2018 TESLA MODEL 3 Complaints

The passenger safety restraint system fault message pops up when driving normally. The diagnostic came up to replace the whole airbag after communicating with service center.

Front passenger safety restraint system fault error message. Error messages comes up most of the time when starting a drive. Tesla reviewed the error message remotely and provided a repair quote.

Dear NHTSA, I am writing to report a safety defect with my Tesla Model 3, VIN [XXX] . On July 28th, 2023, at 3:34 PM PST, My wife [XXX] was driving into my driveway at my home at [XXX] . The weather was sunny and car was traveling at 5-10 mph. The car was not in Autopilot and the driving mode was set to Chill mode. When pressed the brake pedal to slow down, the car did not stop and went straight into my garage, causing significant damage to my home and the car. Very experienced driver and I am confident that wife was applying the brake pedal correctly. However, the car simply did not stop. I am very concerned that this is a software glitch in the Tesla car, and I am worried that it could happen to other Tesla drivers. I have tried to contact Tesla to report the issue, but I have not been able to reach anyone. I had the car towed to a body shop, but the car is now totaled and I cannot take it back to Tesla. I am requesting that NHTSA investigate this safety defect and take appropriate action to protect Tesla drivers. I am also requesting that NHTSA help me to get in touch with Tesla so that I can resolve this issue. Thank you for your time and attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I noticed noise coming from the front driver's side wheel especially when turning. Upon inspection, I found that a nut was missing from the front suspension lateral link that fastens the link to the sub-frame. Also, the 2nd bolt fastening the link was very loose. This is exactly what happened as noted in the NHTSA Part 573 Safety Recall Report - 23V-235. Tesla service says that "there are no open campaigns for your vehicle for nuts missing". Well there needs to be as this is very dangerous.

Charge port door won’t open and charging ports will not unlock when the “unlock charge port” button is pressed on the app. I have to open the charge port door manually. However, the charging ports will unlock when I press the “unlock charge port” button on the touchscreen repeatedly. Previously, the charge port door and charging ports will open and unlock when the “unlock charge port” button is pressed on the app. I have previously requested service, then canceled service once I was informed of the price to replace the charge port door. Recently, I requested service through the app. Before I scheduled a service appointment, there was a pop-up message educating how to open the charge port door. I believe Tesla created the pop up because other users are experiencing the same issue. If that is the case, Tesla should issue a recall to replace the charge port door/charge port apparatus for the Tesla 3 vehicles that are experiencing the problem.

Charging port door won’t open and ports won’t unlock when the button to unlock the charging port door is pressed on the app. Previously, the charge port door would open automatically when the unlock charge port door button is pressed on the app and touch screen. Now, I have to open the charging port door manually. However, the charging ports will unlock after I repeatedly press the button to unlock charge port door on the touchscreen. The ports have to unlock in order for the charger to be inserted to charge the car. I have requested service and cancel service when I was informed of the price to replace the charging port door. Recently, I requested service then a pop-up message appeared stating that several Tesla 3 users have been experiencing problems with the charging port door. If that is the case, there should be a recall And Tesla should replace the charging port doors/charging port apparatus for Tesla 3 owners that are experiencing the problem.

The PASSEMBLY POWER CONVERSION SYSTEM- 48AMP 1PHASE(1135558-04-A part is part of the powertrain attached to the battery pack.. Without it, the car is unable to charge. This failed at approximately 32,000 miles on 8/29/23 on my 2018 Tesla Model 3. The repair was not covered under the powertrain warrenty despite being a critical component.

on 8/26/2023 @10:44AM, received a message on the vehicles display that stated, "Front Passenger Safety Restraint Fault, service is required". This fault is intermittent. Set up a service appointment and after diagnosing the problem remotely, received this response: there are currently no faults/alerts, so it is at your discretion as to when you would like to address this. When the alert is present, the front airbag deployment will not be optimized for the passenger weight. Airbag replacement is necessary to be compatible with the seat sensor update and will ensure better serviceability for the future if it becomes necessary. Let me know if you have any further questions about the repair. Estimate of repairs, $1760.00. I have another tesla model 3, 2017 model year with the same fault. First of all, I drive the vehicle as a commuter car, and 99% of the time I drive alone. Secondly, I am concerned that in the event of an accident, the passenger airbag either won't be deployed at all, or may not be deployed correctly and may injure a passenger by deploying too little or too much.

Cabin noise is over the normal threshold creating distraction and discomfort for concentration. Submitted multiple complaints and repair request through car app for diagnostic and possible repair, but nothing has been addressed. I bought a sound level meter to measure the distracted noise and the sound level was measured at 87 dB. Asked Tesla repair center if they can measure the sound level to confirm my complaint, but they are not will to do so. All the complaints were submitted during manufacture warranty period, but nothing has been done and now my car is out of warranty and Tesla wants ti charge me $265 per hour for the diagnostic. What is Tesla’s published or acceptable cabin sound level? The high sound level is now causing my ear to occasionally have ringing and discomfortable feeling.

The cameras used to display the repeater cameras (eg replace the mirrors) and displayed the image on the center console as a safety feature has a defect where light from the blinker leaks into the housing and partially or entirely blinds the camera when the blinker goes off. As this is a safety feature intended to look for cars in a blind spot and the camera gets entirely blinded while the turn signal is on, this is a safety hazard that requires a recall. Tesla says that it is “operating normally” but literally the screen goes bright white and the video of the road disappears so maybe this is normal with the flawed design but is not actually normal to have a defective safety feature. This design flaw was later designed out to avoid light leakage but makes this safety feature completely unusable right when it is supposed to be working (checking for cars when turning including when turn signal is on). Needs a safety recall.