2003 TOYOTA HIGHLANDER Complaints

2003 V6 AWD TOYOTA HIGHLANDER FRONT TO REAR DRIVE SHAFT FAILURE (PROPELLER SHAFT). *TR

FAULTY ELECTRONIC COMPUTER MODULE ON 2003 TOYOTA HIGHLANDER THROWS MULTIPLE ERROR CODES TO INDICATE A NUMBER OF PROBLEMS WITH EMISSION COMPONENTS. ERROR CODES CALL OUT OXYGEN SENSORS, (THERE IS FOUR SENSORS ON 2003 (4) CYLINDER HIGHLANDERS). FIX ONE SENSOR AND ANOTHER POPS UP BAD ACCORDING TO THE ERROR CODES. ANOTHER $400 REPAIR BILL ! TOYOTA WILL REPLACE THE MODULE ON CARS WITH WARRANTY, NO PROBLEM. HOWEVER, THEY DENY THERE IS ANY PROBLEMS WITH THE MODULE WHEN NO WARRANTY IS INVOLVED. CODES AT TIMES ALSO SHOW A FAULTY CATALYTIC CONVERTER ($1000 REPAIR BILL ). IF YOU VISIT THE TOYOTA NATION WEB SITE YOU WILL SEE MANY REPORTS OF THE COMPONENT AT ISSUE. THIS IS ON THE SAME VEHICLES AS THE ONE I OWN. SOME PEOPLE HAVE REPORTED TOYOTA CHARGES UNSUSPECTING CUSTOMERS $1600 TO REPAIR THESE FOUR SENSORS. ( NOT MY WORDS, TAKEN OFF THE TOYOTA NATION FORUMS). PLEASE DEMAND TOYOTA REPLACE THE MODULES ON THESE VEHICLES. THANK YOU ! *TR

THE VEHICLE WAS BEING OPERATED AT ABOUT 30 MPH WHEN IT SUDDENLY VEERED TO THE LEFT AND CRASHING INTO A LARGE BOULDER. THE POLICE REPORT SUGGESTED IT WAS A MECHANICAL FAILURE. I ASKED TOYOTA TO DO A FORENSIC EXAMINATION OF THE VEHICLE TO AVOID A SIMILAR OCCURRENCE ON OTHER VEHICLES AS A SIMILAR INCIDENT AT HIGHWAY SPEED MIGHT HAVE HAD VERY SERIOUS RESULTS. TOYOTA ADVISED THAT THEY INSPECTED THE VEHICLE AND "DETERMINED THAT ALL DAMAGE TO THE VEHICLE WAS THE RESULT OF IMPACT AND NOT THE RESULT OF ANY MANUFACTURING DEFECT." *TR

MY 2003 HIGHLANDER HAS AN ISSUE WITH THE DRIVER SIDE SUNVISOR. DURING MOVEMENT OF THE CAR IT'S CONSTANTLY FALLING DOWN INTO MY LINE OF VISION DURING DRIVING. IT STARTED FALLING DOWN ONLY OCASSIONALLY OVER SPEED BUMPS AND NOW IT JUST FALLS DOWN ALMOST EVER FEW MINUTES WHILE DRIVING. I TRIED TO GET THE LOCAL TOYOTA DEALERSHIP TO REPACE THE VISOR UNDER MY EXTENDED WARRANTY BUT WAS TOLD THAT IT WAS NOT COVERED BY IT. AFTER READING MANY POSTINGS ON THE WEB IT SEEMS THAT MANY TOYOTA HIGHLANDER OWNERS HAVE THIS SAME PROBLEM. MY VISOR HAS BUILT IN ELECTRICAL PARTS ON IT THAT ARE SUPPOSED TO CONTROL A GARAGE DOOR, HOUSE LIGHTS, ETC. IN WHICH TOYOTA SAY IS A "HOME CENTER CONTROL" - I HAVE NOT PUT ANYTHING ON THE VISOR TO MAKE IT ANY HEAVIER THAN HOW THE FACTORY PRODUCED IT. THE VISOR IS TOO HEAVY AND IT CAN NOT BE SUPPORTED BY THE METAL PART THAT CONNECTS IT TO THE ROOF OF THE CAR. THE LOCAL DEALERSHIP GAVE NO SOLUTION OTHER THAN TO REPLACE THE VISOR AT MY COST BUT I HAVE READ OTHER PEOPLES POSTS SAYING THAT THE ISSUE WILL ONLY HAPPEN AGAIN. THEY INFORMED ME THE PART ALONE IS $800 WITHOUT INSTALLATION. I THOUGHT THAT MAYBE VELCRO WOULD WORK SO I TRIED TO VELCRO THE VISOR TO THE ROOF OF MY CAR BUT UNFORTUNATELY THE VELCOR IS NOT STRONG ENOUGH TO HOLD THE VISOR TO THE ROOF AND DURING THE SUMMER THE GLUE MELTS AND DOESN'T ALLOW THE VELCRO TO STICK TO THE ROOF THUS I CAN NOT KEEP THE VISOR UP. THIS ISSUE STARTED ABOUT 2007 AND PROGRESSIVELY GOT WORSE AND NOW THE VISOR WILL NOT STAY UP MORE THAN A COUPLE OF MINUTES - ESPECIALLY IN THE SUMMER. FIRSTLY THE VISOR ITSELF IS DISTRACTION, SECONDLY ONCE IT'S DOWN IT BLOCKS A PORTION OF THE DRIVER'S VIEW, AND THIRDLY IT'S A DISTRACTION TO HAVE TO USE ONE HAND TO PUT THE VISOR BACK UP. YOU CAN NOT EVEN TRY TO MOVE IT TO THE SIDE AS IT'S STILL TOO LOW TO SEE OUT THE DRIVER SIDE WINDOW AND ALSO THER ARE NO ACCESSIBLE SCREWS TO REMOVE THE VISOR MYSELF. ALL IN ALL THIS ISSUE IS A HUGE HAZARD AND SHOULD BE CORRECTED BY TOYOTA.

MY COMPLAINT CENTERS AROUND THE THROTTLE POSITION SENSOR ON THE TOYOTA HIGHLANDER. THIS PROBLEM HAS BECOME MORE APPARENT WITHIN THE LAST YEAR ON THE 2003 MODEL THAT MY WIFE AND I OWN. *TW

)N THE MORNING OF 12-05-09, AS I'M PULLING INTO MY GARAGE, THE CAR SUDDENLY LURCHED FORWARD WITH AN UNEXPECTED INCREASE IN SPEED. BEFORE I COULD BRAKE, THE CAR SLAMMED INTO A STEEL SHELVING UNIT ON THE BACK WALL WHICH RESULTED IN EXTENSIVE DAMAGE TO THE WALL ( BOTH INTERIOR & EXTERIOR) AND WHAT APPEARED TO BE MINIMAL DAMAGE TO THE AUTO. I TOOK THE VEHICLE TO MY TOYOTA SERVICE ON THAT SAME DAY BECAUSE I/WE FELT THAT THIS COULD CONSTITUTE AN UNSAFE DRIVING CONDITION. TOTAL COSTS FROM THIS INCIDENT WERE AS FOLLOWS: COVERED BY INSURANCE- $3607.81 (PLUS 703.31 PD. DIRECTLY TO THE DEALER?) AND $916.27 ( 500.00 INSURANCE DEDUCTIBLE AND AN ADDITIONAL MECHANICAL CHARGE FOR A FUEL/AIR SENSOR THAT FAILED ON 12-26-09). I HAVE NOT PREVIOUSLY EXPERIENCED "SUDDEN ACCELERATION" WITH THIS VEHICLE. I HAVE NOTIFIED BOTH MY LOCAL DEALER, SOUTHEAST TOYOTA DISTRIBUTORS AND TOYOTA CUSTOMER RELATIONS REGARDING THE PROBLEM STATING THAT THERE MAY BE OTHER VEHICLES BEYOND THE SCOPE OF THEIR CURRENT RECALL THAT SHOULD ALSO BE CONSIDERED AS POTENTIALLY DANGEROUS. *TR UPDATED 05/03.10 TOYOTA DENIED THE CONSUMER CLAIM, STATING THE VEHICLE EXAMINATION REVEALED NO APPARENT REASON FOR THE ACCELERATION. HOWEVER, THE DEALER THAT PERFORMED THE INSPECTION STATED THE THROTTLE WAS BECAME STUCK DUE TO GUMMY DEPOSITS CASED BY ETHANOL IN THE GASOLINE. UPDATED 08/210/10*JB

I ROUTINELY HAVE DIFFICULTY WITH MY BRAKES ON MY 2003 TOYOTA HIGHLANDER. I BROUGHT THE CAR TO THE DEALER SEVERAL TIMES AND THEY WERE NEVER ABLE TO REPRODUCE THE PROBLEM. JUST RECENTLY I DISCOVERED THAT THE PROBLEM IS CUASED BY MY "BIG FEET" - I AM A SIZE 14. IF MY FOOT IS STRAIGHT UP AND DOWN THE TOP OF MY SHOE OR BOOT RESTS AGAINST THE METAL BRACKET AND I LOSE ALL THE LEVERAGE ON THE BRAKE. IN ESSENCE - I HAVE TO STAND ON THE BRAKE TO MAKE THE CAR STOP. I NOW TRY TO REMEMBER TO KEEP MY FOOT TILTED TO THE SIDE SO THAT I ONLY PUSH ON THE RUBBER PAD OF THE BRAKE PEDAL. I DON'T BELIEVE THAT I SHOULD ALTER HOW I APPLY THE BRAKES TO GET THEM TO WORK. THE BRAKE PEDAL DESIGN NEEDS TO BE CHANGED. AT LEAST TWICE I HAVE HAD NEAR ACCIDENTS WHEN I HAD TO STOP SUDDENLY AND MY REFLEX WAS TO BRAKE NORAMLLY - NOT TILT MY FOOT TO THE SIDE. I ENTERED THE LAST DATE THIS OCCURED. *TR

ON MONDAY, APRIL 28, 2008 AT APPROXIMATELY 7:45 A.M. CDT, I DROVE MY 2003 TOYOTA HIGHLANDER ON TO THE EMPLOYEE PARKING LOT AT UNIGROUP, INC. AS I ALWAYS DID, I PULLED UP PAST MY ASSIGNED PARKING SPOT, STOPPED, AND PUT THE VEHICLE IN REVERSE TO BACK INTO MY SPACE. WHEN I MOVED MY FOOT FROM THE BRAKE TO THE ACCELERATOR AND TURNED THE STEERING WHEEL TO BACK INTO SPACE 304, THE SUV SUDDENLY ACCELERATED AT A TREMENDOUS SPEED, HIT AND BOUNCED OFF THE FORD EXPLORER PARKED IN SPACE 305 AND THEN HIT THE SUBARU LEGACY WAGON PARKED IN SPACE 317 IMMEDIATELY BEHIND SPACE 304. ONE WITNESS WHO WAS IN THE PARKING LOT AT THE TIME LATER TOLD ME THAT WHILE HE DID NOT SEE THE CRASH, HE HEARD A HUGE ROAR OF A MOTOR AND THE CRASHING NOISE OF THE IMPACT. THE OWNER OF THE SUBARU ALSO DID NOT SEE THE INITIAL ACCELERATION OF THE SUV, BUT HEARD THE TIRES SCREECHING AND TURNED IN TIME TO SEE MY SUV HIT HIS SUBARU. BOTH OF THE TWO WITNESSES HELPED ME LOAD THE BACK BUMPER OF MY HIGHLANDER INTO THE CARGO AREA. PRIOR TO GOING INTO THE OFFICE, I CHECKED THE FLOOR MAT UNDER THE STEERING WHEEL, BUT COULD NOT SEE ANY INDICATION THAT IT IN ANY WAY HAD MOVED. I AM CONVINCED THAT THE ONLY THING THAT STOPPED MY HIGHLANDER WAS THE FACT THAT IT HIT THE TWO VEHICLES IN SPACES 305 AND 317. LATER THAT DAY (4.28.2008), I CALLED TOYOTA TO REPORT THE INCIDENT. I WAS TOLD BY A REPRESENTATIVE BY THE NAME OF BARBARA THAT THERE WERE NO PROBLEMS OR RECALLS ON THE HIGHLANDER, ONLY THE CAMRY (THIS ACCORDING TO THE NHTSA.) MY REPORT WAS GIVEN . THERE WAS EXTENSIVE DAMAGE TO MY SUV AND THE TWO OTHER VEHICLES THAT WERE HIT. THUS FAR, TOYOTA HAS NOT ACKNOWLEDGED THAT MY VEHICLE (2003 HIGHLANDER) IS INCLUDED IN THE RECALL AND SINCE THE VIN # BEGINS WITH A J, I AM TOLD THAT THERE IS NO PROBLEM WITH ANY VEHICLE MADE IN JAPAN. THEREFORE, I CANNOT EVEN TAKE IT TO A DEALERSHIP FOR REPAIRS. I AM LEFT IN LIMBO WITH A DEFECTIVE TOYOTA. *TR

2003 TOYOTA HIGHLANDER, I HAVE A RANDOMLY OCCURRING PROBLEM WITH THE GAS PEDAL STICKING WHEN YOU ARE TRYING TO ACCELERATE FROM A STOP. MY YEAR MODEL IS NOT INCLUDED IN THE CURRENT RECALL BUT I WANTED TO MAKE YOU AWARE THAT THERE ARE OTHER POSSIBLE PROBLEMS OUT THERE. I HAVE CALLED THE DEALERSHIP AND THEY SAID WITHOUT BEING ABLE TO DUPLICATE THE PROBLEM THERE IS NOTHING THAT I CAN DO AND IT IS RANDOMLY OCCURRING. *TR

2003 TOYOTA HIGHLANDER UNCONTROLLED SURGE IN ACCELERATION. CONSUMER STATES THERE WAS LIMITED TO NO USE WHEN THE BRAKE PEDAL WAS DEPRESSED. *KB THE CONSUMER STATED THE FLOOR MAT PLAYED ABSOLUTELY NO ROLE IN THE SUDDEN ACCELERATION INCIDENT. THE TRUCK WAS TAKEN TO THE DEALER WHERE THEY REPLACED NUMEROUS PARTS, BUT COULD NOT EXPLAIN THE CAUSE. *JB