2018 TESLA MODEL 3 Complaints

Front passenger airbag and Seat sensor issues. The safety of front seat passenger was at risk due to faulty airbag or sensor. Tesla did confirmed that an alert was trigger on the car an they proceeded to replaced the airbag and sensor. Tesla verified the equipment after the repairs were done and everything since to be fine. We did get a warning on or around Feb 5th, 2024 and that when we proceeded to contact Tesla service and make an appointment. The reason for this complain is that we ended up paying for airbag and seat sensor repairs which should have been covered by Tesla since these parts are obviously defective. Please see uploaded documents for more details.

PTC Heater failed. This is a critical component that helps to maintain the battery's temperature within safe operating range. The only alternative is to replace this PTC Heater. Till the replacement is done, EVs battery may not maintain safe operating temperature range and could cause the car - not drive able. I consider this a significant safety risk. Cabin temperature cannot be maintained as well. Cause for PTC Heater failure is known - "change in temperature" could cause this item to fail per Tesla. i.e. when cold air blows over the heating element. Not sure if enough has been done to fix this from occurring for such a critical component with some hardware or hardware recall for several vehicles on the road. Else these cars must be considered for sales only for few states in the USA which have a stable operating temperature ranges for their PTC heaters to not run into the risk of failure due to big change in temperature.

The High Voltage Service Panel is part the battery which is part of the manufacturer warranty and drivetrain. A lot of Tesla cars had this problem and they are being charged $1800 to $2000 to “fix” this common failure. The problem is that the battery stop receiving the full amperage to charge the battery appropriately. In my case, I started charging more frequently on Superchargers during a long trip to different locations without a Level 2 homecharger and stopped several times into the Superchargers of Tesla. A diagram of the drivetrain and Battery system placed the High Voltage Service Panel as part of the battery. I had the problem since the past 2 years and did not fixed it, after I was sent an estimate cost of “repair”. I said that it was part of the battery system and they refused to accept it. As of 2024, I have search about this problem and most of the cars after 3-4 years are having the same problem. I am not sure what the repair consist of, but it might be a full battery replacement, and maybe opening the battery unit. In terms of safety, I feel unsafe about the possibility of the car catching fire during a supercharger session or even when plugged into my house Level 2 charger at 220 volts. Please inquire more about this frequently ongoing problem and safety, or any TSA related to this common issue. I included a picture found on the internet and the service panel is just on top of the battery

Horn stopped working. I see other people have this problem with Model 3. Tesla does not cover this after warranty period.

The rear camera often fails. Does this mean it is recording or not when driving. I think Tesla should have fixed this rear camera harness recall. I have been waiting over two years for this fix. It has been too long. Safety issues backing up or driving without the rear camera working properly.

The steering wheel horn stopped working about a month or so ago. I can use the Tesla app to make the horn sound but not by pressing the steering wheel. Fortunately, no safety of others or myself have been experienced. No one else has inspected it yet, though I am due to have my state inspection tomorrow and I don't think that it will pass. There were no warning lamps for messages prior to the failure. I think I first noticed that it wasn't working about a month or so ago. I reported the bug on the car texting service but have not heard from Tesla nor received a software update to fix the problem.

Get an error message - Front Passenger safety restraint system fault. - This is front passenger safety issue - This can put the front passenger to serious risk to injury or death - This message does not go away & Tesla acknowledges they need to fix it - Its not been inspected by police or insurance reps - Yes there is a warning message as noted above Tesla is failing to admit its their fault. They are giving me a quote of $2300 to fix this issue which I believe is a safety issue that Tesla did not manufacture properly leading to this issue. Please see the attached quote from Tesla - They need to "Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat" and many other related fixes to get rid of this issue. TESLA SHOULD BE RECALLING VEHICLES FOR THIS SAFETY ISSUE!

I don’t feel comfortable driving this car because it is unsafe when I am on autopilot on the highway it would randomly stop the car by breaking instantly out of nowhere when there isn’t any car in front of me?! Please give me another car that is more safe to drive!?

Vehicle touch screen will shut off while driving and take 5 minutes to reboot. I have taken it to Tesla multiple times since November and they said it’s a firmware issue and nothing is being done to resolve.

While in FSD the car swerved to the left and hit a Tree. Youtube of the Crash.. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)