2003 TOYOTA 4RUNNER Complaints

TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION WHEN THEY DETECTED THAT THE REAR DIFFERENTIAL, REAR LOWER CONTROL ARM AND FRAME WERE SEVERELY CORRODED. ONE OF THE TWO REAR LOWER CONTROL ARMS HAD BECOME SLIGHTLY DETACHED FROM THE VEHICLE. IN ADDITION, THE EMERGENCY BRAKE ALSO EXHIBITED CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.

NEAR THE END OF AUGUST FOUR WARNING LIGHTS CAME ON AT THE SAME TIME IN MY 2003 4RUNNER. THEY WERE THE VSC TRAC, VSC OFF, ABS AND BRAKE. I SCHEDULED AN APPOINTMENT WITH THE LOCAL TOYOTA AUTHORIZED REPAIR SHOP TO DETERMINE AND FIX THE PROBLEM. THEY LOOKED AT THE VEHICLE AND DISCOVERED SIGNIFICANT RUST AND CORROSION ON THE FRAME, REAR AXLE AND ATTACHED PARTS. I HAVE ASKED FOR AN ESTIMATE TO REPAIR, AND THEY ARE UNABLE TO DO SO AS THERE IS SO MUCH RUST, CORROSION, AND LACK OF MATERIAL TO WORK WITH. I AM THE SECOND OWNER OF THIS VEHICLE. THE FIRST OWNER, A FRIEND OF MINE, HAD THE VEHICLE UNDERCOATED THE DAY AFTER PURCHASE, KEPT THE CAR IN A GARAGE, AND WASHED THE VEHICLE FREQUENTLY INCLUDING THE UNDERSIDE. I PURCHASED THE VEHICLE IN FEBRUARY 2007 WITH 13,750 MILES. IT HAS ALSO LIVED IN A GARAGE HERE. AS OF AUGUST 29, 2013, THE DATE OF THE INSPECTION, THE VEHICLE HAD 24,005 MILES. THE EXTERIOR OF THE VEHICLE IS IN PERFECT CONDITION, AND THE INTERIOR IS THE SAME. HOWEVER, THE UNDERSIDE IS A DIFFERENT STORY. I HAVE CONTACTED TOYOTA AND RECEIVED THIS RESPONSE. "THERE ARE NO KNOWN ISSUES OR CURRENT RECALLS RELATING TO BODY AND FRAME RUST ISSUED FOR YOUR VEHICLE...YOUR VEHICLE IS OUT OF WARRANTY, AND WE WOULD BE UNWILLING TO OFFER YOU ANY COMPENSATION FOR ANY REPAIRS TO THE VEHICLE. WHILE WE UNDERSTAND YOUR DISSATISFACTION WITH THIS DECISION, IT DOES REPRESENT TOYOTA'S FINAL POSITION IN THIS MATTER." *TR

I PURCHASED MY VEHICLE IN FEBRUARY OF 2010. I HAVE HAD TO REPLACE BOTH FRONT BRAKE CALIPERS THREE TIMES EACH. I HAD TO HAVE BOTH REAR BRAKE CALIPERS REPLACED TWICE EACH. CURRENTLY MY RIGHT REAR BRAKE CALIPER IS MALFUNCTIONING. ALL OF MY BRAKE CALIPERS HAVE BEEN SEIZING UP AND THE COST TO HAVE THEM REPAIRED IS EXPENSIVE. THIS IS A SERIOUS SAFETY ISSUE ALONG WITH AN EXPENSIVE ONE. I HAVE READ NUMEROUS INTERNET COMPLAINTS ABOUT THIS PARTICULAR VEHICLE EDITION HAVING BRAKE PROBLEMS AND THE COMPANY WILL NOT ADDRESS IT. SOMETHING NEEDS TO BE DONE SUCH AS REDESIGNING THE BRAKE CALIPERS FOR THIS PARTICULAR VEHICLE. THANK YOU. *TR

MY 4RUNNER GOT REAR ENDED ON THE FREEWAY AND DURING THE REPAIR PROCESS I FOUND OUT THAT THE HITCH RECEIVER THAT WAS ORIGINAL INSTALLED (51909-35010) WAS SUPERSEDED TO AN 'IMPROVED' ONE (51909-35011). HOWEVER, WHEN I INSTALLED MY BICYCLE CARRIER, I REALIZED THAT THE UNIVERSAL FOOT WAS STANDING ONE INCH OUT OF THE HITCH RECEIVER CAUSING IT TO VIRULENTLY SHAKE AND BOUNCE AROUND. WHEN INSPECTING THE NEW HITCH RECEIVER MORE CLOSELY, I REALIZED THAT THE HOLE FOR THE HITCH RECEIVER PIN IS NOW ONLY 1.5 INCHES FROM THE END OF THE HITCH AWAY WHILE BEFORE IT WAS 2.5 INCHES. I COMPARED THIS TO OTHER MANUFACTURERS HITCHES (E.G. GMC, CHEVROLET, JEEP, ETC) AND THEY ALL HAVE A 2.5 INCH DISTANCE FROM THE END OF THE RECEIVER TO THE HOLE FOR THE PIN. I CONTACTED TOYOTA TO FIND OUT WHETHER THIS IS THE CORRECT PART AND WHY THEY CHANGED THE DESIGN IN THAT WAY, BUT THEY WERE UNABLE OR UNWILLING TO PROVIDE FURTHER INFORMATION. IN MY OPINION, THE NEW HITCH RECEIVER IS UNSAFE AS IT ALLOWS MORE PLAY OF THE BALL MOUNT AND APPEARS LESS STABLE AS LESS MATERIAL IS AROUND THE HITCH RECEIVER PIN. SINCE I AM UNABLE TO OBTAIN MORE INFORMATION FROM TOYOTA AND TOYOTA IS NOT WILLING TO LOOK FURTHER INTO THIS, IT WOULD BE GREAT IF YOU COULD HAVE A DETAILED LOOK IN THIS ISSUE. BEST REGARDS. *TR

TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE STEERING WHEEL FAILED. THE STEERING WHEEL BECAME HARD TO TURN AND THE VEHICLE WAS TAKEN TO A MECHANIC FOR INSPECTION. THE FAILURE WAS LOCATED AT THE STEERING WHEEL SYSTEM, WHICH FAILED DUE TO SEVERE CORROSION THAT EXPANDED TO THE TRANSMISSION LINES AND THE FRAME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 125,000.

MY 4RUNNER WAS MAKING A FUNNY NOISE, AND THE BRAKES FELT WEIRD. I WAS DUE FOR AN OIL CHANGE, AND THAT'S WHEN I HAD THE MECHANIC AT THE NEWARK TOYOTA WORLD IN NEWARK, DELAWARE, WHICH I ALWAYS USE, CHECK THE BRAKES, AND THAT'S WHEN I WAS TOLD IT WOULD COST APPROXIMATELY $1,200.00. WHICH IS VERY DIFFICULT FOR ME AT THIS TIME TO COME UP WITH SINCE MY HUSBAND HAS BEEN UNEMPLOYED SINCE OCTOBER OF 2012. BUT, I NEED A CAR FOR MY JOB, SO I HAD NO OTHER CHOICE, I CAN'T DRIVE IT WITHOUT BRAKES. *TR

TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65 MPH, THE BRAKES FAILED TO RESPOND TO DECELERATION ATTEMPTS AND THE CONTACT CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE VEHICLE WAS AWAITING DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 93,000.

TL-THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE ENGINE, VSC TRAC AND VSC WARNING INDICATORS ILLUMINATED CONTINUOUSLY ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FIVE TIMES AND TWICE TO AN INDEPENDENT MECHANIC. THE ENGINE 02 SENSORS HAD BEEN REPLACED EVEN TIMES. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE. JS

TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED. THE CONTACT TOOK THE VEHICLE TO A PRIVATE MECHANIC. THE TECHNICIAN STATED THAT THE ENTIRE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 48,000.

MY 2003 4RUNNER WAS BROUGHT IN ON THE ABOVE DATE FOR ROUTINE SERVICE TO FOX TOYOTA, EAST PROVIDENCE, RI. THE SERVICE ADVISOR NOTIFIED ME THAT IN THE PROCESS OF SERVICING THE VEHICLE,THE TECH NOTICED SEVERE FRAME ROT AND BROKEN WELDS ON THE FRAME. THIS CONDITION WAS CONFIRMED BY THE SERVICE ADVISOR. SERVICE ADVISOR THEN SUGGESTED THAT I CALL TOYOTA'S CUSTOMER SERVICE 800 NUMBER SINCE THERE HAVE BEEN RECALLS ON OTHER VEHICLES BASED ON THE SAME FRAME. A SERIES OF CALLS TO TOYOTA HAVE PRODUCED NO RESULT. THEY ARE DENYING ANY RESPONSIBILITY FOR THIS PROBLEM. I AM NOW AFRAID TO BE OPERATING THE VEHICLE, AND TOYOTA IS WASHING THEIR CORPORATE HANDS OF RESPONSIBILITY BEYOND THEIR BASIC FIVE YEAR WARRANTY. *TR