2018 TESLA MODEL 3 Complaints

On August 2020, Error showed on dash: Front passenger safety restraint system fault/Contact Tesla Service. Took to Tesla to investigate, and they perform service based on bulletin [XXX] ). The error message then returned exactly a year later August 2021, but Tesla denied that it was the same issue and had to charge for this repair since car was out of warranty. Since then I have met with other owners that had expressed the same situation and I wanted to officially document this in case in need to become an actual recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Got warning about front drivers safety restraint failure on screen. Airbag warning began to display on the side showing if an accident occurred, they would not deploy. Talked with Tesla representatives and was told this is a known issue but would not be covered. Seems to be faulty wiring from chair moving over time based on what I was able to read. Error code was rcm_a021.

Front Passenger Safety Restraint System Fault error. Tesla is indicating this is out of warranty but seems this is a very pervasive issue with an important safety mechanism on the car.

The rear camera routine fails to activate. I wonder if this related to the trunk harness issue. I tried contact Tesla, but they want to charge for a repair.

Concern: I See the error message on my screen like restraint system fault require service. when I contacted Tesla for Sevice Repair I got an estimate which includes following fixes for a charge of 1,804.02. They are not covering for this saying the car is out of warranty. Seems like Tesla is aware of this issue and impacting many other Tesla's for 1) FIRST ROW SEAT HARNESS ASSEMBLY - RIGHT HAND(1489060- 03-G) 2) FIRST ROW - SEAT BELT REMINDER SENSOR BOX CLIP(1130363-00-B) 3)Correction: Replace Front Passenger Airbag And Update Vehicle Configuration - Remove and Replace

I was called told suspension issue unrelated to accident. Sounds like a recall from the same year and same model. Could it be under this recall? Suspension: Front Recall date 2023-03-30 Recall no. 23V235000 Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame. Recall consequence A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash. Recall action Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752 (tel:1-877-798-3752). Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous re call number 21V-835.

On [XXX], I started driving to work when I heard an click from my front wheel. The car was driving without any problem. After a while when making a U-turn, the car front wheel got completely locked with a "grinding sound" and I lost control of the car. Fortunately, it was at low speed and I just stopped driving, If it was at high speed, it could've been a horrible situation. I had to park my car, call Tesla and tow the car to them as it was not drivable. After initial evaluation, they said the bolts of the right suspension lateral arm were not only loose, but detached and fell off, so there was physical locking between the wheel and the lateral arm. Also the bolt attachment site at the subframe was completely worn out so they needed to change the whole subframe and both lateral arms. Beside a clear RECALL from TESLA models 3/y made between 2018-2020 about the exact same issue, and this event being for the same exact problem, Tesla keeps not appreciating that and says that recall is gone. Tesla says the loose component will be audible before it completely separates, but it was not in my case. Looking at people's posts in public media, I strongly believe Tesla is ignoring this life-threatening deficit in these cars and models and this can put the lives of many drivers at risk. While I paid out of pocket for repairs, I'm more concerned about the safety of driving my and similar cars at the moment, so I request adequate investigation. Here is some evidence: [XXX] [XXX] [XXX] . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? “Front left safety restraint system fault” error code “RCM_a021” How was your safety or the safety of others put at risk? It appears as though the seatbelt or airbag may not function properly when needed. Has the problem been reproduced or confirmed by a dealer or independent service center? No but it has been on every time I drive. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, upon requesting inspection, I was quoted 400$ Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, it appeared periodically before but now it’s constant as of 9/29/2024

Seems that when brake pedal sensor can trigger a "pressed" reading when not actually being pressed. The only way to turn off the car manually is defeated by, you guessed it, depressing the brake pedal. This causes the vehicle to remain on and unlocked. Even if you are able to leave the vehicle in a locked park state, at any point, the sensor can register a "pressed" reading and essentially unlock and turn on the vehicle. I see this as a extremely serious safety issue. The issue seems to occur randomly at first and then more frequently. It can be confused with a known seat sensor issue which seems to also cause the same symptoms.

Car was making clunking sound, so made an appointment with service center. Before appointment, clunking sound stopped. Around the same time the clunking stopped we found a bolt in the driveway. Took into service and was told a bolt was missing from the lower lateral link which sounds quite concerning. I'm told by others had both bolts fallen out the wheel would have tipped inward or outward and damaged the fender and possibly caused an accident. I searched recall notices and I found recalls and/or bulletins with the same problem in similar but not the same VIN range as our vehicle and have read of others with similar problems not covered by recalls. There had been no previous work done on the front suspension.