2006 TOYOTA PRIUS Complaints

In June of 2018 My brake actuator failed on my 2006 Prius. At that time I had 169,689 miles on the vehicle. I had the part replaced at Autonation, a Toyota dealership for $2626 . Recently I had noticed that while sitting at a stoplight I was hearing a tapping noise at the brakes along with what they refer to as a 'seal bark'. The same sounds the car was making just before the actuator failed three years before. A few days later I was driving south on highway 19 in Saint Petersburg during a light rainstorm. Traffic slowed quickly in front of me. I pressed on the brake pedal and the brakes locked up. The ABS was not working. I was barely able to avoid a crash. On September 27th I took the car to the same Toyota dealership that had replaced the actuator three years earlier. I told them about the noises at the brakes and told them these were the same sounds the car was making when the actuator failed the first time. They checked it out and told me that everything was working fine and that the car was not issuing any error codes. They could hear the same noises that I could, but said that I would need to continue to drive the car until the actuator failed to the point that it lit up dash lights or issued error codes. I logged on to PriusChat to search for what other people were seeing. I am not alone in this. Many others have had the same experience with the dealerships saying 'drive it till it fails'. Drive it until you lose your brakes? If I'm in this situation, then how many other Prius owners are driving around with dangerous brakes. I have no choice but to wait until the failure gets worse. If you search results on PriusChat for 'actuator', I think you will see that this probably means that there are thousands of cars just like mine out there on the roads. I got 169,689 miles out of the first actuator and just 22,000 out of the second one. Based on what I've seen on PriusChat, the new part seems to be worse than the original part.

Discovered through failures repeated to dealers that certain items (Brakes, dashboard, et. al.) were recalled by Toyote. Never received recall notices. Contacted Toyota who demanded the vehicle be taken to dealer and now refuses to do anything. Have complete documentation to attach to this communication. Essentially: Dashboard failed, brakes failed when auto in operation. Likely there are UNKNOWN additional recalls, etc. of which we were not noticed

Vehicle, upon turning on ignition/starting and putting in either drive or reverse gear, on level surface with brakes still applied will roll forward or backward. This has happened several times but usually at first start up for the day No warning lights(brake or other) are displayed Brake pedal is firm /no problems with pads/shoes ,brakes work fine any other time. I have called the local toyota dealer and toyota(company) and told them about this safety issue but was told i would have to pay to get it diagnosed . No one other than my wife child and i experienced this problem . Fortunately no one has gotten hurt. Was suprised to learn that this problem is not a part of a recall.

The contact owns a 2006 Toyota Prius. The contact stated that while driving at an undisclosed speed, the vehicle lost power and immediately regained power. Approximately 24 hours later the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the hybrid water pump was faulty and needed to be replaced. The vehicle was repaired. The local dealer was contacted and informed the contact that the vehicle was not included in the NHTSA campaign number 12V536000 (Engine and Engine Cooling, Hybrid Propulsion System). The contact indicated that the vehicle experienced the failure listed in the recall. The failure mileage was 167,000.

The contact owns a 2006 Toyota Prius. The contact stated that the vehicle intermittently failed to shut-off as needed with several unknown warning lights illuminated. The contact had taken the vehicle to the dealer on three separate occasions and the mechanic was able to either disconnect the battery or shut-off the vehicle as designed. The manufacturer had been notified of the failure and informed him that the vehicle was out of warranty and that there were no recalls on the vehicle. The contact filed a case with the manufacturer. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 160,000. Consumer stated Toyota is refusing to responsibility even with extended warranty if problem occurred after 2012.

Hi, After being parked for about 1.5 hrs my back seat on the drivers side caught on fire. I understand this is where a battery is and that newer cars of this brand have had recalls for this problem.

The contact owns a 2006 Toyota Prius. While receiving an oil change by an independent mechanic, the contact was informed that there was a large crack to the engine cradle located on the undercarriage. The contact was informed by the mechanic that the vehicle was unsafe to drive. The contact notified the manufacturer of the failure and was informed that the VIN was not under recall. The vehicle was not repaired. The failure mileage was approximately 159,000.

THE TOYOTA PRIUS 2006 WAS HIT FROM BEHIND (REAR ENDED) ON 05/13/2021 AND DRIVER'S SEAT COLLAPSED BACKWARDS, CAUSING A HEAD INJURY. THIS WAS NOT EXPECTED AND IS NOT ACCEPTABLE BY ANY SAFETY STANDARD. FORTUNATELY THERE WERE NO OTHER OCCUPANTS IN THE VEHICLE. THIS WAS A CHAIN COLLISION AND THE PRIUS WAS STATIONARY WHEN IT WAS HIT IN A SECONDARY COLLISION AND STILL THIS HAPPENED, WHAT IF OUR CAR WAS HIT IN THE PRIMARY COLLISION OR WHAT IF THERE WAS A CHILD ON THE BACK SEAT?! THE VEHICLE IMMEDIATELY BEHIND WAS ALSO STATIONARY BEFORE IT EXPERIENCED THE FIRST ORDER COLLISION. THESE SEATS DESERVE A SAFETY RECALL. ONE CAN FIND MANY OTHER SEAT COLLAPSING EVENTS, EVEN WITH CHILDREN KILLED OR BRAIN DAMAGED ON BACK SEATS. PLACE OF THE ACCIDENT: THE CHESAPEAKE EXPRESSWAY (168). ACCIDENT REPORT ATTACHED.

THE BRAKE BOOSTER IS MAKING LOTS OF CHIRPING NOISE WHEN THE BRAKE PEDAL IS DEPRESSED. WHILE I AM NOT GETTING ANY VISUAL INDICATORS OF FAILURE AT THIS MOMENT I BELIEVE (DUE TO MY OWN RESEARCH) THAT WHEN I DO THERE IS A HIGH CHANCE OF ME GETTING INTO A CAR ACCIDENT. I HAVE READ ON PRIUSCHAT.COM THAT SEVERAL PEOPLE HAD BRAKE FAILURE DUE TO THE FAULTY PUMP WHICH CAUSED A CAR WRECK. THIS IS A DANGEROUS PREDICAMENT TO BE IN AND TOYOTA SHOULD EXTEND THEIR WARRANTY TO COVER THE FAULTY EQUIPMENT THEY HAVE INSTALLED ON THESE VEHICLES BEFORE SOMEONE GETS SERIOUSLY HURT OR DIES.

WHILE VEHICLE WAS IN MOTION ON A CITY STREET, AND ALSO UPON BACK ROADS, THE BRAKES IN MY 2006 TOYOTA PRIUS SEEMED TO GRAB. THERE WAS ALSO A LOUD NOISE UPON BRAKING. THIS ISSUE WORSENED AND THE DASH LIGHTS LIT UP. I TOOK TO LOCAL TOYOTA DEALERSHIP AND IT WAS DETERMINED THAT THE BRAKE ACTUATOR NEEDS TO BE REPLACED DUE TO SAFETY ISSUE OF BRAKES GOING OUT IN THE FUTURE. (NOT IF BUT WHEN). I WAS TOLD WHEN THE BRAKES GO OUT, I AM TO PUSH THE EMERGENCY BRAKE AND THE VEHICLE WOULD COAST TO A STOP. THIS IS AN UNSAFE CONDITION AND COULD HAPPEN WHILE BRAKING FOR A RED LIGHT OR BRAKING TO AVOID HITTING A DEER. THE COST TO FIX THIS BRAKE ACTUATOR ISSUE WILL BE APPX $3000. UPON FURTHER RESEARCH, TOYOTA KNEW OF THE ISSUE AND OFFERED AN EXTENDED WARRANTY THAT EXPIRED DEC 2017. THERE ARE SEVERAL OTHER COMPLAINTS OF THIS SAME ISSUE WITH OTHER '06 PRIUS OWNERS OF THIS HAPPENING BEFORE AND AFTER THE WARRANTY EXPIRED IN DEC OF 2017. THIS IS A SAFETY ISSUE WHICH COULD CAUSE INJURY OR DEATH WHEN THE BRAKES DO STOP WORKING AND NEEDS TO BE A RECALL, NOT AN EXTENDED WARRANTY THROUGH TOYOTA THAT EXPIRES.