2004 TOYOTA PRIUS Complaints

I WAS DRIVING APPROX. 15 MPH ON A STREET ON 5/14/20 AND WAS MAKING A SOFT TURN AND HEARD A 'CLICK' NOISE. IMMEDIATELY AFTER MY STEERING WHEEL BEGAN TO SPIN FREELY WHILE TOTALLY DISENGAGED FROM THE FRONT WHEELS CAUSING TOTAL INABILITY TO CONTROL DIRECTION OF VEHICLE TRAVEL. THIS CAUSED A MINOR COLLISION WITH ROCK /DEBRIS WHICH CAUSED MINOR FRONT BUMPER DAMAGE. I THEN HAD VEHICLE TOWED TO NEAREST MECHANIC WHO DETERMINED THAT THE MAIN BOLT AT THE INTERMEDIATE STEERING SHAFT AND STEERING RACK WAS DISCONNECTED. THE MECHANIC CHECKED THE SHAFT AND SPLINES FOR DAMAGE AND FOUND NONE, THEN PROCEEDED TO REATTACH BOLT. I WAS ALSO INFORMED BY THIS MECHANIC THAT TOYOTA HAD TWO RELATED RECALLS: ONE FOR THE STEERING SHAFT, AND ONE FOR THE INTERMEDIATE STEERING SHAFT EXTENSION. BOTH OF THESE RECALLS HAD BEEN ADDRESSED AND REPLACEMENT PARTS INSTALLED FOR MY VEHICLE. THERE ARE TWO RELATED RECALLS: 06V188000 (STEERING SHAFT) AND 12V537000 (INTERMEDIATE STEERING EXTENSION SHAFT). *TR

HEADLIGHTS OCCASIONALLY GO OUT AT RANDOM WHILE DRIVING. BEGAN WITH DRIVER SIDE, VERY INTERMITTENT, BECAME MORE FREQUENT, NOW ALSO INCLUDES PASSENGER SIDE. BOTH HAVE GONE OUT AT THE SAME TIME WHILE DRIVING AT NIGHT TWICE. TURNING ALL LIGHTS OFF BRIEFLY AND BACK ON WILL RE-ILLUMINATE THE HEADLIGHTS. PROBLEM FIRST OCCURRED SEVERAL MONTHS AGO AND HAS GOTTEN PROGRESSIVELY MORE FREQUENT. NOW, ONCE LIGHT(S) GOES OUT DURING A DRIVE, IT WILL CONTINUE TO DO SO REPEATEDLY EVERY FEW MINUTES. VERY DANGEROUS.

HEADLIGHT GO OUT DAILY AND HAPPENS WHILE DRIVING AT NIGHT FROM WORK, THEY TURN BACK ON SWITCH ON AND OFF

COMBINATION METER IS BLACK 90% OF THE TIME. RESTARTING ENGINE OR DISCONNECTING BATTERY ONLY WORKS ON OCCASION. HAVE SAFETY CONCERNS.

WHEN STOPPING SUDDENLY SOMETIMES THE BRAKES ON MY 2004 PRIUS WOULD NOT RESPOND IMMEDIATELY AS THEY SHOULD. THEY WOULD RELEASE THE CALIPERS COMPLETELY AND THE ONLY WAY TO STOP WOULD BE TO LET OFF THE BRAKES AND PRESS THEM AGAIN. IT DOES NOT HAPPEN OFTEN BUT IT IS REGULAR ENOUGH THAT THIS HAS ALWAYS CONCERNED ME VERY MUCH. TODAY I WAS FOLLOWING A CAR WHO SLAMMED ON THEIR BRAKES VERY SUDDENLY AND THEREFOR I ALSO HAD TO SLAM ON MY BRAKES. THIS SAME ISSUE OCCURRED AND I DID NOT HAVE TIME TO RELEASE THE BRAKES AND PRESS THEM AGAIN CAUSING ME TO HIT THE BACK OF THE CAR THAT I WAS FOLLOWING. I MAINTAIN MY CARS VERY WELL AND THIS CAR WAS IN TOP CONDITION WITH BRAND NEW TIRES. THE BRAKES DO NOT EVEN ACTIVATE ENOUGH TO SQUEAL OR LEAVE ANY RUBBER BEHIND. THERE IS NO WAY THAT I COULD POSSIBLY HAVE STOPPED IN TIME. THIS IS NOT SAFE AND NEEDS TO BE RESOLVED FOR OTHER PEOPLE WHO HAVE THESE CARS.

BRAKE ACTUATOR ASSEMBLY MALFUNCTIONED, AND HAD TO BE REPLACED, JUST AS PREDICTED IN TOYOTA'S WARRANTY ENHANCEMENT ZG1. TOYOTA KNOWS THE PART IS DEFECTIVE, BUT THEY REFUSED TO REPLACE IT UNTIL IT FAILED, AND MINE DID NOT FAIL UNTIL AFTER THE EXTENDED WARRANTY DEADLINE. THIS FAILURE HAPPENED ON I-45 NEAR MADISONVILLE AND I HAD TO PULL OFF THE ROAD BECAUSE A WARNING LIGHT BRAKE LIGHT WENT ON.

WHEN DRIVING DOWN THE ROAD ALL OF A SUDDEN WE TRIED TO USE THE BRAKES AND IT FELT LIKE WE ONLY HAD 10% OF OUR BRAKING ABILITY. THE BRAKE LIGHT CAME ON AND ABS LIGHT WENT ON AND THE STABILITY CONTROL LIGHT CAME ON AS WELL AS A WARNING BUZZER. IT FELT LIKE WE HAD MANUAL BRAKES.

TL* THE CONTACT OWNS A 2004 TOYOTA PRIUS. THE CONTACT STATED THAT THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 12V537000 (STEERING) BY BALISE TOYOTA (1399 RIVERDALE ST, WEST SPRINGFIELD, MA 01089, (413) 306-3037), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE POWER STEERING WARNING INDICATOR ILLUMINATED AFTER THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 138,000.

I AM THE OWNER OF A 2004 PRIUS. AFTER BUYING MY CAR USED 2 YEARS AGO I NOTICED THAT ONCE IN AWHILE THE DISPLAY, INCLUDING FUEL CONSUMPTION, SPEEDOMETER, ODOMETER, AND MORE, WOULD NOT LIGHT UP AND THAT THE CAR WOULD NOT TURN OFF EASILY SEVERAL TIMES I HAVE BEEN IN SITUATIONS WHERE I HAVE LITTLE GAS AN AM UNABLE TO SEE MY GAS GAUGE OR KNOW HOW FAT IAM GOING ON THE HIGHWAY. I UNDERSTAND THAT THIS WAS ONCE COVERED BY TOYOTA UNDER THE WARRANTY EXTENSION BUT IS NOT CONSIDERED A SAFETY CONCERN. THE WARRANTY EXTENSION IS EXPIRED. IN WHAT UNIVERSE ARE A FUNCTIONING FUEL GAUGE AND SPEEDOMETER NOT CONSIDERED A SAFETY CONCERN? I AM ALSO CONCERNED THAT THIS WILL DETERIORATE FURTHER AND CAUSE AN ACCIDENT.

(COMBINATION METER PROBLEM) WHILE DRIVING AT NIGHT ON THE FREEWAY THE ENTIRE INSTRUMENT PANEL (DASH BOARD) STARTED BLINKING ON AND OFF. FOR OUR SAFETY, WE DECIDED TO SLOW DOWN AND EXIT THE FREEWAY AND STOP IN A SAFE AREA. WE TURNED THE IGNITION OFF, THEN STARTED THE CAR, WITH NOTHING APPEARING ON THE INSTRUMENT PANEL BESIDE THE CHECK ENGINE LIGHT. WE LOST THE SPEEDOMETER, ALL GAUGES AND ALL THE ELECTRICAL AND ELECTRONICS WHICH NORMALLY HELPS TO GUIDE OUR DRIVING.WE HAD TO TAKE THE CAR TO THE TOYOTA DEALER THE FOLLOWING MORNING WHICH TOOK SEVEN DAYS TO REPLACE THE COMBO METER. I LATER FOUND OUT THAT THIS ISSUE IS NOT KNEW AND THERE WAS A LETTER ISSUED BY TOYOTA TITLED (2004 TO CERTAIN 2009 MODEL YEAR PRIUS VEHICLES COMBINATION METER WARRANTY ENHANCEMENT NOTICE). THE LETTER STATED THAT THEY HAD PROBLEMS WITH SOME OF THESE PRIUS YEAR MODELS AND THAT IF THE OWNER DID NOT EXPERIENCE THIS CONDITION TO FILE THE LETTER IN THEIR VEHICLE'S OWNER'S WARRANTY INFORMATION BOOKLET. HERE IS MY REQUEST: THIS SHOULD NOT BE A WARRANTY ISSUE BUT SHOULD HAVE BEEN A SAFETY RECALL AS DEPENDING OF THE NUMBER OF MILES THE VEHICLE IS DRIVEN, THIS ISSUE SEEMS TO SOONER OR LATER OCCUR. I REPAIRED MY VEHICLE AND PAID FOR ALL THE REPAIRS, ALL I NEED NOW IS FOR THE NHTSA TO LOOK INTO THIS PROBLEM, INVESTIGATE IT AND HAVE TOYOTA SEND A RECALL LETTER RATHER THAN AN EXTENDED WARRANTY. THIS WAY I CAN RECEIVE A REIMBURSEMENT FOR THE REPAIRS. HERE IS A LINK TO THE LETTER AND ALL CONSUMERS COMPLAINTS: HTTPS://WWW.TOYOHEADQUARTERS.COM/THREADS/2004-2009-TOYOTA-PRIUS-COMBINATION-METER-WARRANTY-EXTENSION-ZTV.174/ I BELIEVE FOR THE SAFETY OF ALL PRIUS DRIVERS IN THE USA, THIS SHOULD BE CHANGED TO A RECALL SINCE MANY OF THESE MODEL AND YEAR PRIUS VEHICLES ARE STILL ON THE ROAD AND WILL REACH A CERTAIN MILEAGE TO MAKE TO COMBINATION METER FAIL.