2002 TOYOTA 4RUNNER Complaints

MY 2002 TOYOTA 4RUNNER HAS EXCESSIVE RUST ON THE FRAME TO THE POINT THAT IT HAS BEEN DEEMED BY MY LOCAL TOYOTA DEALERSHIP AS "UNSAFE TO DRIVE." IT ONLY HAS 180,000 MILES ON IT, THE RUST SHOULD NOT BE THIS EXTENSIVE.

MY 2002 TOYOTA 4 RUNNER FAILED MASS STATE INSPECTION DUE TO EMERGENCY BRAKE NOT ENGAGING. I IMMEDIATELY BROUGHT THE VEHICLE TO A LOCAL AUTO SHOP FOR REPAIR. I WAS THEN NOTIFIED BY THE SHOP THAT THE ENTIRE FRAME WAS COMPLETELY ROTTED & UNSAFE TO DRIVE. THEY REFUSED TO DO ANY REPAIR TO THE E-BRAKE UNTIL THE FRAME WAS REPAIRED. I'M DEVASTATED THAT MY WELL CARED FOR VEHICLE , WITH ONLY 130,000 MILES IS NOW UNSAFE TO DRIVE DUE TO FRAME ROT.

REAR SWAYBAR RUSTED FROM FRAME CAUSING 4RUNNER TO WOBBLE EXCESSIVLY ALMOST CAUSING ME TO WRECK. THAT SIDE OF FRAME IS COMPLETELY RUSTED AWAY.

THIS IS YET ANOTHER COSTUMER OF THE 4RUNNER 3RD GENERATION COMPLAINING ABOUT THE FRAME RUSTING OUT. THERE NEEDS TO BE RESPONSABILITY FOR THE BAD FRAMES ON THIS YEAR 4RUNNER. MY FRAME HAS HOLES IN THE REAR CONTROL ARM ATTACHMENT AREA AND MORE RUST ALL THROUGHOUT ENTIRE FRAME. I'M DOING ALL I CAN TO KEEP MY FRAME FROM GETTING ANY MORE RUST ON IT AND KEEPING IT SAFE TO BE ON THE ROAD. I STRONGLY BELIEVE TOYOTA SHOULD ALSO HAVE A FRAME RECALL FOR THE 4RUNNER LIKE IT DID FOR THE TUNDRA TACOMA AND SEQUOIA FRAMES.

TL* THE CONTACT OWNS A 2002 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE SERVICE AT AN INDEPENDENT MECHANIC SHOP, THE TECHNICIAN NOTICED THAT THE FRAME WAS CORRODED THROUGH AND CAUSED THE TAILPIPE TO DETACH. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 168,000. ..*BF *JB

I HAVE A 2002 4 RUNNER AND PUT ALMOST $2,800.00 IN IT LAST YEAR FOR A NEW REAR END, NEW TIRES, BECAUSE I FELT IT STILL HAD A TREMENDOUS AMOUNT OF LIFE LEFT IN IT, ONLY TO FIND OUT THAT THE FRAME HAS 2 HOLES IN IT FROM EXCESSIVE RUST. THE DEALERSHIP I TOOK IT TO INFORMED ME THAT THEY WERE CURRENTLY IN THE PROCESS OF REPLACING FRAMES FOR 2003 - 2009 MODELS. WHEN I ASKED ABOUT THE 2002 MODELS, THEY STATED THAT TOYOTA DOES NOT ASSUME RESPONSIBILITY FOR THE 4 RUNNERS. MY QUESTION IS "HOW DO I FIND OUT IF THE 2002 FRAMES WERE MANUFACTURED WITH THE SAME MATERIALS THAT THE 2003 MODELS WERE MADE OF?" I REALLY WANTED TO HAND THIS CAR DOWN TO MY DAUGHTER. SHE NEEDS A CAR AND WITH THE CURRENT SITUATION OF THE FRAME, THERE IS NO WAY I CAN LET HER DRIVE THIS IN ITS CURRENT CONDITION. PLEASE HELP!!!

CHECK ENGINE LIGHT COMES ON SO I TAKE MY 2002 4 RUNNER TO GET IT CHECKED. I NOTICED IT SOUNDS LIKE IT MIGHT BE A EXHAUST PROBLEM. THEN I GET THE BAD NEWS . THE FRAME EXPERIENCE EXCESSIVE CORROSION. MY UNDERSTANDING IS THAT THERE WAS SOME KIND OF RECALL ON THIS MATTER A FEW YEARS AGO BUT I NEVER RECEIVED A NOTICE .I PURCHASED IT USED IN 2003 SO MAYBE THE NOTICE WENT TO THE FIRST OWNER. I HAVE BEEN LIVING AT THE SAME ADDRESS SINCE I OWNED IT.

REAR AXEL IS RUSTED OFF THE FRAME, AND ROTTING, MECHANIC SAYS IT'S UNSAFE TO DRIVE

LEAVING WORK FRIDAY OF LABOR DAY WEEKEND 2018 I NOTICED THE SMELL OF GAS. MY CO-WORKER ALSO LOOKED, AND OBSERVED A PUDDLE OF GASOLINE UNDER THE CAR. SINCE THE DEALER WAS CLOSE, I TOOK THE RISK TO DRIVE IT THE DEALER. THE DEALER IS HERITAGE TOYOTA IN BALTIMORE MARYLAND. THE CAR HAS ONLY 91000 MILES ON IT. THE ENTIRE BOTTOM OF THE CAR IS RUSTED OUT. THIS IS WHAT CAUSED THE FUEL LEAK. THE FRAME IS ALSO RUSTED OUT TO THE POINT OF NOT BEING SAFE ANYMORE. MY COMPLAINTS ARE THESE: 1. THE UNDERSIDE OF THE CAR COMPLETELY RUSTED OUT. 2. OTHER TOYOTA TRUCKS OF THE SAME YEAR ARE HAVING THEIR FRAMES REPLACED BY TOYOTA. 3. MY TOYOTA WAS SERVICED WITH ME LETTING THE DEALER DO "ANYTHING IT NEEDS". I ESTIMATE SPENDING ABOUT $15,000 AT THIS DEALER. NEVER ONCE WAS I TOLD THERE WAS A RUST PROBLEM. WITH MOUNTING REPAIRED COSTS, I TOOK IT TO ANOTHER MECHANIC WHO IMMEDIATELY RECOMMENDED THAT I TAKE THE CAR TO THE DEALER FOR ASSESSMENT. NEVER DID THE TOYOTA DEALER WARN ME ABOUT THE RUST. 4. TOYOTA WAS COMPLETELY UNINTERESTED IN HELPING. I DID FILE A COMPLAINT #1808271490

MY FRAME IS SUFFERING FROM PREMATURE AND EXCESSIVE RUSTING, AS IS COMMONLY REPORTED AMONG OTHER EARLY TO MID 2000'S 4RUNNER OWNERS. THE MOST SEVERE AREA IS THE RADIATOR SUPPORTS. I AM FILING THIS COMPLAINT SO IT IS REGISTERED AMONG THE MANY COMPLAINTS RECEIVED ABOUT THIS ISSUE. I'D BE HAPPY TO PROVIDE DOCUMENTATION IF NEEDED, BUT I'M PRETTY SURE THERE HAVE ALREADY BEEN A LOT OF REPORTS OF THIS SINCE THERE'S NOW AN INVESTIGATION INTO THE ISSUE.