2019 TESLA MODEL 3 Complaints

While driving, the front driver-side suspension collapsed due to a complete detachment of the front lower lateral link. The fastener (bolt) backed out entirely and fell onto the road/under-shield. This matches the failure mode described in NHTSA Recall 21V-835, although Tesla has previously claimed my specific VIN was not included. The failure caused an immediate loss of steering control and structural instability. I am reporting this as a potential 'recall bypass' where the defect exists outside the currently identified recall population

The contact owns a 2019 Tesla Model 3. The contact stated that while the vehicle was parked, the rearview camera became inoperable while opening the trunk. The message “Camera Not Available” was displayed. The contact stated that the rearview camera functionality returned after opening and closing the trunk several times. The vehicle was taken to the dealer, where it was determined that the rearview camera wiring harness had failed and needed to be replaced. The vehicle was not repaired. The contact informed the dealer that the vehicle had previously been associated with a recall related to the failure; however, the dealer did not repair the vehicle under the recall. The manufacturer was made aware of the failure. The approximate failure mileage was 81,952.

At approximately 30,000 miles, the front left suspension lateral link/control arm separated while driving due to a missing mounting fastener (bolt), resulting in sudden steering instability and abnormal front wheel movement. Vehicle handling became unpredictable and felt unsafe to control, creating risk of loss of steering control. I stopped driving immediately. There was no collision, curb strike, pothole, or road hazard at the time of the incident. No warning lights or messages appeared prior to the failure; it occurred suddenly without advance notice. Tesla Service inspected and confirmed the separation and missing fastener. Suspension components and the front subframe assembly were replaced —$4,400 out of pocket. Tesla documented they could not make a formal cause determination. The recovered bolt is intact and available for inspection upon request. Insurance also reviewed the incident and classified it as mechanical rather than collision-related. Because this involves a safety-critical steering/suspension fastener failure without warning, I am submitting this report for safety tracking. I am aware of similar owner reports describing suspension fastener or lateral link separation on this vehicle generation in case this reflects a broader pattern.

What component or system failed or malfunctioned, and is it available for inspection upon request? The steering system failed due to corrosion and water ingress affecting both the steering rack and the associated steering wiring harness. These components were replaced by Tesla and are no longer available for inspection. How was your safety or the safety of others put at risk? The steering system is a safety-critical component. Corrosion and water intrusion created a risk of reduced or sudden loss of steering assist while driving, which could lead to loss of vehicle control and increase the risk of a crash. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Tesla service confirmed water ingress and corrosion affecting the steering rack and wiring harness and performed a full replacement of both components. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes. The vehicle and steering components were inspected by Tesla at a Tesla Service Center, which identified water ingress and corrosion as the cause of failure. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The vehicle displayed steering-related warning messages prior to repair, including reduced steering assist alerts, which prompted inspection by Tesla service. The warnings appeared shortly before the repair was performed.

Warranty Alignment: This failure occurred at 47.7k miles, well under the 60,000-mile threshold of the Supplemental Restraint System Limited Warranty. Known Defect: This repair is the subject of a specific Service Bulletin (RCM_a078), confirming it is a known manufacturing issue and not standard wear-and-tear. Safety Criticality: The SRS is a primary safety system. Forcing a customer to pay for a known defect on a life-saving system at such low mileage is inconsistent with Tesla’s safety mission. I have already paid the high invoice to ensure the vehicle was safe to drive. Tesla did not consider the goodwill repair request for known manufacturing defect that puts passenger at risk. Such safety related repair should be part of safety recalls.

System error code RCM_a021 "Front left safety restraint system issue" The wiring under the front seat may be damaged due to the "easy entry" function which raises, lowers and moves the seat backward and forwards for easier entry and exit of the car. Safety restraint system or airbags may be compromised in the event of a collision if wiring or controls are damaged. Warning code RCM_a021 appeared every time the easy entry function was automatically started.

I am reporting a safety defect involving a welded rear subframe component. The welded section snapped under normal driving conditions, and this is a safety-critical structural suspension component. There was no collision, misuse, or accident prior to this failure. The vehicle is currently not safe to drive due to the compromised rear suspension structure. I have included photos showing the snapped weld and overall rear subframe area. This appears to be a premature structural defect, not normal wear. I am requesting that this failure be documented and reviewed as a potential safety defect. Additional Notes: This component is part of the rear suspension and is expected to last the life of the vehicle. The failure created a serious safety hazard, and I am not driving the vehicle. I have scheduled a service appointment, but I am filing this complaint to ensure the defect is officially reported.

After 3 prior repairs 2 of which were recalls of the front suspension, control arms. I was driving when me and my 3 children’s life’s were almost taken. While driving on the expressway immediate loss of control of the car shaking while driving to work, I stopped immediately thank God no cars around next to me to crash into. We called for a ride and walked off the expressway. Immediately car was taken to Tesla where they told me they couldn’t help and come back in a few days. The car was later inspected by Tesla where instantly knew the issue and later the report came back where the lateral links on both sides of the front where completely out of socket, the compliance links bushing completely torn. This is critical failure and breakdown of critical safety components that almost took our life. We had moments before this happened and thank God we made it out before imminent life changing things happened. No warning no alerts in the car at any time.

Brakes failed to stop the car. The car sat at Tesla service center for one month with no action from Tesla.My wife rear ended another car. The air bags deployed. No one was injuryed and the other was not damaged. Both people could have been seriously hurt or killed. Car was finally towed to Classic Collision November 24 by State Farm Insurance for repair. Estimate to be repaired January 8, 2026.

The two bolts that hold the front lower control arm on fell out (driver side). Luckily this happened when we were backing out of the driveway and not at speed. There were no warnings lights, just a loud noise from the wheel when it failed. There is already a recall about this problem for the same year and model of my car, but the dealer is saying my car is not part of the recall. Here is a link to the recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)