2019 TESLA MODEL 3 Complaints

I received an error. - RCM_a056 "front passenger safety restraint system fault" So I scheduled service to review what happened. According to Tesla, and my service center - this is a known and common issue. The issue is a failure of the seat occupancy sensor. This requires replacement of: seat harness assembly, seat belt reminder sensor box clip and the first row occupancy sensor. However, the major issue (and what should be a class action lawsuit) is that Tesla created a new sensor - that now works, however, requires the replacement of the PASSENGER AIRBAG. Tesla's solution to this widely known issue (according to my service center) was to create a sensor that is not compatible with the current airbag system. This cost is astronomical. If the sensor alone could be replaced, this could be around a $400 fix, but because the airbag is an extra (approximate) $1,000. Total cost of repair is $1,329.34, not including the required $100 remote diagnostic fee.

I bought a used 2019 Tesla model 3 and just got a system warning that says “Front passenger safety restraint system fault”. I was researching this and it seems to be a common enough issue that a recall should be issued for it. If the seat belt system fails, someone could be very seriously injured if they’re in an accident

Tesla Model 3 battery pack coolant connector design flaw. It is made by plastic and covered with very thin cheap plastic cover which can very easily create impact and break the battery pack connector when any small objects hit front wheels(both side) while driving that leads the following safety and hazard issues to driver and passengers. 1. When there is hit in the coolant connector while driving the coolant start leaking which put safety of car,driver,passengers and others in very high risk 2. When it happens the dashboard shows the car is running reduced power and not giving enough info to take immediate action 3. This issue can be easily reproducible just driving the car in freeway where the road has debris or due to work zone 4. This issue reported to Geico Insurance 5. There is no warning before it first appears 6. It leads to change the entire battery pack which cost ~ $20,000 7. Since this is very critical component it should be well protected which is not the case currently

Continental 235/40/r19 This is what I sent to Consumer Affair website: My personal experience reflects exactly the same as the poor rating of this brand. Tire has separation at 32k miles on the Tesla 3. I first noticed a thumb thumb sound. I ignored but it got worse then the vibration inside cabin started to occur. I pulled the tire off and inspected. My God i have a tire separation with steel wire sticking out and a big hump. I got mad after i found out that Tesla wants nothing to do with it (heck they don't even a have no. to call for an expensive car, shame on you Tesla) and Continental does not have a warranty. Spending time searching for another tire to buy i find out it is expensive for EV tire. I was frustrated and angry that i have to deal with a defective tire with no warranty from Tesla and Continental for low miles (plenty of thread left on tire). I decided to call Continental. The experience was horrible with them hung up on me and a run around. They told me to take to Discount tire to have it inspect. Dt agreed tire is defective and expect me to pay $250 with pro rate covered by Continental. I already found the same tire for $225 so i tell D.t take a hike. I called Continental back and [XXX] broke loose. I got a lot of run around, hung up with the rep. then manager and they won't do the tire pro rate more than 30%. I got fed up with lot of cussing I went back to D.Tire and settled with another Continental tire that is cheaper. I was pushing my luck driving with the tire that will blow anytime. The [XXX] Tesla does not have a spare tire on an expensive car (shame on you Tesla). I had no choice to replace a tire out of my pocket of $150 for the same brand as that is the only one with similar thread pattern very reluctantly as I had NO other choice or take a risk driving and NO spare tire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Tesla Model 3. The contact stated while driving at 55 MPH, the steering wheel seized and made it difficult to turn. The vehicle was taken to a local dealer where it was diagnosed that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

The contact owns a 2019 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The following recalls have been pending on my vehicle: 23V-838; TC2023-657, 24V-051 Tesla is unable to push over-the-air (OTA) updates to my vehicle to remedy these recalls due to an issue with the onboard computer being unable to receive updates. This issue arose when Tesla pushed a software/firmware update to my vehicle which effectively "bricked" the Advanced Drive System portion of the computer. In other words, I am unable to safely receive an update to resolve the issues (solved by the recall) because Tesla's failed software update damaged the onboard computer.

February 2024 my car gives me a pop up warning on screen that “ steering ability may be reduced”. A few minutes later I could barely steer the car as if steering was partially locked up to maybe 90%. Tesla service dept. said the car “ reset” and it was ok to drive. Today April 16 2024 the same thing happened while driving. This is very dangerous. This is a software issue Tesla needs to resolve. The contact stated the vehicle is in the repair shop again regarding the same issue.

Front Passenger Safety Restraint System Fault requiring replacement of airbag and passenger seat sonsor retrofit. If not replaced a danger of airbag failure to deploy. Problem confirmed with dealer and inspected by manufacturer. Warning light appeared to bring car in for repair

I started to notice a noise that kind of sounded like rusty hinge on door every time I turned the steering wheel. It did not matter whether it was left or right. I took the car into the dealer because I was concern it could be something serious. The Tesla service center said my upper and lower control arms were "torn" and needed to be replaced. I find this hard to believe that control arms are failing only after 35, 000 miles on the car. The car is not even 5 years old yet. I am not abusive with this car and even so this should not be happening. I have many other vehicles over the years with hundreds of thousands of miles on them and never had issues with control arms.