2023 TESLA MODEL Y Complaints

The contact owns a 2023 Tesla Model Y. The contact stated while driving at various speeds, there was an abnormal scraping sound from the vehicle. There was no warning light illuminated. Upon inspection, the contact discovered that a bolt was hanging off the front passenger’s side of the suspension. Upon further inspection, the contact discovered that two additional bolts on the bracket were also loosened. The contact was able to tighten the bolt to secure the suspension. The contact called a Tesla Service Center but received no assistance. The manufacturer was not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 49,000.

The back seat latches will not buckle. This just started and had not been an issue until now. The middle and back passenger seat belts do not latch.

Emergency braking and alerting engaged. There were no vehicles or objects in front of my vehicle at the time. The braking was hard enough to engage the ABS and bring the car from 40mph to 5-10 mph, risking a rear end collision if someone was behind me. I have owned the car just over 1 year, this is the first time this has happened. No warnings or other errors appeared before the incident and no errors are present after the incident. Neither the dealer or anyone else has inspected the vehicle. Conditions: Dry, Night (9:50pm) no cruise control or lane keeping functions enabled, no cars or objects were seen in front of the vehicle.

I noticed that the car window glass broke without any external impact, and there are no signs of external damage. I suspect this may have been caused by stress fractures due to improper assembly. From what I understand, stress fractures often occur at the edges without any signs of external impact, which matches this situation. But Tesla service refused to admit this is a flaw of installation and refuse to replace it under the warranty coverage. After exploration, I found there are plenty of similar cases happened on the internet. And some of them were treated as flaw, some not. How Tesla identify this kind of case as flaw or not? They didn't even check my out in person. I cannot accept that!

The contact owns a 2023 Tesla Model Y. The contact received notifications of NHTSA Campaign Numbers: 24V051000 (Electrical System) and 24V554000 (Latches/Locks/Linkages, Electrical System); however, the contact was not able to perform the over the air software updates. The contact called and informed the manufacturer that the current operating system software was out of date. The contact stated that the operating system software version was 2023.44.30.8 and the newest version was 2024.20.3. The manufacturer informed the contact that the operating system was adequate. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

On [XXX] , south of Austin, north of [XXX] , on both directions, there are many turn lanes on either side. These turn lanes fork from either of the two highway lanes and do not have clear lane markings (by design, not due to fading) until the lane width is full. Tesla Autopilot with lane assist will, at multiple times along this route, center the car between the current lane and the emerging turn. Once the lane markings begin , the car will violently jerk back into a lane. Avoidance of these situations requires a takeover. Along this route, this is particularly dangerous on banks, hills, and in traffic (even with max following distance configured) due to reduced visibility of the start of the lane markings. One example of this is at [XXX] , although there are many others along this route in both directions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Tesla Model. The contact stated that whether driving, or while the vehicle was parked, the hood and the trunk of the vehicle occasionally opened independently. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 13,000.

Several times in the last few months I have had extremely hard braking on the highway when using adaptive cruise control (called Autopilot by Tesla). It has happened on a few different highways ([XXX] in Arizona, [XXX] in New Mexico, [XXX] in Colorado) all when going between 65-75 miles per hour. Thankfully, in most cases, there was no one directly behind me or there almost certainly would have been an accident. In one case a colleague of mine was following me and had to slam on the brakes, too, but she avoided an accident by reacting quickly. In all cases the road in front of me was empty of traffic and there was no warning that the brakes were about to be strongly applied. In some cases the car seemed to react to a turn in the highway, or maybe an uphill or downhill section, but it is unclear to me. In all cases the brakes were applied with a lot of force, and in all cases it was pretty scary. This seems like a huge safety issue with the adaptive cruise control of my Tesla Model Y. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This has happened several times and I am unsure what to do to prevent it. I have small children who have various things in the back seats. Sometimes during sudden braking a water bottle or a toy will roll under the drivers seat and under the pedals which makes for a very scary situation. I’ve read online that this has happened to other Tesla owners as well. I hope that there can be a fix for this as currently there is no barrier between the drivers seat and the back seats.

Front left suspension came apart without any collision. Over the course of a couple days, noticed a sound in the suspension when turning the steering wheel to make a 90 degree turn or more. Pulling out of a driveway and hear loud sound and then steering wheel would not move the front left tire. After getting out to inspect what happened, noticed there were two large bolts on the ground and a large piece of the suspension was hanging down under the car and sitting on the ground. There were no warnings prior to this occurring to signal that something was loose or malfunctioning. Luckily I was on a quiet residential road when it happened and was able to get out safely but it would have been extremely dangerous if this happened in a different location.