1997 TOYOTA CAMRY Complaints

1997 TOYOTA CAMRY CAUGHT ON FIRE WHILE DRIVING ON I-87. FIRE BEGAN SOMEWHERE UNDER THE FRONT HOOD OF THE VEHICLE. BRAKES FAILED WHILE MOVING TO HIGHWAY SHOULDER. PASSENGERS WERE IMMEDIATELY EVACUATED AND THE FIRE DEPARTMENT WAS CALLED TO PUT OUT THE FIRE. THE CAR WAS COMPLETELY DESTROYED BY THE FIRE. *JB

WHILE DRIVING HOME, HEARD CLANGING NOISE AND CAR LOST POWER - CAR WOULD NOT START. HAD CAR TOWED TO TOYOTA DEALER. UPON EXAMINATION THE FOLLOWING WAS FOUND: "#3 PISTON ROD BROKEN COMING THROUGH BLOCK" - THERE WAS A HOLE IN THE BLOCK. THE DEALER REPLACED SHORT BLOCK, OIL PUMP, BALANCED SHAFT & REPLACED NECESSARY FLUIDS. TOYOTA REPLACED THE ENGINE, HOWEVER, I INCURRED $1,560 IN LABOR. *JB

THERE IS A SIGNIFICANT AMOUNT OF "PLAY" AND "BODY ROLL" WITH RESPECT TO THE STEERING COMPONENTS/STEERING WHEEL OF THE VEHICLE. THIS HAS EXISTED FROM DATE OF PURCHASE. ADDITIONALLY, THE BRAKING SYSTEM IS NOT AS RESPONSIVE AS THAT WHICH I HAVE EXPERIENCED IN ALL OTHER VEHICLES. THE DEPTH WHICH THE BRAKE PEDAL MUST BE DEPRESSED IS MUCH DEEPER AND REQUIRES A GREATER AMOUNT OF PRESSURE, THAN THAT OF ANY OTHER VEHICLE I HAVE DRIVEN. FINALLY, THE HEADLIGHTS PROVIDE POOR VISIBILITY BOTH IN THE AMOUNT OF LIGHT EMITTED AND IN THEIR LOW MOUNTING OR ANGLE WHICH THEY SIT AT. THANK YOU FOR YOUR TIME AND EFFORTS ON MY BEHALF. BEST REGARDS. *JB

CAR : 97 TOYOTA CAMRY LE 4 CYLINDER THREE MAJOR PROBLEMS 1) BLUE SMOKE AT COLD-STARTING (MILEAGE: 87 MILES -AUG. 2001) ENGINE GAVE OFF BLUE SMOKE FROM THE EXHAUST WHEN COLD-STARTING IN THE MORNING. AFTER REPLACING VALVE STEM SEALS (PAID AROUND $1000 TO A TOYOTA DEALER FOR THE REPAIR), THE PROBLEM WAS SOLVED. 2) POWER STEERING RACK & PINION LEAKING (MILEAGE: 87KMILES -AUG. 2001) POWER STEERING RACK & PINION LEAKED AND A MECHANIC REPLACED IT WITH A NEW ONE. 3) EGR VSV FAILURE (MILEAGE: 100 KMILES -OCT. 2004) CHECK ENGINE LIGHT CAME ON. OBD II SCANNER SAYS "INSUFFICIENT EGR FLOW." A MECHANIC REPLACED EGR VSV AND THE PROBLEM WAS SOLVED. 4) FRONT STRUT MOUNTS FAILURE ((MILEAGE: 87 KMILES -AUG. 2001) BOTH FRONT STRUT MOUNTS MADE NOISE. AFTER A TOYOTA DEALER REPLACED IT, THE PROBLEM WAS SOLVED. *JB

DT: WHILE DRIVING THE VEHICLE THREW A ROD THROUGH THE ENGINE AND DESTROYED IT. THIS OCCURRED ON AUGUST 31, 2005. THE CONSUMER HAD THE VEHICLE TOWED TO A MECHANIC, WHO TOLD HIM THAT IT WAS THE PISTON ROD THAT CAME LOOSE. NO ONE WAS INJURED. THEY WERE NOT HAVING THE VEHICLE REPAIRED. WHEN THE CONSUMER CONTACTED THE MANUFACTURER, THEY TOLD HIM THAT THEY WOULD NOT COVER THE DAMAGE. *AK 11/02/05. *JB

I OWN A 1997 TOYOTA CAMRY WITH 194,000 MILES. LAST WEEK IT CAUGHT ON FIRE. I PULLED INTO THE OFFICE PARKING LOT AND TURNED OFF THE IGNITION AND REMOVED THE KEY. THE STARTER CONTINUED TO TRY TO START THE CAR. I TRIED TO STALL IT OUT BY LETTING OUT THE CLUTCH, BUT IT JUST CONTINUED TO TRY TO START. I THEN PUT THE KEY BACK IN TURNED ON THE IGNITION AND PUT IT IN NEUTRAL. I THEN RAN INTO THE OFFICE TO GET A TOOL TO DISCONNECT THE BATTERY. WHEN THE BATTERY WAS DISCONNECTED THE STARTER QUIT, BUT BY THEN THE SOLENOID WAS SO OVERHEATED IT STARTED TO SMOKE AND BURN. LUCKILY WE HAD A FIRE EXTINGUISHER ON HAND. THE DEALER HAS ONLY SAID THAT THEY NEED TO REPLACE THE STARTER. I THOUGHT VEHICLES HAD A FAIL SAFE MEASURE THAT WOULD TERMINATE THE POWER SUPPLY TO THE STARTER ONCE THE IGNITION WAS TURNED OFF AND THE KEY REMOVED. *NM

MY CHEK ENIGNE LIGHT CAME ON WHEN I WAS HEADED OUT FOR A 250 MILE TRIP. I TOOK IT TO THE DEALER AND GOT THEIS LIST OF PROBLEMS. TIMING BELT REPLACMENT,WATER PUMP, RESEAL OIL PAN, REPLACE ENGINE PIPE, TRANSMISSION GASKET AND FILTER REPLACEMENT OXYGEN SENSOR, A/F SENSOR, EFI SERVICE, CAM SEAL, CRANK SEAL, OIL PUMP SEAL . BLUE SMOKE COMING FROM EXHAUST. I WENT ON LINE AND REALIZED THAT I HAD OIL SLUDGE. CALLED TOYAOTA, THEY TOLD ME TO GET IT EVALUATED FOR OIL SLUDGE

IN JULY, 2003 (PLEASE REFER TO ODI ID NUMBER: 10030262) OUR 1997 TOYOTA CAMRY CE (MANUAL TRANSMISSION) BEGAN LEAKING LARGE AMOUNTS OF GASOLINE. IT WAS DETERMINED INTERNAL PRESSURE HAD CAUSED THE TANK TO BULGE OUT AND RIP AT THE SEAMS. AFTER TWO SOLDERING ATTEMPTS WERE MADE TO PATCH THE TANK, THE ENTIRE TANK WAS REPLACED WITH A NEW ONE. A PRESSURE TEST WAS CONDUCTED BUT NO PROBLEMS WERE FOUND. IN FEBRUARY 2005 THE GAS TANK STARTED LEAKING AGAIN. THE SAME BULGE FROM INSIDE OUT WAS FOUND AS HAD PREVIOUSLY BEEN SEEN WITH THE OLD AND SINCE REPLACED TANK. THE TANK WAS REMOVED & SENT OUT FOR WELDING, RETURNED AND TESTS WERE CONDUCTED ON THE CHARCOAL FILTER & VACUUM SWITCH. BOTH TESTED FINE. THE VACUUM SWITCH WAS REPLACED AS THE COST OF REPLACING THE CHARCOAL FILTER WAS TOO EXPENSIVE AND SINCE IT DIDN'T SHOW FAILURE, IT DIDN'T APPEAR TO BE NECESSARY. THE MECHANIC SUGGESTED PERIODIC TESTS IN CASE THE PROBLEM WAS INTERMITTENT. ALSO, THE HEAT DISTRIBUTOR (I BELIEVE THAT'S THE NAME FOR THE METAL BETWEEN THE EXHAUST PIPE & THE GAS TANK TO KEEP THE TANK FROM OVERHEATING & EXPLODING) WAS FOUND TO HAVE BEEN "WRINKLED" BUT FROM THE PRESSURE OF THE IN-OUT EXPANSION OF THE TANK, NOT FROM AN OUT-IN PUSH THAT WOULD HAVE BEEN CAUSED FROM DRIVING OVER SOMETHING. *AK LESS THAN TWO WEEKS LATER, THE GAS LEAK RETURNED. TOYOTA WAS CONTACTED AND WE WERE REFERRED TO THE LOCAL DEALERSHIP CUSTOMER SERVICE MANAGER. THE CSM COORDINATED WITH THE SERVICE DEPARTMENT TO HAVE THE CAR PUT UP ON THE RACK AND LOOKED AT. THREE INDIVIDUALS, INCLUDING THE CSM DECLARED IT WAS AN "EXTERNAL LEAK FROM THE PATCH" AND FELT IT WAS NOTHING THEY WERE WILLING TO INVESTIGATE FURTHER. THEY DID SUGGEST REPLACING THE TANK AND DOING FURTHER INVESTIGATIONS TO ATTEMPT TO DUPLICATE THE PROCESS, HOWEVER, THE EXPENSES ARE SO EXTRAORDINARY, WE HAVE OPTED TO REPLACE THE TANK WITH A USED ONE AND LOOK AT OTHER REPLACEMENT VEHICLE OPTIONS, POSSIBLY SELLING PARTS OR TOWING TO A JUNK YARD.

THERE IS A SERIOUS PROBLEM WITH THE BRAKES ON THE 1997 TOYOTA CAMRY. THE BRAKES ON THE VEHICLE DOES NOT LAST FOR MORE THAN THREE MONTHS, AND LESS. *AK

OWNER WAS DRIVING ON THE FREEWAY AT APPROXIMATELY 60 MPH AND WHILE TRYING TO AVOID HITTING A VEHICLE, OWNER REAR ENDED ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. PROVIDE FURTHER DETAILS.