2019 TESLA MODEL 3 Complaints

The vehicle has quite a bit of noise coming from the suspension during normal driving. Creaks and groans.

Between 2023 and 2026, I have had several clunking and creaking sounds from the suspension. These were then found isolated to "lateral and compliance link detachments" and Tesla noted these were "serious safety issues" and fixed them out of warranty at a cost of roughly $2500. When I pointed out that vehicles within this model range (manufactured April 2019 at the Fremont, CA plant) were flagged for a recall, they mentioned my vehicle was outside that range and insisted on an out-of-pocket repair. Further, I have similarly had to have the front left driver's side seat belt harness replaced because of a restraint control module failure. I have owned 3 other vehicles and have never had a restraint control module/seatbelt fail over just 82000 miles of use.

Honestly since I took delivery the vehicle I did notice a clunking sound every time I would turn into a steep driveway. I reported the problem to Tesla on multiple occasions and they either could not replicate the sound or find the problem when they inspected the vehicle. So I lived with the on and off clunking sound. Years later while driving on the freeway I heard a really hard clunk and I began to lose control of the car luckily I was close to home and I was able to make it to my street. Upon arrival my tires completely fell off the control arm and I could move the steering wheel at all. I had to get it towed to the body shop. Long story short the lower control arm bolt completely fell off. I just happy this didn’t result in a major accident. But I had to get the car towed. I am pretty upset that Tesla pretty much said there is no issue. My family has Teslas and in all of them I hear the same clunking sound.

About one month ago, my 2019 Tesla Model 3 developed a suspension issue that caused a noticeable vibration in the rear of the vehicle whenever I drove above 40 mph. At first, we suspected the problem was related to a tire. However, after the technicians at the Tesla Service Center lifted the vehicle for inspection, they discovered a much more serious issue. They brought me into the service area to show me that the right rear suspension was being held together by only the front portion of a bolt. The retaining nut had completely come off, leaving the bolt barely in place. Had that bolt shifted even a few millimeters while I was driving, it could have resulted in a catastrophic suspension failure and a serious accident. Tesla determined that the loose bolt had caused damage to the right rear (passenger-side) suspension assembly. The necessary repairs totaled approximately $1,800, which I paid to restore the vehicle to safe operating condition.

My brake lines have corroded to the point where half a liter of brake fluid has leaked out rendering the vehicle unsafe. Tesla admits that this is a design flaw but says that it does not affect this particular VIN number but the damage is exactly as described: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Tesla rolled out FSD 14 Lite to hardware, including to my vehicle and it’s become extremely unsafe.The past several days the vehicle will suddenly slow down/break causing people to almost crash into me, make sudden and indecisive lane changes, and constantly rocking the steering wheel left and right. I hope someone takes this seriously and has Tesla revert back to the old software or make changes before someone is killed.

The Front Passenger Safety Restraint System failed prematurely on my 2019 Tesla Model 3 at only 23,105 miles, triggering the alert 'Alerts - Seats - Front passenger safety restraint system issue/Service is required' and disabling passenger airbag functionality. Upon inspection, Tesla Service quoted $1,285.13 out-of-pocket to repair the system. While the root failure involves a $12 occupant occupancy sensor (Part #1099592-00-F), Tesla's mandatory service procedures require a full subsystem revision cascade to fix it. Specifically, under 'Replace Occupant Classification System (OCS) of Front Passenger Seat while Servicing Subcomponents' and 'Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat,' Tesla requires replacing the right-hand seat harness assembly (Part #1489060-03-G) and the complete Front Passenger Airbag (Part #1077823-00-G) solely to maintain hardware compatibility with the revised sensor. Because Tesla redesigned subcomponent hardware without offering a backwards-compatible replacement sensor for earlier Model 3 production units, restoring a critical primary safety system creates an exorbitant financial barrier, forcing the vehicle to be operated with disabled airbags.

I was locked inside my tesla model 3 two stories down in a parking garage with no internet access to find out where the emergency release was for my door. I KICKED my driver side window to survive. It wasn't until after I was told that the doors are tied to a 12v battery that had died without warning. I did not know the doors tied to that nor that there was a secret emergency release. There are no clear indicators within the car that this is how it operates and you SHOULDN'T NEED INTERNET ACCESS AND ELECTRICITY TO SURVIVE EXITING A CAR.

Front passenger Occupant Classification System (OCS) failed on its own, without accident, misuse, or modification, at low mileage. The fault disables proper airbag deployment logic for the front passenger seat. Tesla has issued multiple service bulletins acknowledging this as a known condition. **Vehicle Identification Number (VIN):** [XXX] **Model Year:** 2019 **Make:** Tesla **Model:** Model 3 **Mileage at time of failure:** Approximately 27,800 miles **Date of incident/failure:** XXX (date alert was first detected, per invoice) **Component:** Air Bags / Occupant Classification System (Front Passenger) **Crash involved:** No **Fire involved:** No **Injuries:** None **Number of injuries/fatalities:** 0 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am getting an electrical fault which has disabled my front passenger seat airbags. They need to replace the wiring, which means they also now need to replace the passenger airbag itself because wiring has changed and the old airbag is not compatible with the new wiring. Replace Occupant Classification System (OCS) of Front Passenger Seat while Servicing Subcomponents Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat I had this same error 4 months ago and it ended up shorting out the entire electrical system, which disabled autosteer and eventually completely disabled power steering which made the car unusable. Tesla service center called it a water intrusion problem and had to replace the entire front electrical harness system and steering rack costing $4500. Now the problem has resurfaced and I'm afraid I might lose power steering again which is extremely dangerous and could happen any time, in addition to my airbags potentially not deploying.