2016 TOYOTA PRIUS Complaints

WHILE AT HIGHWAY SPEEDS I WAS STRUCK BY A ROCK. WINDSHIELD CRACKED. HAD TO HAVE IT REPLACED. COSTLY AND NOW I AM TOLD IT WILL COST ANOTHER $400+ TO HAVE IT CALIBRATED. I AM NOW READING THAT THE PRIUS IS PRONE TO WINDSHIELD BREAKS AND THE COST OF RECALIBRATION IS BOTH EXPENSIVE AND THE DEALERS DON'T LIKE DOING IT SO THE TIME TO GET IT DONE IS EXCESSIVE. I NOW WORRY IF SAFETY FEATURES ARE COMPROMISED AND IT IS DANGEROUS TO DRIVE.

FEBRUARY 7, 2018 !01 FRWY NORTH APPROACHING SANTA ROSA/ PLEASANT VALLEY OFF RAMP ON THE DOWNGRADE OUT OF NEWBURY PARK AT 25 MPH IN THE RIGHT LANE. A.BRAKE LIGHTS ARE SEEN IN CAR AHEAD. B.THE DASH BOARD LIGHTS UP RED WITH THE WORD BRAKE IN RED C.A LOUD PULSATING AUDIO NOISE CAN BE HEARD COMING FROM THE SPEAKERS. D.THE DRIVER TOUCHES THE BRAKES AND THE CAR GOES INTO FULL ABS EMERGENCY BRAKING REDUCING SPEED FROM 25 MPH TO 12 MPH IN LESS THAN 1/2 SECOND E.THE DRIVER AND THE PASSENGERS EXPERIENCE A VIOLENT LURCH WHICH PRODUCES WHIP LASH. F.THE SEAT BELTS ENGAGE CAUSING PAIN TO THE SHOULDERS. G.THE INCIDENT OCCURRED AT 25 MPH. THIS HAS OCCURRED OVER 6 TIMES IN THE PAST YEAR. A PDF IS ATTACHED OF THE HISTORY OF PROBLEM AS PRESENTED TO THOUSAND OAKS TOYOTA AND TOYOTA NATIONAL IN NOVEMBER 2017. VIDEO CAMERAS WERE INSTALLED IN THE CAR IN DECEMBER 2017 TO CAPTURE THIS AS THOUSAND OAKS TOYOTA AND TOYOTA NATIONAL SAID THIS NEVER HAPPENED. HERE ARE THE LINKS TO THE VIDEO OF THE ABOVE INCIDENT: ACCIDENT STARTS AT 30 SECONDS HTTPS://VIMEO.COM/254847752 HTTPS://YOUTU.BE/62AO8Z0IGDY [XXX] - DRIVER [XXX] - PASSENGER FRONT SEAT [XXX] - PASSENGER REAR LEFT SEAT CAMERA 1 MOUNTED IN BACK CEILING CAMERA 2 MOUNTED ON CONSOLE INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

OVER THE PAST YEAR AND OVER 15,000 MILES OUR 2016 TOYOTA PRIUS FOUR TOURING HAS EXPERIENCED SUDDEN DISPLAYS OF WARNING MESSAGES AND LIGHTS REPORTING BRAKING POWER LOW - VISIT YOUR DEALER; BRAKING POWER LOW - STOP IN A SAFE PLACE - SEE OWNER'S MANUAL; PRE-COLLISION SYSTEM MALFUNCTION - VISIT YOUR DEALER; ANTI-LOCK BRAKE SYSTEM MALFUNCTION - VISIT YOUR DEALER; LANE DEPARTURE ALERT MALFUNCTION - VISIT YOUR DEALER; ICS MALFUNCTION - VISIT YOUR DEALER; CHECK CRUISE CONTROL SYSTEM - VISIT YOUR DEALER. THE FOLLOWING CODES/FAULTS HAVE BEEN DETECTED: ABS - C1403, C1407, C1415; PARKING SENSORS - C164D, C1A50; BLIND SPOT MONITOR - C1A45; BLIND SPOT MONITOR SLAVE - C1A45; PRE-COLLISION SYSTEM 2 - C1A50; LANE-KEEPING ASSIST 2 - C1A50; ECU - P157800 & CRUISE ECU - P157800. THE WARNING MESSAGES/LIGHTS CAME AND WENT WHILE DRIVING ON BOTH CITY STREETS AND HIGHWAYS. EACH TIME I TOOK THE VEHICLE TO THE DEALER. THEY COULD SEE THE CODES IN MEMORY, BUT COULD NOT REPLICATE THE PROBLEM. NO PARTS WERE REPLACED. THE ONLY THING THEY HAVE DONE IS TO TAKE APART AND RESEAT SOME OF THE CONNECTOR CABLES AND THEN SEND US ON OUR WAY TELLING US TO BRING IT BACK IN IF IT HAPPENS AGAIN. WE ARE SERIOUSLY CONCERNED ABOUT THE SAFETY OF THIS VEHICLE AND HAVE NO REASSURANCE THAT THE PROBLEM HAS BEEN RESOLVED AND NO REASSURANCE THAT MAJOR BRAKING SYSTEMS MIGHT NOT BE AVAILABLE TO ME IF IT OCCURS AGAIN. I CONTACTED TOYOTA CUSTOMER ASSISTANCE WITH NO CHANGE IN THEIR POSITION. I AM CURRENTLY NEGOTIATING TO TRADE THE VEHICLE IN AS I AM NOT COMFORTABLE THAT THE PROBLEM IS RESOLVED AND DEEPLY CONCERNED THAT IT WILL HAPPEN AGAIN. I HAVE SHARED VIDEO OF THE WARNING MESSAGES AND LIGHTS WITH THE DEALER, BUT AM UNABLE TO UPLOAD VIDEO HERE.

I HAVE OWNED 3 TOYOTA PRIUS AND SINCE I PURCHASED THIS 2016 PRIUS IN 09/2016. I HAVE HAD TO REPLACE THE WINDSHIELD TWICE SO FAR, 1 IN 09/2016 AND 06/2017. AND NOW HAVE CRACKED WINDSHIELD ALL CAUSE BY SMALL ROCK CHIP STARTING IN THE CORNERS OF THE WINDSHIELD. THIS IS GETTING RIDICULOUS, I HAVE NEVER HAD THIS ISSUE WITH OTHER 2 MODELS OR OTHER VEHICLE I HAVE OWNED.

LEASED THE VEHICLE FOR LESS THAN 1 YEAR AND HAVE EXPERIENCED 3 MAJOR CRACKS TO THE FRONT WINDSHIELD. THE FIRST ONE WAS CAUSED BY PROBABLY A SMALL ROCK WHILE DRIVING MID SPEED AND SPREAD IMMEDIATELY FROM THE PASSENGER-SIDE PERIMETER. THE SECOND ONE WAS CAUSED BY UNKNOWN, MAYBE A ROCK, AS I DID NOT SEE NOR HEAR ANYTHING BUT OVERNIGHT SAW A CRACK IN THE CENTER THAT SPREAD VERY QUICKLY. THE THIRD CRACK WAS CAUSED BY PROBABLY A SMALL ROCK THAT STARTED ON THE DRIVER'S SIDE PERIMETER. I HAVE OWNED NICER CARS THAN THE PRIUS AND ALSO ONES LESS PRESTIGIOUS. WHILE OWNING THESE CARS FOR 5+ YEARS AND DRIVING EXTENSIVELY, I HAVE NEVER, EVER SUFFERED MORE ROCK IMPACTS BY A WINDSHIELD THAT CAUSED EXTENSIVE DAMAGE THAN WHEN I HAVE DRIVEN THIS 2016 PRIUS. THIS CAR SHOULD BE RE-EXAMINED FOR SAFETY AND ANGLES. IN ADDITION, TOYOTA SUPPOSEDLY HAS HAD A BACKORDER OF THIS PARTICULAR TYPE OF WINDSHIELD AND HAS NOT ALLOWED AFTER-MARKET PRODUCTION SO I AM FORCED TO EITHER USE MY INSURANCE OR PAY AN EXORBITANT AMOUNT OUT OF POCKET.

I HAD PREVIOUS PROBLEMS WHEN I FIRST BOUGHT MY PRIUS WHERE I RECEIVED 2 CRACKS ON MY WINDSHIELD WITHIN A WEEK OF OWNING THE CAR. I NEVER HEARD A ROCK HIT MY CAR. I REPORTED IT HERE AND TOYOTA CALLED ME TO REPLACE MY WINDSHIELD SO THEY COULD KEEP MY OLD ONE FOR QUALITY CONTROL. I WAS FINE WITH THIS BUT JUST TODAY I GO OUT TO MY CAR AND SEE A 6 INCH CRACK THAT STARTED FROM THE BOTTOM OF THE WINDSHIELD THAT WASN'T THERE BEFORE AND I DIDN'T HEAR A ROCK HIT IT EITHER. I FEEL LIKE MY PRIUS WINDSHIELD PROBLEMS WILL NEVER EVER END

SINCE PURCHASE OF THE CAR, THE VEHICLE HAS SHIFTED FROM DRIVE TO NEUTRAL UPON BRAKING HARD. THIS HAS OCCURRED WHILE DRIVING ON THE FREEWAY. THE CAR WILL NOT RETURN TO DRIVE WITHOUT TURNING OFF THE ENGINE AND RESTARTING. IT IS NOT SAFE TO DRIVE. TOYOTA OF CARLSBAD COULDN'T REPRODUCE THE EVENT AFTER A FEW TRIES ON A TEST DRIVE, SO THEY WILL NOT DO ANYTHING ABOUT IT. I AM CONCERNED ABOUT HAVING A FATAL ACCIDENT WHILE DRIVING ON THE FREEWAY. THE EVENTS HAPPEN RANDOMLY.

UPON START UP THIS TOYOTA PRIUS VEHICLE EMITS FOUL SMELLING CHEMICAL AIR INTO THE CABIN OF THE VEHICLE. IT IS UNKNOWN HOW TOXIC THESE SMELLS ARE BUT AGGRAVATE RESPIRATORY CONDITIONS AND ASTHMATIC CONDITIONS. TOYOTA ACKNOWLEDGES THAT THEY HAVE A SERVICE BULLETIN WITH "THOUSANDS" OF COMPLAINTS FROM CONSUMERS REPORTING NOXIOUS AIR BEING EMITTED INTO THE CABIN OF THE VEHICLE. HOWEVER THEY ARE REQUIRING CONSUMERS TO PAY FOR FIXES, EVEN IF THE CONSUMER HAS A FULL WARRANTY FOR MANUFACTURER DEFECTS. THIS VEHICLE ONLY HAS ABOUT 9.2K MILES ON IT (2016) AND IS GETTING WORSE. THE PROBLEM ALWAYS HAPPENS ON VEHICLE START UP WHEN AT REST, ESPECIALLY IN WARM AMBIENT CONDITIONS. THE AC WILL BE FOUL AND NOXIOUS. IN COLD TEMPERATURES THE FIRST FEW MINUTES OF HEATING WILL ALSO EMIT FOUL AND NOXIOUS ODORS. SERVICE LINE AT DEALERSHIP ACKNOWLEDGE THESE COMPLAINTS ARE HERE BUT WILL NOT EFFECT REPAIRS UNDER DIRECTION OF TOYOTA CORPORATE. ALL REPAIRS FOR MANUFACTURING DEFECT FOR TOXIC AIR HAVE TO BE PAID FOR BY THE CUSTOMER. S

VEHICLE WAS STATIONARY SITTING IN DRIVEWAY. FIRST CRACK STARTED AND CONTINUES TO SPREAD. SECOND CRACK STARTED 3 WEEKS AFTER THE FIRST. WINDSHIELD REPLACEMENT SUPPOSEDLY ON BACKORDER. THE CAR IS TYPICALLY PARKED IN A PARKING GARAGE DURING THE WORKWEEK AND EITHER IN MY DRIVEWAY OR GARAGE. THE CAR IS NOT EVEN 2 YEARS OLD. TO REPLACE WINDSHIELD ALSO MEANS HAVING TO RECALIBRATE FOR SIDE AND BACK UP MIRRORS TO FUNCTION PROPERLY WHICH IS JUST AS COSTLY AS HAVING TO PAY FOR THE WINDSHIELD.

TL* THE CONTACT OWNS A 2016 TOYOTA PRIUS EQUIPPED WITH YOKOHAMA BLUEARTH S34 TIRES, SIZE: P215/45R/17 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY BECAME UNSTABLE AND A THUMPING NOISE WAS PRESENT COMING FROM THE REAR END. AFTER STOPPING THE VEHICLE AND INSPECTING IT, THE CONTACT DISCOVERED THAT THE REAR DRIVER SIDE TIRE WAS FLAT. AFTER REMOVING THE TIRE, IT WAS DISCOVERED THAT THE SIDEWALL BLEW OUT INSIDE THE TIRE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE TIRE AND VEHICLE MANUFACTURER WERE BOTH NOTIFIED ALONG WITH THE LOCAL TIRE DEALER (LES SWAUB AND GOODYEAR). THE VIN AND DOT NUMBER WERE UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 15,900.