2016 TOYOTA PRIUS Complaints

Overheating light began flashing while driving 5/21/22. Drove to Napa Auto Parts and saw coolant reservoir was empty. Bought anti-freeze and filled reservoir. Upon arrival at destination, reservoir was empty again. Filled it again. Upon the next morning, reservoir was empty again. Took it to an auto-shop which found that the exhaust heat exchanger in my car has failed and is leaking coolant. Please see Applicable technical service bulletin, T-SB 0135-19. While the car is less than 96 months old, it is above 80k miles. I see this issue has been escalated in California, where the warranty is for 96 months and 150k miles. Want to report that the change in miles between states is disappointing. This issue is common and should be handled as a known recall, not just a known issue.

My steering wheel controls, including odometer, cruise control, horn, and airbag light is on. I took it to the dealership and they said it is the spring (clocking) cable in the steering wheel. Looking up a recall there are quite a few years and models where this exact issue has been recalled on Toyotas, but the dealership says my 2016 Toyota Prius is not cover (same exact issue). I submitted a ticket through Toyota customer service but they have done nothing about this safety issue for the 2016 Toyota Prius. I see lots of blogs and complaints because the airbag default warning light stays lit, so I assume airbag is not functional. I found a site that says to put the complaint through here.

While going 70 MPH, I hid a feral hog. Although the front end of my car crumpled up, and we came to a sudden stop, the air bags did not deploy.

Our car has approximately 65K miles on it. THREE of the door lock actuators have failed already. This is terrifying that we might not be able to lock or unlock doors in an emergency particularly with our kids in the back seat. We have had our Prius serviced regularly by an independent well regarded local hybrid car mechanic and they think it is very odd that these have all failed so quickly.

The active grille shutter system failed due to debris. There is a bulletin already that references error code P05A072 - active grille shutter stuck open. The code I got was P059F73 - active shutter grille stuck closed. Not sure why it wasn’t included in the original bulletin when the cause and part are the same. This seems to be a known problem with this vehicle that can lead to engine overheating. Bulletin referenced was T-SB-0319-17.

The contact owned a 2016 Toyota Prius. The contact stated that while switching lanes, the vehicle was rear-ended by another vehicle driving at 30 MPH. The contact's front driver's side seat backrest inadvertently moved backward, which caused her shins to hit the dashboard under the steering wheel during impact. None of the air bags deploy upon impact. The contact later received medical attention at the hospital for injuries to her shins. A police report was filed. The vehicle was towed to a tow yard and deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.

Over the course of the last year, I have noticed an increasingly louder clicking noise coming from the front left (driver side) wheel area upon breaking. The noise goes away if I shift into neutral, so I'm nearly positive that this is related to the axle/CV joint. I've also conducted extensive research on this issue and it is a common problem encountered by other Gen4 Prius owners. Toyota even issued a TSB for this issue in December of 2018 (T-SB-0157-18), NHTSA No. 10153229. My car had its powertrain warranty lapse earlier this year, but I know for a fact that this has been covered out of warranty because I've corresponded with other Prius owners who had Toyota cover the repair of this defect/glitch. I am trying to avoid a catastrophic breakdown of my CV joint if I'm driving on the highway and I'd appreciate it if NHTSA would be able to compel Toyota to help with the repair of this issue. I've had no luck dealing with either the dealership, or the corporate office at Toyota. They do not seem to be taking any ownership of this issue nor taking demonstrating any accountability.

Moments ago, I entered my 2016 Toyota Prius to find that my windshield had mysteriously cracked while parked over night. The crack was not present when I last drove the car last night. Based on some online research for windshield replacement cost, I've learned that Toyota was faced with a class action lawsuit regarding 2016-17 Toyota Prius containing defective windshields; in which these windshields are known to unexpectedly crack while parked or under ordinary driving conditions. Furthermore, my Toyota Prius is equipped with safety features (such as pre-collision system, lane departure alert with steering assist, automatic high beams and full-speed dynamic radar cruise control) that require a front camera to function properly. The cracked windshield now interferes with the camera's visibility, line of sight and perceived orientation, thus causing me to feel unsafe while driving the vehicle. I am filing this compliant because I am now faced with not only an unsafe vehicle to operate, but also the cost to fix a windshield that is known to be defective from Toyota.

I bought my 2016 Prius brand new in November of 2016. Over the past 2 years or so my OEM leather like steering wheel wrap started to wrinkle. it is now cracking and starting to peel. it hasn't caused any stealing control issues, it is just ugly an slight distracting on the palm of the hand. I do worry that if might start causing gripping issues on that side of the steering wheel if the wrap becomes loose.

I was hit when someone ran a stop sign. Pushed into oncoming traffic and hit a truck. My Toyota Prius was totaled. No air bags deployed. Seatbelt did not tighten either. I have contacted Toyota. Someone retrieved the data from recorder. I have a copy but it was to long to send with pics. Toyota claim # [XXX] (sorry for one pic I couldn’t delete) INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”