIME WENT ON, THERE WAS A DRAGGING WHICH CAME FROM THE REAR INTERIOR, THE SEAT BELT HOLDERS RATTLED, THE LEATHER SEATS HAD SINK HOLES WHERE THE BATTING WAS COMING FROM THE LEATHER, AND THERE WAS A LOUD ROAR COMING FROM THE ENGINE. *SCC *JB

THE BRACKET WHICH THE CLUTCH FOOT PEDAL AND THE ARM WHICH THE MAIN CLUTCH VALVE ACTUATOR IS DRIVEN BY HAS A METAL FATIGUE WHICH MAKES THE CLUTCH INOPERATIVE. COULD LEAD TO A ACCIDENT OR OTHER PROBLEMS.*JB

WHILE SHIFTING GEARS, THE TRANSMISSION WOULD DOWN SHIFT ON ITS OWN. THE DRIVER TOOK THE MOTORCYCLE TO THE DEALER FOR ANALYSIS. THE MECHANIC NOTICED THAT THE GEAR SHAFT NEEDED REPLACING. *PH